Documente Academic
Documente Profesional
Documente Cultură
Base Plate:It acts as a support for all different components to be mounted. This piece is made of mild steel (MS).
Side Pillars:It acts as a support or guide on which the moving jaw moves. On its upper end, it supports top plate. This piece is made of mild steel.
On one sides turning was done by centre lathe machine while on the other side, turning and threading was done by lathe machine.
Top Plate:It is the plate which acts as a mounting support for the box nut. This piece is made of mild steel.
Fixed Jaws:Two fixed jaws act as support on which the pipe (for job operation) is mounted. This piece is made of mild steel.
Moving Jaws:To fabricate this part, the following steps were taken: 1. The initial dimension was 1157023 mm. 2. Side facing was done on plane shaper. 3. Facing was done on centre lathe machine. 4. A hole was drilled in the centre for the lead screw.
Box Nut:It is mounted on the top plate so as to fabricate the movement of the lead screw. It has internal threading. This piece is made of mild steel.
Lead Screw:This is the main screw thread used for moving the moving jaw up and down. The lead screw has external threads where the box nut has internal threads so as to drive the screw. This piece is made of mild steel.