Documente Academic
Documente Profesional
Documente Cultură
IMPORTANT: Provide this information to employees, customers, and users of this product. Read this MSDS before handling or disposing of this product. This product is covered by the OSHA Hazard Communication Standard and this document has been prepared in accordance with requirements of this standard.
Company Identification Vertical Partners West, LLC Venom, Atomik RC, Steerix 14028 N. Ohio Street, Rathdrum, Idaho 83858 General Business General Business CHEMTREC 1-800-705-0620 1-208-712-3053 1-800-424-9300
Product Identification Venom Power Lithium Polymer Batteries Rechargeable Lithium Polymer (LiPO) Lithium Ion (Polymer); Secondary Battery; Rechargeable
Page 1 of 13 Copyright 2013 Vertical Partners West, LLC. All rights reserved.
20C 8000mAh 7.4v 2-Cell LiPO Hard Case - UNI 10C 7.4v 1250mAh 2-Cell LiPO Battery 10C 11.1v 800mah 3-Cell LiPO Battery 25C 3S 7500mah 11.1v LiPO - Uni 20C 3200mah 7.4v 2-Cell R/C Car LiPO UNI - Hard Case 20C 4000mah 7.4v 2-Cell R/C Car LiPO UNI - Hard Case 20C 5000mah 7.4v 2-Cell R/C Car LiPO UNI - Hard Case 25C 2S 3300mah 7.4v LiPO Hardcase - Uni 25C 2S 4100mah 7.4v LiPO Hardcase - Uni 25C 2S 5000mah 7.4v LiPO Hardcase - Uni 10C 1600mah 7.4v 2-Cell RX LiPO FLAT 10C 1200mah 7.4v 2-Cell RX LiPO HUMP 20C 3S 2100mah 11.1v LiPO - UNI 20C 3S 4000mah 11.1v LiPO - UNI Plug 20C 3S 5400mah 11.1v LiPO - UNI Plug 20C 3S 5000mah 11.1v LiPO - UNI Plug 25C 120mah 3.7v LiPO - MCX 25C 150mah 3.7v LiPO - MCX 15C 2S 250mah 7.4v LiPO Battery - 1/24 Losi 20C 3S 850mah 11.1v LiPo Battery + Bullet Connector 20C 3S 950mah 11.1v LiPo Battery + Bullet Connector 25C 1S 250mAh 3.7V LiPO Blade MCPX 2400 mah 7.4v 2-cell LiPO RX Flat pack 2100 mah 7.4v 2-cell LiPO RX Hump pack 20C 2S 430mah 7.4v LiPO Batt w/JST 20C 2S 800mah 7.4v LiPO Batt w/JST 20C 4S 2100mah 14.8v LiPO for Starter Box 13C 2S 1320mah 7.4v LiPO w/JST 13C 3S 1320mah 11.1v LiPO - UNI 20C 3S 3200mah 11.1v LiPO - UNI 20C 2S 5400mah 7.4v R/C Car LiPO UNI 20C 3S 6400mah 11.1v R/C Car LiPO - UNI 20C 2S 8000mah 7.4v R/C Car LiPO - UNI 3000mah 11.1v TX Pack - M11 - MX3 2400mah 11.1v TX Pack - Z-1, Helios 30C 4S 3200mah 14.8v 4-Cell LiPO Battery 30C 5S 3200mah 18.5v 5-Cell LiPO Battery 30C 6S 3200mah 22.2v 6-Cell LiPO Battery 25C 4S 3600mah 14.8v 4-Cell LiPO Battery 25C 5S 3600mah 18.5v 5-Cell LiPO Battery 25C 6S 3600mah 22.2v 6-Cell LiPO Battery 25C 4S 5000mah 14.8v 4-Cell LiPO Battery 25C 5S 5000mah 18.5v 5-Cell LiPO Battery 25C 6S 5000mah 22.2v 6-Cell LiPO Battery 20C 2S 2000mah 7.4v LiPO Battery UNI 20C 3S 1300mah 11.1v LiPO Batt UNI
Page 2 of 13 Copyright 2013 Vertical Partners West, LLC. All rights reserved.
25C 6S 2500mah 22.2v LiPO 35C 3S 5000mah 11.1v LiPO - UNI 35C 4S 5000mah 14.8v Hard Case Lipo 35C 5S 3800mah 18.5v Hard Case Lipo 25C 6S 3200mah 22.2v Hard Case Lipo 50C 2S 5000mah 7.4v Hard Case Lipo 50C 4S 5000mah 14.8v Hard Case Lipo 50C 2S 4500mah 7.4v Saddle Pack Hard Case 40C 3S 2200mAh 11.1V LiPO Battery - Uni 50C 1S 5000mah 3.7v Hardcase LiPo - UNI 50C 3S 2200mah 11.1v LiPO Battery - UNI 30C 3S 3200mah 11.1v LiPO Hardcase - UNI 50C 4S 2500mah 14.8v LiPO Battery 50C 5S 2500mah 18.5v LiPO Battery 50C 6S 2500mah 22.2v LiPO Battery 50C 4S 3600mah 14.8v LiPO Battery 50C 5S 3600mah 18.5v LiPO Battery 50C 6S 3600mah 22.2v LiPO Battery 50C 4S 5000mah 14.8v LiPO Battery 50C 5S 5000mah 18.5v LiPO Battery 50C 6S 5000mah 22.2v LiPO Battery 40C 4S 3500mah 14.8v LiPO Hrdcase - UNI 40C 2S 4000mah 7.4v Sport Power LiPO-UNI 40C 2S 5000mah 7.4v Sport Power LiPO-UNI 50C 2S 5000mah 7.4v Sport Power LiPO-UNI 50C 3S 5000mah 11.1v LiPO - UNI 60C 2S 5000mah 7.4v Hardcase LiPO - UNI 60C 2S 5600mah 7.4v Hardcase LiPO - UNI 60C 2S 3800mah 7.4v LiPO Hardcase - UNI 70C 2S 7.4V 7000mAh LiPO Hard Case - UNI 70C 4S 14.8V 6300mAh LiPO Hard Case - UNI 70C 1S 3.7V 6300mAh LiPO Hard Case - UNI 35C 2S 7.4V 10000mAh LiPO - UNI 35C 2S 7.4V 5200mAh LiPO - UNI 35C 2S 7.4V 8000mAh LiPO - UNI 35C 3S 11.1V 3300mAh LiPO Hard Case - UNI 70C 2S 5300mah 7.4v Hardcase LiPO - UNI 70C 4S 5300mah 14.8v Hardcase LiPO - UNI 70C 2S 5800mah 7.4v Hardcase LiPO - UNI 20C 2S 4500mAh 7.4V LiPO w/ Voltage Check - UNI 35C 4S 4500mAh 14.8V lip w/ Voltage Check - UNI 25C 2S 10000mAh 7.4V LiPO - UNI 30C 5000mah 7.4v LiPO Deans + Sockets 35C 3800mah 7.4v LiPO Deans + Sockets 30C 4200mah 7.4v LiPO Saddlepack 40C 5000mah 7.4v LiPO Battery Hard Case 20C 4000mah 7.4v LiPO fits Tamiya Cars 50C 5000mah 7.4v Hardcase LiPO
Page 3 of 13 Copyright 2013 Vertical Partners West, LLC. All rights reserved.
RC Models that Contain a LiPO Battery: 6050 845623007629 6053 845623011459 6054 845623015341 6055 845623015358 6056 845623016690 6057 845623016768 6201 845623002754 6206 845623007025 6242A 845623009968 6242B 845623010087 6242C 845623010094 C6035 845623038043 C6036 845623038050 C6039 845623038067 C6041 845623038029 C6042 845623038036 C6043 845623038012 C6044 845623037978 C6045 845623037985 C6047A 845623037992 C6047B 845623038005 JA10-1-7191 JP03-8040-2 mDX186 mDX188 mDX189 mSP190 SN06-5073-2 SN07-5089-2 SN08-5103-2 JA12-7210-2 WK-GeniusV2Devo7 WK-InfraX-Devo4 WK-V120D02S WK-4F200LM 18000 18000BLEM WK-V200D03 WK-LBV2-Devo4 WK-LBV2-F4 845623033536 845623033581 845623038074 845623038081 845623038098 845623038104 845623033291 845623033307 845623033314 845623035608 845623039118 845623039088 845623039095 845623039149 845623027528 845623032386 845623039170 845623039071 845623039064
Venom Kona Kopter - 1S 110mah 3.7V Venom Kodiak Helicopter 1S 500mah 3.7V Venom Switch - 1S 90mah 3.7mah Apache Micro V-Pro Venom Ozone Elite Venom Beacon Black Hawk Helicopter - 1S 110mah 3.7V Micro Troop Transporter - Desert 1S 110mah 3.7V Micro Troop Transporter - Jungle 1S 110mah 3.7V Micro Troop Transporter - Sea 1S 110mah 3.7V X2 Max Flight 4CH RTF Micro RC Heli RA-52 4CH RTF Micro RC Heli Lama 4Ch RTF Micro RC Heli Fly Soccer 3CH RTF RC Heli Fly Soccer Mini 3CH RTF RC Heli Lady Bug 4CH RTF Micro RC Quadcopter UFO 4CH RTF Micro RC Quadcopter AirShip 3CH RTF Micro RC Heli Scorpion S-Max RTF Micro RC Multi Rotor Heli Scorpion S-Max RTF Micro RC Multi Rotor Heli - Silver A-10 Thunderbolt RC Jet PNP - Desert Camo - w/ESC and Servos Sky Surfer RC Airplane RTF - White Thunder RTF Mini 4CH RC Heli Travel Copter RTF Mini 4CH RC Heli Police RTF Mini 4CH RC Heli Superfine RTF Mini 4CH RC Heli A-10 Thunderbolt RC Jet RTF - Desert Camouflage Mig-29 RC Jet RTF - Blue/Red F-15 RC Jet RTF - Red/Blue Explorer RC Jet RTF - EDF Version Genius CP V2 6Ch RTF Heli w/ Devo7 InfraX RTF Quadcopter w/ Devo4 V120D02S 6Ch RTF Heli w/ Devo7 4F200LM 6Ch RTF Heli w/ Devo7 Atomik Whiplash 24 RTR Electric RC Boat Atomik Whiplash 24 RTR Electric Boat-BLEM V200D03 6Ch RTF Heli w/ Devo7 Ladybird V2 RTF Quadcopter w/ Devo4 Ladybird V2 RTF FPV Quadcopter w/ Devo F4
Page 4 of 13 Copyright 2013 Vertical Partners West, LLC. All rights reserved.
Master CP 6Ch RTF Heli w/ Devo7 V450D01 6Ch RTF Heli w/ Devo10 V450D03 6Ch RTF Heli w/ Devo7 J3 CUB ARF Brushless RC Airplane J3 CUB RTF Brushless RC Airplane Invader RTF RC Airplane Smart-K RTF RC Airplane Smart-K ARF Brushless RC Airplane Smart-K RTF Brushless RC Airplane Mad Shark F1 RTR RC Boat Offshore Warrior Lite RTR RC Boat Offshore Sea Rider Lite RTR RC Boat 1/18 Barren 4WD BL RTR Buggy 1/18 Mastadon 4WD BL RTR Monster Truck 1/18 Tyronno 4WD BL RTR SC Truck 1/18 Spino 4WD BL RTR Buggy 1/18 Centro 4WD BL RTR Truggy 1/10 Bowie 4WD BL RTR Monster Truck 1/10 Spatha 4WD BL RTR SC Truck 1/10 Tanto 4WD BL RTR Buggy 1/10 Katana 4WD BL RTR Truggy 1/4 Burstout RTR Motorcycle 1/8 Raider 4WD RTR Monster Truck 1/8 Mayhem 4WD RTR SC Truck 1/8 Shootout 4WD RTR Buggy 1/8 Ziege 4WD RTR Truggy Super Cub ARF Brushless RC Airplane Super Cub RTF Brushless RC Airplane Freeman 1600 ARF RC Glider Freeman 1600 RTF RC Glider Invader ARF Brushless RC Airplane Invader RTF Brushless RC Airplane Explorer RC Jet RTF - Prop Version Steerix Apache RC Heli Steerix Ozone Elite RC Heli Atomik Barbwire RTR Brushless RC Boat 1/8 Brian Deegan Metal Mulisha Ford Raptor 150 RTR SC Truck
Page 5 of 13 Copyright 2013 Vertical Partners West, LLC. All rights reserved.
SECTION 3:
Components Aluminum
Aluminum Packaging Foil Carbon (Various Forms) Copper Lithium Cobalt Oxide Lithium Salts Nickel Organic Carbonate Polymer
Physical/Chemical Characteristics 3 Dimensional Rectangular Solid Object with Black or Silver outside covering and two wires [positive (red) and negative (black)]. Emergency and First Aid Procedures
In the event of accidental battery material contact due to a damaged or ruptured battery cell please follow these emergency guidelines: Eye Contact: Skin Contact: Inhalation of Gases: Ingestion: SECTION 6: Immediately Flush eyes with water for 15 minutes and seek medical attention. Immediately wash affected area with soap and water. Immediately move affected victims to fresh air or well ventilated areas and seek medical attention. Seek medical attention immediately. Fire Fighting Measures
Extinguishing Media: CO2, Dry chemicals, water or Foam Extinguishers Fire-Fighting Procedures: Use a positive pressure self-contained breathing apparatus if batteries are involved in a fire. Full protective clothing is necessary. During water application, caution is advised as Page 6 of 13 Copyright 2013 Vertical Partners West, LLC. All rights reserved.
burning pieces of flammable particles may be ejected from the fire. Unusual Fire and Explosion Hazards:
Toxic gases (HF, PF6) will be formed if cells or battery are involved in a fire. Cells or battery may flame or leak potentially hazardous organic vapors if exposed to excessive heat, fire or over-voltage conditions. Damaged or opened cells or batteries may result in rapid heat and the release of flammable vapors. Vapors may be heavier than air and may travel along the ground or be moved by ventilation to an ignition source and flash back. Accidental Release Measures
SECTION 7:
The materials contained within the batteries can only be released under abusive conditions. Use a shovel or broom to cover the battery with dry sand and place in a non-flammable, well ventilated area. SECTION 8: Handling: Handling and Storage Batteries should never be opened, destroyed or incinerated as doing so may lead to leakage, rupture, or fire and the materials contained inside may be released. Batteries should only be recharged using approved chargers and approved procedures. Do not directly heat, throw in fire or solder directly. Do not mix with other types of batteries or other battery sizes or capacities. Storage: Batteries should be separated from other materials and stored in a non-combustible, non-flammable, well ventilated, sprinkler-protected structure with sufficient clearance between walls and batteries.
Page 7 of 13 Copyright 2013 Vertical Partners West, LLC. All rights reserved.
Do not place batteries near heating equipment, nor expose to direct sunlight for long periods of time. Do not store batteries above 60C (140F) or below 32C (-25F). Store batteries in a cool (below 21C (70F)), dry area that is subject to little temperature change. Elevated temperatures can result in reduced battery service life. Battery exposure to temperatures in excess of 130C (260F) will result in the battery venting flammable liquid and gases. Do not store batteries in a manner that allows terminals to short circuit. More than a momentary short circuit will cause temporary battery voltage loss until the battery is subjected to a charge. SECTION 9: Personal Protection
No controls are required for handling batteries that have not been damaged. Personal protective equipment for damaged batteries should include chemical resistant gloves and safety glasses. In the event of a fire, SCBA should be worn along with thermally protective outer garments. SECTION 10: Reactivity and Stability Data
Extended short-circuiting creates high temperatures in the cell. High temperatures can cause burns in skin or cause the cell to flame. Avoid reversing battery polarity within the battery assembly. To do so may cause cell to flame or to leak. Do not heat above 60C or incinerate. Do not puncture, disassemble, short circuit, deform, crush or mutilate.
Page 8 of 13 Copyright 2013 Vertical Partners West, LLC. All rights reserved.
SECTION 11:
Toxicological Information
Irritancy: The electrolytes contained in this battery can irritate eyes with any contact. Prolonged contact with the skin or mucous membranes may cause irritation. SECTION 12: Not Known SECTION 13: Transport Information Ecological Information
These batteries have been tested to Section 38.3 of UN Manual of Tests and Criteria. The amount of Lithium contained in these batteries is below the limits set by the Department of Transportation (DOT) in Section 49CFR173 and IATA. These can be shipped with the following label: LITHIUM POLYMER (LiPO) RECHARGEABLE BATTERIES INSIDE (No Lithium Metal)
Do not damage or mishandle this package If package is damaged, batteries must be quarantined, inspected and repacked. For emergency information, call CHEMTREC 1-800-424-9300
International Conventions International Air Transportation Association (IATA) International Maritime Dangerous Goods (IMDG) U.S. Department of Transportation (DOT) Regulatory Information
SECTION 14:
Page 9 of 13 Copyright 2013 Vertical Partners West, LLC. All rights reserved.
The transportation of rechargeable lithium polymer cells and batteries is regulated by the United States in accordance with Part 49 of the Code of Federal Regulations, (49 CFR Sections 173-185) of the U.S. Hazardous Materials Regulations (HMR). The international transportation of lithium cells and batteries is regulated by the International Civil Aviation Organization (ICAO) Technical Instructions and corresponding International Air Transport Association (IATA) Dangerous Goods Regulations, and the International Maritime Dangerous Goods (IMDG) Code. USA: Canada: This MSDS meets/exceeds OSHA requirements. This product has been classified in accordance with the hazard criteria of the Controlled Products Regulations and the MSDS contains all of the information required by those regulations. This MSDS conforms to European Union (EU), the International Standards Organization (ISO) and the International Labour Organization (ILO) and as documented in ANSI (American National Standards Institute) Standard Z400.11993.
International:
1. Always use a charger specifically designed for Lithium Polymer batteries. Never use NiCd or NiMH type chargers to charge LiPO batteries. Failure to do so will damage the batteries and may cause fire and personal injury. 2. Always charge batteries in a fire proof container. Do not charge batteries on wood, cloth, carpet, in your model, or on any other flammable material. Keep a chemical fire extinguisher near by in case of fire. 3. Never leave batteries unattended while charging. Always observe batteries when charging so that you may react quickly to any problems that may occur. 4. If a battery is deformed, swollen or appears damaged, DO NOT CHARGE. Follow the disposal instructions below to properly and safely dispose the battery.
Page 10 of 13 Copyright 2013 Vertical Partners West, LLC. All rights reserved.
5. Any time you have an accident with your model or if the battery swells balloons or if the battery exceeds temperature guidelines, follow these safety steps:
a. b. c. d.
Immediately remove the battery pack from your model or charger. Place the battery in a non-flammable, well ventilated area. Observe the battery for 30 minutes from a safe distance. After 30 minutes, if the pack appears stable, is not swollen and does not show any signs of damage, return the battery pack to normal use with caution.
6. Do not let exposed battery wires touch each other. This may cause the battery to short and potentially cause a fire. 7. Store your batteries in a cool, dry place between 40-80 F / 4-26 C. 8. Do not assemble unmatched or dissimilar LiPO cells. 9. Store battery packs out of the reach of children and pets. SECTION 16: Safety During Charging Instructions
1. Venom Power Lithium Polymer Power Cells feature a separate balancing plug that isolates each cell in a pack and charges it independently. This ensures that all cells peak equally and discharge at the same rate during use preventing one or more cells from discharging past their safe low voltage cut off rating. The balancing plug can be identified by the multi wire Molex plug. 2. Charge each battery pack individually. Never charge battery packs in series. Charging packs in series may result in improper charger cell recognition and an improper charging rate that may lead to overcharging, cell damage and fire. 3. Always check to make sure that your charger settings match those listed on the battery pack label. Refer to the battery label for the proper cell count and charging amperage setting. Selecting a cell count or amperage charge rate other than the one listed on the battery pack will damage the battery and may cause a fire. 4. Make sure the battery connections are connected in the correct polarity. A wrong connection will damage the battery and may cause a fire.
Page 11 of 13 Copyright 2013 Vertical Partners West, LLC. All rights reserved.
5. Always check battery pack voltage before charging. Do not discharge LiPO batteries below 3.0 Volts per cell. The voltage of a typical LiPO cell at rest is 3.7 Volts. If the battery pack appears swollen or damaged, DO NOT attempt to charge it. Check the voltage and follow Step 5 from the Safety Guidlines section. 6. Do not charge at over 1C current. C= battery pack mAh capacity 1000. Divide the battery mAh capacity by 1000 to determine the proper charge rate. Example: 1200mAh 1000 = 1.20 Amps Charge Rate for Venom Power LiPO Battery Packs, example: a. 800mAh Capacity = 0.80 Amps b. 1200mAh Capacity = 1.20 Amps c. 2000mAh Capacity = 2.00 Amps 7. Do not peak charge to more than 4.2 Volts per cell. Example: A 2S Battery Pack contains two cells, therefore the peak voltage should not exceed 8.4 Volts. 8. Battery Temperature is critical. Please use the following guidelines: a. b. c. Charge Temp Range: 32 - 110F / 0-43C Discharge Temp Range: 32 - 140F / 0-60C Storage Temp Range: 40 -80F / 4-26C
For optimum performance in cold climates, warm to 100F/ 37C before use. 9. If the battery exceeds the temperature guidelines as above, isolate the battery pack and follow Step 5 from the Guidelines & Warnings section. SECTION 17: Safety During New Battery Break-In
1. New LiPO battery packs may require 12 or more charge/discharge cycles before the batterys optimum performance is reached. 2. During this time, it is recommended that the battery pack is not discharged over 7C. 7C = 7 x 1C, where 1C= battery pack mAh capacity 1000. Example: [(1250mAh 1000) x 7] = 8.75 Amps Recommended Maximum Discharge Rates During Break-In Period a. 800mAh Capacity = 5.4 Amps b. 1200mAh Capacity = 8.4 Amps c. 2000mAh Capacity = 14 Amps
Page 12 of 13 Copyright 2013 Vertical Partners West, LLC. All rights reserved.
SECTION I8:
1. Never discharge a LiPO battery pack at more than the manufacturers recommended discharge rate. 2. The discharge rate is: Battery pack capacity (mAh) 1000 x Pack C rating a. Example for 15c packs: (3200 mAh 1000) x 15c = 48 Amps b. Example for 20c packs: (2100 mah 1000) x 20c = 42 Amps SECTION 19: Battery Disposal Instructions
1. Discharge battery pack to 2.5 Volts per cell or less. 2. Fill a bucket with enough water to submerge the battery pack completely. 3. Add salt to the water until no more salt will dissolve; the water is now saturated with salt. 4. Place the battery pack in the bucket and leave submerged in the salt water solution for 24 hours. 5. Remove the battery pack from the salt water and test the voltage. 6. If the voltage does not read 0.0 Volts, re-submerge and re-test until the voltage reads 0.0 Volts. 7. Once the battery pack has been discharged to 0.0 Volts, it is safe to dispose. 8. Dispose in according to local, state and country regulations. 9. These batteries do not contain any materials listed by the U.S. EPA that require special disposal requirements. SECTION 20: Additional Information
The information contained herein is based on the data available to us and believed to be correct. However, Vertical Partners West, LLC makes no warranty, expressed or implied. Users should consider the data only as a supplement to other information gathered through personal research and must make independent determinations of the suitability and completeness of information from all sources to ensure the proper use and disposal of these materials and the safety and health of employees and customers.
Page 13 of 13 Copyright 2013 Vertical Partners West, LLC. All rights reserved.