Documente Academic
Documente Profesional
Documente Cultură
(2 = Semi-confidentional, Minolta-QMS, internal use only, 3 = Service Partners/Distributors/First Line usage only. 4 = General Information, may be send to end-users.)
We assume that the driver of the printer is already installed, if this is not the case then please install the driver first. Please see the user guide for instructions on this. Please go to Start -> Settings -> Printers (XP users: go to Start -> Printers and faxes) Then right mouse click on the printer icon and go to the driver properties. Then go to ports and click on the button Add new port
Page 1 of 5
Then click at the button with New Port and the following screen comes up:
Then click at the button with Next and the following screen comes up:
Printer Name or IP Address: Fill in the IP address of your printer without leading zeros. (.6 instead of .006)
Page 2 of 5
Then click on the button with Next and the following screen comes up:
Page 3 of 5
Printer Model / Name Magicolor 2 / 2+ Magicolor 2 Desklaser Magicolor 6100 / 6100 DL / 6110 Magicolor 330 Magicolor 2200 / 2200 DL / 2210 Magicolor 3100 / 3300 Magicolor 2350 Magicolor 2300 DL Magicolor 7300 QMS 2060 QMS 3260 / 4032/ 4060 Page Pro 9100
Device Type QMS Printer QMS Printer *See note last page QMS Printer QMS Printer QMS Printer QMS Printer Minolta Network Printer Minolta Network Printer Minolta Network Printer QMS Printer QMS Printer QMS Printer
Page 4 of 5
Now click Finish to complete the Add Port Wizard. In case it doesnt work then please go to Ports and select Configure Port and check the settings with the list below. Printer Model / Name Magicolor 2 / 2+ / DL Magicolor 6100 / 6100 DL / 6110 Magicolor 330 Magicolor 2200 / 2200 DL / 2210 Magicolor 3100 / 3300 Magicolor 2350 Magicolor 2300 DL Magicolor 7300 QMS 2060 QMS 3260 / 4032 / 4060 Page Pro 9100 Protocol RAW RAW RAW RAW RAW RAW RAW RAW RAW RAW RAW Port number 35 35 35 35 35 9100 9100 9100 35 35 35 Queue Name n/a n/a n/a n/a n/a n/a n/a n/a n/a n/a n/a Remarks n/a n/a n/a n/a n/a n/a n/a n/a n/a n/a n/a
Please leave LPR Settings and SNMP Status Enabled unchecked! After filling out the correct settings click OK and Apply to save the changes. Magicolor 2 Desklaser: Open the driver properties and change the port protocol to RAW and set the port number to 35.
Page 5 of 5