Documente Academic
Documente Profesional
Documente Cultură
Statics Fundamentals
http://strengthandstiffness.com/2_statics/page_2a.htm
Vectors and Forces A solid grasp of vectors is vital to solve problems in Statics and Strength of Materials. Vectors describe the magnitude and direction of forces and torques/moments. It is often convenient to reduce vectors into their scalar components; e.g., 2D-force F can be broken into its x- and y-components: Fx = Fcosq and Fy = Fsinq where F is the magnitude of force F, and q is its direction measured from the x-axis.
Free-Body Diagrams The construction of free-body diagrams (FBDs) is the first and most important step in solving a Strength of Materials problem. The following steps are involved in constructing a FBD: Isolate from its surroundings the part(s) of the system that you are interested in analyzing; visualize or actually draw a boundary around the body of interest. Identify and represent ALL external forces (and moments) acting on the body; i.e., forces that act across the boundary. Include weight when comparable to the applied forces. Include a coordinate system and necessary dimensions on the diagram for convenience in applying equilibrium equations and communicating geometry. The diagram should be free of clutter and extensive information. The forces, moments and key dimensions are the primary information required. To help illustrate the construction of a FBD, consider the rear suspension of the mountain bike below:
Equilibrium Once a FBD system is constructed, the next step is to apply the conditions of equilibrium. A body in static equilibrium is not accelerating, so the forces and moments acting on it must sum to zero in any direction. Equilibrium requires that: the sum of the forces in any direction must be zero: S F = 0. the sum of the moments about any non-accelerating point must be zero: S MO= 0. In 3-dimensions, six equations must be satisfied: S Fx = 0 ; S Fy = 0 ; S Fz = 0
1 od 2
27.7.2013 22:58
http://strengthandstiffness.com/2_statics/page_2a.htm
S Mx = 0 ;
S My = 0 ;
S Mz = 0
In 2-dimensions, only three equilibrium equations are required. When the object is in the x-y plane, one of the following three sets of equations may be used: S Fx = 0 S Fy = 0 S Mz,A = 0 The sum of forces in x and in y, and the sum of moments about any Point A (about a z-axis through Pt. A), each equal zero S Fx = 0 S Mz,A = 0 S Mz,B = 0 Points A and B are two different points. S Mz,A = 0 S Mz,B = 0 S Mz,C = 0 A, B and C are three points, not all on the same line. The points define a plane.
2 od 2
27.7.2013 22:58