Documente Academic
Documente Profesional
Documente Cultură
(Electronics)
sequel@ee.iitb.ac.in
M.B.Patil, IIT Bombay
A few tips
Examples shown here are available as .sqproj files. To run an example, open the project, and click on run. When execution is completed, the graphs menu will automatically open. Select the x and y axes, and plot the results. To change parameters (e.g., resistance values), refer to the GUI manual.
diode_iv.sqproj
diode_circuit_1.sqproj
diode_circuit_1.sqproj
rectifier_tap_1.sqproj
Rectifier_tap_1.sqproj
rectifier_tap_2.sqproj
rectifier_tap_2.sqproj
triangle_to_sine.sqproj
triangle_to_sine.sqproj
Input spectrum
Output spectrum
wave_shaper_1.sqproj
Voltage_doubler_1.sqproj
bjt_ic_vce.sqproj
bjt_beta_ic.sqproj
bjt_inverter.sqproj
bjt_inverter.sqproj
bjt_ce_amp.sqproj
bjt_cb_amp.sqproj
bjt_cb_amp.sqproj
bjt_cb_amp_freq.sqproj
bjt_class_b.sqproj
bjt_class_b.sqproj
bjt_class_ab.sqproj
bjt_mirror_1.sqproj
bjt_mirror_2.sqproj
bjt_mirror_3.sqproj
bjt_widlar.sqproj
bjt_miller_effect_1.sqproj
bjt_diff_pair.sqproj
bjt_audio_amp_1.sqproj
bjt_audio_amp_1.sqproj
bjt_audio_amp_2.sqproj
bjt_audio_amp_2.sqproj
bjt_diff_amp.sqproj
bjt_diff_amp.sqproj
bjt_diff_amp_ac.sqproj
bjt_osc_1.sqproj
bjt_ttl_dc.sqproj
bjt_ttl_dc.sqproj
bjt_schmitt.sqproj
bjt_tri_to_sin.sqproj
bjt_tri_to_sin.sqproj
mos_iv_1.sqproj
mos_inverter_dc_1.sqproj
mos_inverter_trns.sqproj
mos_pass_n.sqproj
mos_pass_c.sqproj
mos_inverter_buffer.sqproj
mos_ring_osc.sqproj
mos_voltage_pump.sqproj
mos_mirror_1.sqproj
mos_mirror_2.sqproj
mos_opamp_1_dc.sqproj
mos_opamp_1_dc.sqproj
mos_opamp_1_ac.sqproj
mos_opamp_1_ac.sqproj
mos_vco_1.sqproj
mos_vco_1.sqproj
Vin=1.5 V
Vin=2.0 V
jkff_test.sqproj
jkffcntr.sqproj
up_down_counter.sqproj
Mode=1
Mode=0
ring_counter.sqproj
decade_sync_counter.sqproj
demux_test_1.sqproj
mux_test_1.sqproj
inv_amp.sqproj
inv_amp_ac.sqproj
R2=10 k
R2=50 k
non_inv_amp.sqproj
difference_amp.sqproj
summer.sqproj
integrator_741.sqproj
opamp_current_source.sqproj
opamp_current_source_1.sqproj
opamp_current_source_1.sqproj
opamp_limiter_1.sqproj
opamp_regulator.sqproj
Note: regulation with respect to (a) Input voltage change (b) Output load current
low_pass_filter_1.sqproj
low_pass_filter_trns_1.sqproj
low_pass_filter_trns_1.sqproj
band_pass.sqproj
band_reject.sqproj
bass_equalizer.sqproj
a_pot=0
a_pot=1
butterworth_4_ac.sqproj
butterworth_4_trns.sqproj
butterworth_4_digital_ac.sqproj
butterworth_4_digital_trns.sqproj
butterworth_4_digital_trns.sqproj
schmitt_741.sqproj
schmitt_741_1.sqproj
schmitt_osc_741.sqproj
schmitt_osc_411.sqproj
opamp_osc_1.sqproj
opamp_osc_2.sqproj
wien_osc_1.sqproj
wien_osc_2.sqproj
phase_shift_osc_1.sqproj
phase_shift_osc_1.sqproj
super_diode_1.sqproj
super_diode.sqproj
precision_half_wave.sqproj
precision_full_wave.sqproj
precision_full_wave.sqproj
ic555a.sqproj
ic555b.sqproj
rc_demo.sqproj
sample_hold.sqproj
sample_hold.sqproj
adc_dual_slope.sqproj
adc_dual_slope.sqproj
vco_test.sqproj
dpll1.sqproj
dpll1.sqproj
sigma_delta.sqproj
sigma_delta.sqproj
sc_lpf.sqproj f=1 k
f=5 k
f=20 k
sc_notch.sqproj
sc_notch.sqproj
f=100 Hz
f=60 Hz
f=20 Hz
sc_bpf_lq.sqproj
sc_lpf_5th_1.sqproj
sc_lpf_5th_1.sqproj
f=1 kHz
f=100 Hz
f=2 kHz
sc_lpf_5th_2.sqproj
sc_lpf_5th_3.sqproj
sc_lpf_5th_3.sqproj
References
A. S. Sedra and K. C. Smith, Microelectronic Circuits, 5th Edition, Oxford University Press, 2004. R. J. Baker, H. W. Li, and D. E. Boyce, CMOS: Circuit Design, Layout and Simulation, IEEE Press Series on Microelectronic Systems, 1997. J. M. Fiore, Op Amps and Linear Integrated Circuits, Delmar Thomson Learning, 2001. S. Franco, Design with Operational Amplifiers and Analog Integrated Circuits, McGraw-Hill International, 1998.
Thanks!