Sunteți pe pagina 1din 19

Fill in the blank values based on the information provided 1)

Peak to peak voltage 12 Volts AC RMS voltage (effective): Frequency Wave length (meters) Time for 1 cycle 20 micro seconds
2)

Peak voltage RMS voltage (effective): 15 Kilo-Volts AC Frequency 250 Hz Wave length (meters) Time for 1 cycle
3) List three advantages of alternating current over direct current a. _____________________________________ b. _____________________________________ c. ___________________________________

4) What is the effective current of the circuit below?

5) What is the effective power of the circuit bellow?

6) What is the peak power dissipated by the circuit below?

7) What is the True power dissipated by the circuit above?

8) What is the reactance of a 1 F capacitor at the following frequencies? 60 Hz? 1 kHz? _______________ _______________

9) What type of filter is illustrated below this question?

10)

What frequencies will the circuit below pass to meter ?

1000 Ohms

METER

AC Voltmeter

S
signal generator

G
5 micro Farads

_________________________

11) What frequencies will the circuit below pass to the ac voltmeter?

10K Ohms

S
signal generator

G
5 pico Farads
METER

AC Voltmeter

_____________________________

13) (8 Pts)What is the impedance of a network composed of a 500mili-henry inductor in series with a 100-ohm resistor and a 25 micro-farad capacitor , at 67.8 Hz? Specify your answer in rectangular coordinates and Polar coordinates.

Polar Coordinates___________________________________________________

Rectangular Coordinates ______________________________________________

14) (8 Pts) What is the impedance of a network comprised of a 150-ohm-reactance inductor with a 2300-ohm resistor and a 200 ohm-reactance capacitor all in parallel?

Polar Coordinates___________________________________________________

Rectangular Coordinates ______________________________________________

15)

Given the Oscillator schematic above, What is the frequency determining device?_______________________ What is the regenerative feedback path?_________________________ What Components develop the output for Q2?____________________ What Components develop the output for Q1?____________________ What components set up bias for Q2?___________________________ What components set up bias for Q1?___________________________ What function does C1 perform?______________________________

16)

Given the Oscillator schematic above, What components form the frequency determining device?___________________________________________________ What is the regenerative feedback path?_________________________ What Components develop the output for Q1?____________________ What components set up bias for Q1?___________________________ What function does C4 perform?______________________________ What function does R3 perform?______________________________

17)

Identify filter type (L, Pi, T) and function (low pass, High Pass, band pass, band reject)

____________

_______________

____________

___________________

______________

__________________

_______________ _________________

____________

_______________

18)

Given the circuit above, resistor value is 100 ohms and capacitor value is 2 micro farads

What is the cut-off frequency for the circuit above?

What is the current?

What is the voltage drop of the capacitor?

19) Which statement is true regarding the filter output characteristics shown in Figure 3F16? A. C is a high pass curve and B is a band pass curve. B. B is a high pass curve and D is a low pass curve. C. A is a high pass curve and B is a low pass curve. D. B is a band pass curve and C is a low pass curve.

20)

21) List 4 requirements for an oscillator circuit: 1) _______________________ 2) _______________________ 3)_______________________ 4)_______________________

input to a mixer is 200 MHz and the local oscillator frequency is 150 MHz. What output would you expect to see at the IF output prior to any filtering? A. 50, 150, 200 and 350 MHz. B. 50 MHz. C. 350 MHz. D. 50 and 350 MHz.

2) If a single side band SSB transmitter radiates 1000 watts at peak modulation, what will it radiate with no modulation? A. 10 Watts B. 0 Watts C. 500 Watts D. 1000 Watts 3) Describe the function of the six major components of receiving and processing a radio transmission. Number the processes in order necessary to receive an amplitude modulated radio frequency and produce an audio signal. ___Preamplifier___________________________________________________________ ___Demodulator__________________________________________________________ ___Speaker or video/signal processor________________________________________ ___Antenna_____________________________________________________________ ___Antenna coupler_______________________________________________________ ___Tuner________________________________________________________________ ___Audio Power amplifier__________________________________________________

4) Is the modulation function accomplished as part of the transmit or receive process?

5) Under normal circumstances, when frequencies are above 30 MHz, what influence does the ionosphere have on them?

6) Long range HF radio communications are primarily enables by which layers of the ionosphere? 7) When is the D layer of the ionosphere most prevalent? What affect does it have on HF sky-waves?

8) Class A amplifiers conduct what percentage?

9) When comparing class A, class B, and Class C amplifiers, which class of amplifier is the most efficient?

10-13 Answer true or false 10)_______Frequencies in the UHF band are typically used for long range communications because the short wave length tends to bounce off the ionosphere. 11)_______The F1 and F2 layers of the Ionosphere are not important to long range sky wave radio communications. 12)_______Class AB amplifiers are more efficient than class B amplifiers 13)_______An antenna coupler is an impedance matching device that matches the antenna system impedance to the frequency being utilized 14) What will over-modulation of an AM signal cause?

15) What are the four minimum components of an oscillator? 16) What are the frequency determining components in the circuit below?

17)

What is the purpose of a buffer amplifier between a mixer circuit and an oscillator?

18)

What is the frequency determining device (FDD) in the circuit below?

19) What type of waveform is produced by a sinusoidal oscillator? a. Sine Wave b. Squad wave c. Pulses d. Saw tooth 20) What is the interchange of energy between the inductor and capacitor in a tank circuit used as an FDD called?

21) What components (s) in the circuit below keep the oscillator frequency from entering the power supply?

22) What components forward bias Q1 in the circuit below?

Write the type of modulation in the blank provided 23) _________________________

Write the type of modulation in the blank provided 24)___________________________________

25) What type of modulation is represented in the signal below?____________________________

26) Given binary modulating source (line A), enter the type of modulation represented on lines B, C and D.

27) List the 6 minimum processes in a radio transmitter in block diagram form, starting with the microphone and ending with the antenna. Ensure you explain the function of each process.

S-ar putea să vă placă și