Documente Academic
Documente Profesional
Documente Cultură
Clearance
Make sure that the place of installation meets the following requirements.
300 mm (11-13/16")
Installation Guide
Environment
Temperature: 10 to 32.5 C (50 to 90.5 F) Humidity: 15 to 80 %RH Power Supply: 120 V AC, 60 Hz, 7.7 A / 220 to 240 V AC, 50/60 Hz, 4.3 A
CAUTION: Be sure to provide enough space around printer. Prolonged use without sufficient clearance may cause overheating. Important: Do not install the printer where temperature or humidity is outside the
300 mm (11-13/16")
100 mm (3-15/16")
200 mm (7-7/8")
600 mm (23-5/8")
recommended range. Print quality may suffer and there will be an increased chance of paper jams.
Attach the included language label sheet on the indicator as shown in the figure.
Printer Toner Container Waste Toner Box Power Cord Plastic Waste Bag
2
1
Insert the protrusion at the left of the rear cover into the hole in the printer. The rear cover is fixed.
Open the top cover and remove the fixing tape. Take the toner container from the bag.
Shake the new toner container at least 10 times as shown in the figure in order to distribute the toner evenly inside the container.
Push on the PUSH marks on the toner container until the container clicks into place.
shown in the figure. When the box is set correctly, it will snap into place.
Adding Paper to the Paper Cassette 1 Pull out the paper cassette. The paper cassette can accommodate
A6(FS-2020D model:A5) to A4/Letter and Legal size paper and can hold approximately 500 sheets.
Turn the paper size dial so that the size of the paper you are going to use appears in the paper size window.
Pull the release lever on the left side guide and slide to the desired paper size.
If you are going to set paper that is longer than A4/Letter, pull out the extension paper cassettes pushing the lock lever one by one and adjust them to the desired paper size.
Pull the release lever and slide the paper stopper to the desired paper size.
Fan the paper, then tap it on a level surface to avoid media jams or skewed printing.
Place the paper in the cassette, with side to be printed downward, so that the leading edge is aligned against the paper stopper.
Insert the paper cassette into the slot in the printer. Push it straight in as far as it will go.
5
1
Connecting Cables
Connect the printer to the PC or your network device. Use shielded interface cables. These cables are sold separately. Remove the cap, when using the network interface. Important: Installing the optional network interface card on the FS-2020D model enables the
network function.
Connect the power cord to the printer and the other end into a power outlet.
Cap
6
1
Wait until the message display indicates MSG Language. The default message language is English. Important: MSG Language may not appear according to the destination.
3 4
To change the language, press [U] or [V] repeatedly until the message display shows the desired language. Press [OK]. The message language will be changed.
Refer to the Operation Guide to set network parameters and to install the printer driver.
2008 by KYOCERA MITA Corporation All rights reserved. 2-28, 1-Chome, Tamatsukuri, Chuo-ku, Osaka 540-8585, Japan Printed in China 302J056020 Rev.1.0 2008.9