Documente Academic
Documente Profesional
Documente Cultură
http://www.meadinfo.org/2009/07/press-fit-pressure-calculator-op...
Home
Reference
Categories
Archive
Pro/Engineer (Creo)?
3. Duplex Bearing Arrangements - Back to Back, Face
(Creo)
8. SolidWorks 2013 New Features [Video] 9. How to Create an Auxiliary View in Pro Engineer
(Creo)
10. AutoCAD 2013 New Features
Calculate pressure generated and force to engage/disengage - H6m6 fit example - Click on the image to download the calculator
Interference and Transition fits can be used effectively connect machine elements. This calculator uses following formula to find the pressure generated with the designed
1 of 2
10/1/2013 1:23 PM
http://www.meadinfo.org/2009/07/press-fit-pressure-calculator-op...
connection.
This data then can be used to optimize the design of the hub/shaft, or can be used to find the force to engage and disengage these parts, or can be used to find the maximum torque this connection can transmit without slippage. Above example shows a transition fit of H6/m6 between shaft and hub. To find tolerances for different fits refer Tolerance Table for Regularly Used Fits For calculating minimum force to engage or disengage these parts we can use the following formula
F = . pmax . A
Where is the friction between hub and shaft, A is the area of contact between shaft and hub. To calculate maximum torque which can be transmitted without slip can be found using following formula
T = F . d/2
2008-2012 MEADinfo. The content is copyrighted to MEADinfo and may not be reproduced without consent. MEADinfo - Mechanical Engineer's Information Hub
2 of 2
10/1/2013 1:23 PM