Documente Academic
Documente Profesional
Documente Cultură
8L 00-02
HOLDEN
Engine Code: VH
ENGINE COMPARTMENT
1
20
19
10
18
11
17
12
16
13
15
14
COMPONENT
LOCATION
ABS Control Module (in ABS Modulator) .................. 19
ABS Hydraulic Modulator .......................................... 19
Anti-Boost Control Solenoid (supercharged) ............. 14
Battery Harness Fusible Link Housing ...................... 15
Brake Hydraulic Failure Switch ................................. 20
Bypass Valve Actuator .............................................. 13
Camshaft Position Sensor ........................................ 16
Canister Purge Control Solenoid ................................ 2
Crankshaft Position Sensor ...................................... 17
Direct Ignition System Module ................................... 11
Engine Compartment Fuse/Relay Box ...................... 18
Engine Coolant Temperature Sensor .......................... 8
EGR Valve .................................................................. 6
Heated Oxygen Sensors .............. (near cat. converter)
COMPONENT
LOCATION
Idle Air Control Valve .................................................. 5
Ignition Coils ............................................................. 12
Injectors - RHS Bank .................................................. 3
Intake Air Temperature Sensor ................................. 10
Knock Sensor - LHS ................................................... 9
Knock Sensor - RHS .................................................. 1
Mass Air Flow Sensor ................................................. 7
Throttle Position Sensor ............................................. 4
Vehicle Speed Sensor ....................... (on transmission)
HOLDEN
Engine Code: VH
DASH PANEL
COMPONENT
LOCATION
Body Control Module .................................................. C
Electronic Climate Control Module.............................. A
Data Link Connector ................................................ D
(16pins, under steering column)
Driver Side Fuse/Relay Box ........................................ B
COMPONENT
LOCATION
Powertrain Control Module ......................................... F
SRS (Airbag) Control Module .................................... E
VIN/COMPLIANCE PLATE
Compliance Plate .............. (on scuttle, passenger side)
Manufacturer Plate ............ (on scuttle, passenger side)
VIN ................... (lower left hand corner of windscreen)
HOLDEN
Engine Code: VH
Circuit
Fuse (Amps)
Circuit
F28 (15A)
Fuel pump
F32 (15A)
Auto transmission
F29 (20A)
RHS headlamp
F33 (15A)
Engine sensors
F30 (20A)
LHS headlamp
F34 (15A)
Injectors
F31 (15A)
PCM
F35 (15A)
Ignition
F28
F29
10
F30
F31
F32
F33
F34
FQ FR
FS
FJ
FY
11
12
F35
Component
Location
Radiator Fan Relay (low speed) ................................. 1
EFI Relay .................................................................... 2
Horn Relay ................................................................. 3
Theft Horn Relay ........................................................ 4
Fog Lamp Relay ......................................................... 5
Radiator Fan Relay (high speed) ................................ 6
AC Relay .................................................................... 7
Headlamp Relay (low beam) ...................................... 8
Windscreen Wiper Relay ............................................ 9
Fuel Pump Relay ...................................................... 10
Headlamp Relay (high beam) .................................... 11
Starter Relay ............................................................. 12
Lighting
FR (60A)
ABS
FS (60A)
Engine
FJ (60A)
Main
FY (40A)
Blower
HOLDEN
Engine Code: VH
Circuit
Fuse (Amps)
Circuit
F1 (20A)
F15 (10A)
F2 (20A)
F3
Spare
F16 (10A)
Radio
F4 (10A)
Park lamps
F17 (20A)
F5 (10A)
ABS
F18 (20A)
Wiper/washer
F6 (10)
Interior illumination
F19
Spare
F7 (15A)
Turn signals
F20 (15A)
F8
Spare
F21 (10A)
Instruments
F9 (7.5A)
LPG
F22 (20A)
F10 (7.5A)
F23 (15A)
Radio
F11 (7.5A)
Instrument illumination
F24 (20A)
Sub-woofer amplifier
F12 (15A)
Turn signals
F25 (15A)
Horn
F13 (7.5A)
F26 (15A)
SRS
F14 (10A)
PCM
F27 (10A)
ABS
control
F1
F2
F3
F4
F12
F20
F5
F13
F21
F6
F14
F22
F7
F15
F23
F8
F16
F24
F9
F17
F25
F10
F18
F26
F11
F19
F27
5
Optional
Optional
10
Component
Location
Flasher Unit Relay ...................................................... 1
Blower Fan Relay ....................................................... 2
Heated Rear Window Relay ....................................... 3
Power Window Relay ................................................. 4
Blower Inhibit Relay .................................................... 5
Parking Lamp Relay ................................................... 6
Rear Window Wiper Relay ......................................... 7
Driver Power Window Relay ....................................... 8
Spare .......................................................................... 9
LPG .......................................................................... 10