Documente Academic
Documente Profesional
Documente Cultură
com
http://www.eleccircuit.com/power-amp-super-bridge-120w-by-ic-tda2030/
Home About me Contact us Easy electronic projects Simple circuits Amps with PCB Shop
See Other projects in : Amplifiers DIY projects And: Amplifier ICs, Bridge amplifiers, TDA2030
Posted by admin - June 10, 2007 at 2:14 am
This be Super Bridge 120W Power Amplifier by IC TDA2030 for you like the circuit amplifies that use the integrated circuit. and Transistor BD249 or TIP31 or TIP41 or C1061 and BD250 or TIP32 or TIP42 or A671. It is nice circuit and easy to use.
circuit Power Amp Super Bridge 120W by IC TDA2030 Other circuits are recommended. 1. 2. 3. 4.
More Audio Amplifiers with PCB Bridge amplifier circuit TDA2030 HA13001 IC For 40W Power Amplifier
1 of 7
28/09/2013 17:20
http://www.eleccircuit.com/power-amp-super-bridge-120w-by-ic-tda2030/
This circuit is designed by using TDA2030A circuit as driver to power transistor output to applied to out up 30 watt. - then take both circuit to bridge together, makes we have the power output up to 4 times and have even maximum power output is 200Watt. May dont be defeated because this circuit give the electric power about 120W that load 2 ohm. When see the circuit will think use important equipment be. Must use power supply source that be appropriate about +15V and -15V that current 2Amp. Besides should use heat sink at have the size is appropriate IC TDA2030 and Q1-Q4 BD249,BD250 for see the circuit has already. Build easy must not fine decorate anything. Request a friend has fun Power Amp Super Bridge 120W by IC TDA2030 please sir. - The advantage of this circuit, the voltage of the power supply is low (compared to other circuits. Watts are equal in size), so I used the low voltage capacitor, smaller, and cheaper. - As can be seen from the circuit, we enter a signal input at pin 1 is side single. With pin 1 of IC2 (TDA2030) is connected to ground, And the output signal fed back to the inverting pin (pin 2) of IC2, Allow us to signal with opposite phase, input to the amplifier is one automatically. How to build Soldering Electronic Components to the right, onto the PCB as shown in Figure 2. Then install the power transistor to the heat sink. By Vice insulating sheet mica. To prevent a short circuit on the heat sink neatly. When certain everything must be right, it was the power supply to the circuit, in order to use it, without having to adjust the circuit. Detail of circuits Q1,Q3_________BD250___PNP POWER TRANSISTORS(25A,125W) Q2,Q4__________BD249____NPN POWER TRANSISTORS(25A,125W) D1,D2,D3,D4____1N4002____Diode 1A 100V IC1,IC2_________TDA2030A__18W HI-FI AMPLIFIER AND 35W DRIVER R1,R7,R11,R13__2.2 ohm____Resistors 1/2W R2,R3,R12______100K______ Resistors 1/4W R4,R8__________2.2K_______ Resistors 1/4W R5,R6__________3.3K_______ Resistors 1/4W R9,R10_________1 ohm______ Resistors 1/2W C1_____________0.0015uF 50V___ Polyester Capacitor C2,C3,C4,C5,C7_0.022uF 50V___ Polyester Capacitor C6_____________10uF 16V_____ Electrolytic Capacitors
Bass guitar super bridge amplifier 200 watt. 100 watt DC servo amplifier by Power MOSFET The cheap 100 watt transistor power amplifier project The main amplifier 50 watt OCL by LF351-2N3055-MJ2955 with PCB Power Amplifier OCL 50W by Mosfet (K1058 + J162) Power Amplifier OCL 40W by 2N3055+MJ2955 Related Posts :
2 of 7
28/09/2013 17:20
http://www.eleccircuit.com/power-amp-super-bridge-120w-by-ic-tda2030/
Hello everyone If you want to project an amplifier, which consists of integrated circuits, and printed circuit boards. This article will not make ...
Power Amplifier BCL 35W by TDA2030 The 35W Amplifier BCL by TDA2030 is easy to build, and very inexpensive,Easy to build. To use Power Supply +15V -15V 2A. View ... The multi-purpose Amplifier using TDA2030 The Amplifier Pulse This delayer by multi-purpose ic 4528 10 Channel Equalizer by LA3600 ... low Graphic noise be valuable THD (To using TDA2030. It is have power 8 watt (RMS) at 8 ohm loudspeakers. It is have
3 of 7
28/09/2013 17:20
http://www.eleccircuit.com/power-amp-super-bridge-120w-by-ic-tda2030/
7. Ai cho em xin ci mch Ampli 2-4 Tran vi :D says: January 29, 2013 at 6:10 am [...] 0 Thread(s) Th bc cho em ci mch 4 Tran y vi. Em cng mi kim c ci mch ny nhg cha th. Thy my ng Ty ni cng sut khong 120-200W lin. Ch bit ng hay k. Hm no nghch th. Mch dng 2 TDA2030A mc cu vi 4 con Tran cng sut Power Amp Super Bridge 120W by IC TDA2030 | Eleccircuit.com [...] 8. Akhil says: July 2, 2013 at 10:38 pm Friends the given circuit diagram is wrong 9. Joel says: August 7, 2013 at 11:24 pm What is. Correct way? 10. Joel says: August 7, 2013 at 11:24 pm Anyone know the proper connections.???. 11. Joel says: August 8, 2013 at 11:36 pm The problem is on the 2030 chip you have pin 3 and 5 reversed . Pin 1 is + and pin 5 should be on the same side in the schematic. Pin 2 is and pin 3 should be on the same side in the schematic. Easy mistake 12. ravi says: August 10, 2013 at 1:54 am pls give me a 5.2 channel circuit simple ic transistor based with power supply 13. Joel says: August 12, 2013 at 2:17 pm Whis it? In the parts list you show c2,3,4,5,7 as 0.022uf but in the schematic you show them as 0.22uf. There is a big difference. Also in the parts list you have c1 and c6 as 0.0015 uf 50v and 10 uf 16v but the schematic shows them as both 0.22 uf . Can u pleas write me with the correct info? What else is wrong with the project? Help please. I bought all the parts but cant assemble until I know. Thank u
Leave a Comment
Name (required) Mail (will not be published) (required) Website
4 of 7
28/09/2013 17:20
http://www.eleccircuit.com/power-amp-super-bridge-120w-by-ic-tda2030/
Custom Search
Subscribe
5 of 7
28/09/2013 17:20
http://www.eleccircuit.com/power-amp-super-bridge-120w-by-ic-tda2030/
DC converter (41) Inverters (23) DIY projects (155) Alarm systems (52) Battery (10) Audio diagram (80) Automotive (16) Basic (52) Circuit diagram (24) Digitals (64) Controls (102) Products (6) Lightings (60) Meters (64) Oscillator (43) Radios (27) Datasheets (10) News (3) Tools (5) Detector (25) LED Flasher (28) Microcontroller (3) Motor controller (12) Timers (21)
Recent Posts Cheap touch switch using transistor Simple astable multivibrator circuit using CD4047 Cmos IC 30-minutes emergency lighting Time delay for relay using CD4011 Frequency generators circuit using LM3909 Archives
Blogroll Electrical Engineering Electronics learning with Wikimedia Forrest M. Mims III POWER SUPPLY PROJECTS LM317 voltage regulators DC Switching Power-Supplies
6 of 7
28/09/2013 17:20
http://www.eleccircuit.com/power-amp-super-bridge-120w-by-ic-tda2030/
Like Follow
Send
Follow @eleccircuits
286 people are following Eleccircuit Ideas. Sign Up to see who your friends are following.
Email contact : mome.name (at) yahoo.com or Contact us form:: If you copy our content. Please link to us. Home :: About :: Sitemap :: Contact us :: Advertising :: Easy electronic projects Copyright 2007 - 2013 Eleccircuit.com Theme by HeatMapTheme.com
7 of 7
28/09/2013 17:20