Documente Academic
Documente Profesional
Documente Cultură
Rounded hems at Skirts, dresses, blouses or table cloth are just beautiful. There are many simple ways to do it!
I used simple cotton fabric. But test it on a fabric remnant first! Have fun!
Simple hem
Cut a stencil of the pattern out of cardboard. Iron the seam allowance around the stencil.
Fast hem
If you have a serger, adjust the differential transport. The fabric will crimple a bit and easily go to the inside. Alternatively serge the raw edge, sew a loose seam in the middle and let the threads hang loose. Use these threads to crimple the seam allowance.
Fringed hem
Sew a broad fancy seam a bit above the raw edge. Cut cautiously right beneath the seam with small gaps. Fray a bit with your fingers. After washing the the hem will be beautifully fringed. READY!
Ruffled hem
Pin a ruffle right on right on the raw edge. Sew it on with serger or sewing machine.
Sew Ricrac trim or lace with serger or sewing machine on the raw edge.
Iron down the ricrac or lace and topstich the hem. READY!
Arched hem
Pin embroidery backing on the left side of the fabric and sew a narrow arched seam with your sewing machine. To get a nice back of the seam adjust the thread tension.
Tear the outside backing first and cautiously cut the fabric away. Then tear away the backing underneath the fabric. READY!
Stitched hem
Pin embroidery backing on the left side of the fabric and sew a very narrow zigzag stitch with your sewing machine. To get a nice back of the seam adjust the thread tension. Sew slowly along the raw edge. Tear away the backing. READY!
Sew a rolled hem with your serger. If you stretch the fabric while sewing you get a rolled shell hem. You can adjust the differential transport on some sergers to get this effect. READY!
Cut a small band of non fraying fabric like interlock jersey, fleece or boiled wool. Stitch it right on right to the raw edge.
Iron seam to the left side, topstitch on the right side and trim the piping, if you want. READY!
Serge the raw edge and sew the lace/elastic lace on the seam. Use a broad fancy seam to cover the serger seam. READY!
Coverstitch hem
For a coverstitch hem iron the raw edge first, optionally with a stencil. Then stitch the hem. READY! Hem with bias binding
Use commercial bias tape or alternatively cut a band of fabric in bias grain and stitch it left on right along the raw edge. Iron the fabric around the raw edge.
Fold the bias tape to the left side of the fabric, fold the raw edge inside, iron again and topstitch it. READY!
Fold a long band of fabric in the middle and sew the open sides to the raw edge right on right.
Iron the seam allowance to the left side and topstitch it.
READY!
Fancy hem
Iron the bias tape completely to the left side and topstitch it with a small seam.
READY!
genuine piping
Sew on a commercial piping trim right on right. Use a sewing foot for piping or zippers.
READY!
Single examples of the finished design may sold commercially by individual seamstresses. However, greater quantities may not be sold without express written permission. The pattern is protected under copyright law and may not be photocopied, digitally scanned, photographed or otherwise reproduced without express written consent.