Documente Academic
Documente Profesional
Documente Cultură
TECAPLAS, S.L. Pol Ind El Campillo Pab D-9-8 48500 Gallarta (Bizkaia) Tfno 94 636 34 64 Fax 94 636 38 26 www.tecaplas.com
www.tecaplas.com
Se definen como dispositivos que enlazan los bordes de dos tableros contiguos o de un tablero y un estribo, de forma que permiten movimientos relativos entre los mismos manteniendo una superficie lo ms continua posible. Are defined as devices that links the edges of two adjacent bridge decks, or a bridge edge with the end of the bridge; so that, allow movements maintaining a flat and even surface.
Las condiciones que deben cumplir estos tipos de juntas son: The conditions required for these expansion joints are:
Elasticidad, para acompaar los movimientos sin agrietarse o transmitir esfuerzos inadmisibles en los tableros. Elasticity, to move without cracking or transmitting unacceptable stresses to the bridge decks. Impermeabilidad, evitando cualquier filtracin y proporcionando un sellado adecuado. Waterproofing, preventing leaks and providing a proper seal. Resistencia, para soportar sin roturas ni excesivo desgaste los efectos de impacto y abrasin debidos al trfico. Resistance, to bear without crack or excessive wear the effect of impact and abrasion due to traffic.
Se componen de una estructura de acero recubierta con caucho vulcanizado que permite la absorcin de los movimientos de contraccin y dilatacin de los tableros de puente. They consist of a steel structure covered with vulcanized rubber, allowing the absorption of contraction and expansion movement of the bridge decks.
Los mdulos se fijan con pernos de anclaje a los bordes de la estructura mediante resinas epoxi y son reforzados con arandelas y tuercas autoblocantes. The module edges are fixed with bolts using epoxy resins, and are reinforced with washers and locking nuts.
El diseo de cada tipo de junta ha sido realizado para soportar largos ciclos de carga (compresin dilatacin) as como para la absorcin de los esfuerzos, disminuyendo de esta manera su transmisin a los sistemas de anclaje. Each Joint has been designed to withstand long loading cycles (compression-expansion), as well as to support the absorption of effort, reducing force transmission to anchor system.
www.tecaplas.com
JUNTA DE CALZADA EXPANSION JOINT FOR BRIDGES TIPOS DE JUNTA / JOINT TYPES CTP-50 / CTP-75
JUNTA PARA PEQUEOS DESPLAZAMIENTOS Y PEQUEAS CARGAS JOINT FOR SLIGHT DISPLACEMENTS AND SLIGHT LOADS
Modelo Model
Movimiento Admitido (mm) Accepted movement (mm) Apertura Opening Cierre Closure - 25 - 37,5 a 207 220 b 203 219 c 35 34
Peso Weight (kg) g 292 305 h 143 145 L 1752 1829 26,2 19,4
d 40 45
e 35 40
f 146 152
CTP-50 CTP-75
+ 25 + 37,5
Nota: Movimientos admitidos en puentes Sin esviaje / Remark: Movements supported on No skewed bridges
CTP-50
a c d e b
CTP-75
a c d e b
www.tecaplas.com
www.tecaplas.com
Modelo Model
Movimiento Admitido (mm) Accepted movement (mm) Apertura Opening Cierre Closure - 21 - 26 - 35 - 40 a 240 266 352 427 b 235 262 345 422 c 37 40 45 55
Peso Weight (kg) g 333 305 305 305 h 186 208 280 339 L 2000 1829 1829 1829 32,2 37 60,6 81,6
d 35 50 73 86
e 35 48 52 74
+ 21 + 26 + 35 + 40
Nota: Movimientos admitidos en puentes Sin esviaje / Remark: Movements supported on No skewed bridges
L a c d e b
D Tipo Type A B A C B C D CTP-42 18 54 71 31 CTP-52 19 54 74 39 CTP-70 19 53 74 39 CTP-80 22 61 97 57
www.tecaplas.com
Modelo Model
Movimiento Admitido (mm) Accepted movement (mm) Apertura Opening Cierre Closure - 50 - 65 - 80 - 115 - 165 a 580 585 711 892 1198 b 575 583 704 880 1186 c 55 55 78 98 128
Peso Weight (kg) g 305 305 305 305 305 h 495 510 607 787 1080 L 1829 1829 1829 1829 1220 134,8 145 238 349 414
+ 50 + 65 + 80 + 115 + 165
Nota: Movimientos admitidos en puentes Sin esviaje / Remark: Movements supported on No skewed bridges
CTP-130
a c
e d b
www.tecaplas.com
www.tecaplas.com
Dureza Shore A () Hardness Shore A () Densidad (gr/cm3) Density (gr/cm3) Carga de rotura (Mpa) Tensile Strength (Mpa) Alargamiento (%) Ultimate Elongation (%) Resistencia al desgarro (N/mm) Tear Resistance (N/mm) Envejecimiento trmico (7 das a 70C) Hot Air Aging (7 days under 70C) Variacin de dureza Shore A Shore A Hardness Variation Variacin de carga de rotura (%) Tensile Strength Variation (%) Variacin de alargamiento rotura (%) Ultimate Elongation Variation (%) Resistencia al ozono Ozone Resistance
ISO 7619-1 ISO 2781 ISO 37 ISO 37 ISO 34-1 ISO 188
Lmite elstico (Mpa) Elastic Limit (Mpa) Resistencia a traccin (Mpa) Tensile Strength (Mpa) Alargamiento (%) Elongation (%)
235 360 26
www.tecaplas.com
Estado Machihembrado Tongue and Groove Connection Anlisis Dimensional Dimensional Test Ancho (mm) Width (mm) Alto (mm) High (mm) Longitud (mm) Length (mm)
Tipo de junta Exp. Joint CTP-50 CTP-42 CTP-52 CTP-70 CTP-75 CTP-80 CTP-100 CTP-130 CTP-160 CTP-230 CTP-330
Profund mnima taladro (mm) Esprrago taladro en hormign Drill Head Threaded Rod Minimum drill depth in (mm) concrete 16 16 16 18 18 22 22 21 22 28 32 M-14 M-14 M-14 M-16 M 14 M-18 M-18 M 18 M-20 M-22 M-27 80 80 80 100 80 100 100 100 150 150 200
Tuerca Nut M-14 M-14 M-14 M-16 M 14 M-18 M-18 M 18 M-20 M-22 M-27
Arandela Washer 35x45x3,5 35x45x3,5 35x45x3,5 40x50x4,0 35x45x3,5 50x60x4,0 50x60x4,0 50x60x4,0 50x70x5,0 51x72x6,0 60x70x6,0 17 17 17 18 17 23 23 23 23 25 31
www.tecaplas.com
Junta / Joint
Calzada/Road
Junta / Joint
100g
Puentes rectos / Straight Bridges
Tipo de junta Joint Type CTP-42 CTP-50 CTP-52 CTP-70 CTP-75 CTP-80 CTP-100 CTP-130 CTP-160 CTP-230 CTP-330
Movimientos Admitidos (mm) Accepted Movement (mm) Apertura Opening - 21 - 25 - 26 - 35 - 37,5 - 40 - 50 - 65 - 80 - 115 - 165 Cierre Closure + 21 + 25 + 26 + 35 + 37,5 + 40 + 50 + 65 + 80 + 115 + 165
www.tecaplas.com
g
Junta / Joint
A M B A
g
B A M
Junta / Joint
Calzada/Road oak
Junta / Joint
90
80
70
60
50
CTP-52 CTP-230
40
30
CTP-160 CTP-330
20
10
CTP-130
CTP-70 CTP-80
www.tecaplas.com
TECAPLAS, S.L. Pol Ind El Campillo Pab D-9-8 48500 Gallarta (Bizkaia) Tfno 94 636 34 64 Fax 94 636 38 26 www.tecaplas.com
www.tecaplas.com