Documente Academic
Documente Profesional
Documente Cultură
http://www.codecogs.com/library/engineering/materials/beams/elastic-foundations.php There are many problems in which a beam is supported on a compressible foundation which exerts a distributive reaction on the Beam of intensity proportional to the compressibility. In some cases the foundations can only exert upward forces and the beam may, if it is sufficiently long, lose contact with the foundation. In other cases pressure may be exerted either way. Again the support may not be truly continuous( eg. the support of railway lines) but can be replaced by an equivalent distributed support. If is the upward deflection of the foundation at any point, then the rate of upward reaction is .
A beam is a horizontal structural element that is capable of withstanding load primarily by resisting bending. The bending force induced into the material of the beam as a result of the external loads, own weight, span and external reactions to these loads is called a bending moment.
Or
(2)
(a) Long Beam Carrying A Central Load. Elastic force is a force arising from the deformation of a solid body which depends only on the body's instantaneous deformation and not on its previous history, and which is conservative. This example assumes that the foundations can only exert an upward force. The length of beam in contact with the foundations is and the Origin is at the left-hand end.
A solution to
At
And
Also Giving:
At
which determines the length in contact with the ground. is obtained from the condition that the Shear Force at the centre
since by symmetry it must be numerically the same on either side of the load and it on passing through the load.
Deflection is a term that is used to describe the degree to which a structural element is displaced under a load.
foundations at all points. Again taking the origin at the left hand end and the overall length of the Beam as , then the following conditions are obtained for the constants of integration of
At
And
And
At
And Thus
Solving for
and
since
as
And
Giving
(3) And the least solution is The maximum deflection and Bending Moment are at
Example - Example 1
Problem
A steel railway track is supported on timber sleepers which exert an equivalent load of 400lb./in. length of rail per inch deflection from its unloaded position. For each rail and .
If a point load of 10 tons acts on each rail, find the length of rail over which the sleepers are depressed and the maximum Bending Stress in the rail.
Workings
Each rail can be considered to be an infinitely long beam for which the length over which the downward deflection occurs is given by equation (2)
Solution