Documente Academic
Documente Profesional
Documente Cultură
D
G
F
E
7
ASSEMBLY INSTRUCTIONS
5
5. Connect hose and regulator to cylinder.
The propane gas and cylinder are sold separately.
Use a standard 16.4 Oz. tank propane cylinder only.
Use this heater only with a propane vapor withdrawal
supply system. See chapter 12 of the standard for
storage and handling of liquefied petroleum gas,
ANS/NFPA 58 or CSA B149.1, Natural Gas and
Propane nstallation Code. Your local library or fire
department should have this book.
Storage of an appliance indoors is permissible only if
the cylinder is disconnected and removed from the
appliance. A cylinder must be stored outdoors in a
well-ventilated area out of the reach of children. A
disconnected cylinder must have dust caps tightly
installed and must not be stored in a building, garage
or any other enclosed area. The maximum inlet gas
supply pressure: 150 psi, The minimum inlet gas supply
pressure: 5 psi. is required for purpose of input adjustment.
The minimum hourly of 1500 Btu/hr is required input
rating for a heater at ratings less than full input rating.
The pressure regulator and hose assembly supplied with
the appliance must be used. The installation must conform
with local codes, or in the absence of local codes,with
national fuel gas code, ANS Z223.1/NFPA54, natural
gas and propane nstallation Code, CSA B149.1, or
propane storage and handling code, B149.2.
Standard 16.4 Oz. tank
!
OPERATION INSTRUCTIONS
#$%&'(
CARBON MONOXDE HAZARD
For outdoor use only. Never use inside house, or other
unventilated or enclosed areas. This heater consumes air
(oxygen). Do not use in unventilated or enclosed areas to
avoid endangering your life.
Before Turning Gas Supply ON:
1. Your heater was designed and approved for outdoor use only. Do NOT use it inside a building,
garage, or any other enclosed area.
2. Make sure surrounding areas are free of combustible materials, gasoline, and other flammable
vapors or liquids.
3. Ensure that there is no obstruction to air ventilation. Be sure all gas connections are tight and
there are no leaks.
4. Be sure the cylinder cover is clear of debris. Be sure any component removed during assembly or
servicing is replaced and fastened prior to starting.
Before Lighting:
1. Heater should be thoroughly inspected before each use, and by a qualified service person at least
annually. f relighting a hot heater, always wait at least 5 minutes.
2. nspect the hose assembly for evidence of excessive abrasion, cuts, or wear. Suspected areas
should be leak tested. f the hose leaks, it must be replaced prior to operation. Only use the
replacement hose assembly specified by manufacturer.
Finally, put the assembled product onto proper level ground for good stability.
Now your item is ready for use.
3. OPERATON
3.1 Preparation before lighting
Make sure Control Knob is at OFF position.
To connect to 16.4 oz. Canister:
Open the door, grasp the regulator by one hand and screw
clockwise threaded end of canister into threaded regulator inlet
from the bottom of Base until tight.
NOTE: Be careful not to bend flexible Gas Hose. f gas hose is
bent, gas flow could be reduced, or a gas leak could occur. nspect the visible portion of the hose
prior to each use, and the accessories supplied with the heater.
IMPORTANT: Only use a standard 16.4 propane cylinder which is constructed and marked in
accordance with the specifications for LP-gas cylinder of the U.S. Department Of Transportation
(D.O.T.). Disconnect the cylinder when the appliance is not in use.
Caution: Do not attempt to operate until you have read and understand all General Safety Information
in this manual and all assembly is complete and leak checks have been performed.
Figure 1
9
OPERATION INSTRUCTIONS
CHECK FOR LEAKS
Make 1-2 oz. of leak solution by mixing one part liquid dishwashing soap and 3 parts water.
To check for leaks when connecting to 16.4 oz cylinder Apply several drops of the solution to the
connection between regulator and cylinder. nspect connection and look for bubbles.
f no bubbles appear, the connection is safe, continue the next step- lighting. f bubbles appear,
there is a leak. Disconnect and reconnect, try again. f the leak persists, disconnect the canister and
contact gas supplier for assistance and advice.
WARNING:
Only perform leak tests outdoors. Never perform leak test when smoking. Do not use an open
flame to test for leaks.
3.2 Lighting
Push in Control Knob and rotate counter-clockwise to ON Position,
push igniter button to light. There may be occasions that several times
of lighting would be needed.
3.3 Heat Setting Control
Press and turn the control knob to ON position, the burner will be lit
immediately. Press and turn the control knob to the heat setting required.
!"#$% While in use, the burner flame should be mainly blue in appearance with a small amount of
Yellow. Consult your store of purchase if satisfactory performance cannot be obtained.
WARNING: f you smell gas while in use, immediately press and turn the control knob to "OFF
position to shutdown the heater. f burner does not light, turn off, wait 5 minutes and repeat from
Step 3.3.
3.4 Turn off
Turn Control Knob clockwise to OFF position to shut down the heater.
Disconnect canister and remove when the Gas Lantern is not in use.
WARNING: Please strictly follow the ignition procedures. mproper lighting procedures with
electronic ignition may cause severe injury, death or property damage.
4. STORAGE
Store the Gas Lantern outdoors in a cool, dry and well ventilated area out of the reach of children,
and not in a building, garage or any other enclosed area. Store the Gas Lantern upright in a
sheltered area away from inclement weather and dust. ndoor storage is permissible only if the
cylinder is removed.
Correct flame:
Blue
Yellow
incorrect flame:
Blue
10
OPERATION INSTRUCTIONS
5. MAINTENANCE
To obtain the best performance from your heater, make sure you perform the following mainte-
nance activities on a regular basis:
Keep exterior surfaces clean. Use warm soapy water for cleaning. Never use flammable or
corrosive cleaning agents. Be sure to keep the area around the burner and control
assembly dry at all times.
Keep the ventilated openings of the cylinder enclosure free and clear from debris.
Check your Gas Lantern for possible damages or wear and replace components as
necessary.
Keep the appliance area clean and free from combustible materials, gasoline and other
flammables.
6. TROUBLESHOOTING
ProbIem What To Do
Burner won't light Check if the gas cylinder contains gas.
The Burner jet may be blocked, clear blockage.
Check if Control knob is in ON.
Burner flame is low The Gas pressure may be low, turn cylinder valve OFF and replace
cylinder.
The Burner jet may be partially blocked, clear blockage.
11
The appliance has been manufactured under the highest standards of quality and workmanship. We
warrant to the original consumer purchaser that all aspects of this product will be free of defects in
material and workmanship for three (3) year from the date of purchase. A replacement for any defective
part will be supplied free of charge for installation by the consumer. Defects or damage caused by the
use of other than genuine parts are not covered by this warranty. This warranty shall be effective from
the date of purchase as shown in the purchaser's receipt.
This warranty is valid for the original consumer purchaser only and excludes industrial, commercial or
business use of the product, product damage due to shipment or failure which results from alteration,
product abuse, or product misuse, whether performed by a contractor, service company, or consumer.
We will not be responsible for labor charges and/or damage incurred in installation, repair or replace-
ment, nor for incidental or consequential damage.
LAVA HEAT TALA
Toll free No.: 1.888.779.LAVA 1.888.779.5282
Addr.: 5999 Malburg Way, Vernon, CA, 90058
THREE-YEAR LIMITED WARRANTY
When You Receive Your Product:
f Your Product is..
Damaged
Requires Technical Support
Requires Parts
Or f You Have A Sales Question Or You Would Like To Offer Product Feedback
Please contact the manufacturer:
LAVA HEAT ITALIA
888.779.5282 or
CS@LAVAHEAT.COM
DO NOT RETURN PRODUCT TO RETALER!