Documente Academic
Documente Profesional
Documente Cultură
Oxidative degradation is slower in solutions even in the absence of added antioxidants; This protection depends on the chemical nature of the solvent and the physical conditions of storage. Air and light should be avoided. The best storage conditions are a super freezer (- !"#$ to store for a long time (up to one year$ lipid extracts in chloroform-methanol mixtures filling well stoppered glass vials (with Teflon liners$% the cap being secured with a wide length of self-stic&ing tape. 'encil written labels should be protected by an outer layer of polyester tape. (or long period of storage% it can be useful to flush vials or tubes with nitrogen before closing to prevent fatty acid oxidation. (or the same purpose% a low amount of antioxidant such as )*T (butylated hydroxytoluene or +%,-di-tert-butyl---methoxyphenol$ or ethyl gallate (i.e. about .! /g )*T0ml$ may be added in the solvent if the natural antioxidant amount is estimated too low (purified extracts$. The antioxidant is used as a concentrated solution in ethanol (1! mg0ml$. After long periods of storage% the cleavage of ester lipids and plasmalogens must be expected with a concomitant rise in free fatty acids% diacylglycerols methyl or ethyl esters. These problems can be minimized by using neutral extracts and +-propanol instead of methanol or ethanol in the solvent mixture. 2t must be remembered that best results are obtained with freshly prepared materials. To prevent labile lipids from oxygen attac& it is possible to use a commercially available oxygen absorber (Ageless% 3itsubishi 4as #hem #o$ placed inside the sample pac&age. After a short 5pretreatment5 at +"#% the labile lipids appear preserved even at room temperature for a long time. This method allows transportation of biomaterial samples to a distant laboratory without utilizing any freezing system (Hirao S et al., J Oleo Sci 2003, 52, 583$. 2t has been demonstrated that after one year storage of plasma samples at -6!"# various lipid parameters (cholesterol% triglycerides$ were altered (Devanapalli B et al., Clin Chim Acta 2002, 322, 17 $. Thus% even at low temperature% intact biological samples must be extracted as soon as possible. 2n contrast% it was shown that after storage at -6!"# up to - years% the fatty acid compositions of plasma triglycerides and erythrocyte phospholipids were practically unchanged (Ho!"on # et al., Clin Chim Acta 2002, 321, $3$.
Introduction
+he preser"ation and storage of !A is of interest to scientists in a 'ide range of fields and disciplines( .hen considering 'hat is meant by the terms /preser"ation0 and /storage0, it must be remembered that the perspecti"es of these scientists 'ill "ary considerably( 1or e,ample, !A re*uired for testing a pharmaceutical product 'ill need to be stable for a fe' years, 'hereas samples used in e"olutionary biology ha"e been in e,istence for millions of years1( +he do'nstream applications in 'hich these samples may be used are "ery different and therefore the minimum *uality and *uantity of !A re*uired 'ill "ary( Although nuclease contamination must al'ays be carefully a"oided 'hen handling !A, it is chemical degradation that represents the ma2or threat to !A preser"ation(
Room temperature on a /dry0 solid matri, 3204C 3504C 31674C #storage in li*uid nitrogen&
+'o of these methods, dried and stored at room temperature and storage at 31674C, share a common mechanism 'here the !A is maintained in a glassy #or "itreous& state( )n the glassy state, molecules lose the ability to diffuse such that the mo"ement of a proton is estimated to be appro,imately one atomic diameter in 200 years, thereby pre"enting chemical and nuclease degradation( )f moisture is added to the /dry state0 or the temperature is raised abo"e the glass transition temperature of 'ater, mo"ement and reacti"ity of protons is reestablished and damage to the !A can occur2(
$lass is a state of matter8 glasses combine some properties of crystals 'ith some properties of li*uids( $lass formation, or "itrification, is the creation of a li*uid solution 'ith the "iscosity of a solid( $lasses can be formed either by increasing the solution concentration or by lo'ering temperature( )n fro9en a*ueous samples, glasses are formed by a combination of the t'o( $lasses are usually supersaturated and thus metastable, but the high "iscosities and acti"ation energies re*uired for phase separation may pre"ent decomposition for long periods, the duration being dependent upon composition and temperature( +he formation of glasses is normal for substances that remain li*uid o"er a 'ide temperature range #the :good glassformers:& and can be induced for most li*uids if cooling is fast enough to bypass crystalli9ation( uring reheating, but still belo' the melting point, good glassformers e,hibit glass transitions as they abruptly transform into supercooled li*uids, 'hereas other substances transform directly from the glassy to the crystalline state;( <torage at 3204C to 3504C may 'ell pro"ide ade*uate conditions depending on the *uality and *uantity of !A desired and the time frame in 'hich the sample 'ill be stored( %o'e"er, neither of these conditions 'ill maintain !A *uality e*ui"alent to maintenance at li*uid nitrogen temperatures o"er e,tended time periods #e(g( decades&( )n contrast to storage of !A in solution at "ery lo' temperatures, it is also possible to store !A dried( +his can be a practical alternati"e for long-term storage( )n addition to reducing molecular mobility, dehydration also remo"es 'ater that can participate in hydrolytic reactions( +here are se"eral methods of remo"ing 'ater from li*uid preparations8 these include spray drying, spray free9e drying, air drying or lyophilisation( <praying !A is perhaps the least popular option as it has been associated 'ith damage introduced by shear stress( Another option for storage of dried !A is on 1+A= Cards #.hatman&( Cells are lysed upon application to the card and the nucleic acids are immobili9ed( <tudies ha"e sho'n that genomic !A that has been stored on 1+A Card at room temperature for o"er 1> years has been successfully amplified by PCR?( +he cards are supplied 'ith a reagent 'hich enables high molecular 'eight !A to be released from the matri, for use in many molecular biology techni*ues( Although !A stored on 1+A Cards may be suitable for microarray studies, this has not been tested by @$+( )n a laboratory setting, !A is most commonly stored at ?4C, 3204C or 3504C( +o a"oid chemical and en9ymatic degradation, !A is often stored as a precipitate in ethanol at 3 504C( Ander these conditions, nucleic acids are stable for prolonged periods, but must be isolated from the ethanol, transferred to a*ueous buffers, and typically *uantified prior to use( +hese manipulations render ethanol precipitations undesirable for applications 'here the samples are needed on a regular basis( A*ueous solutions of !A 'ould be the most con"enient, but nucleic acids are sensiti"e to depurination, depyrimidination, deamination and hydrolytic clea"age, 'hich limit prolonged storage under these conditions( )t is possible to inhibit these acid-catalysed degradation processes by storage in al-aline solutions( +he ionic strength of the solution 'ill also affect depurination rates, so storage in salt solutions as opposed to a lo' ionic strength buffer 'ill help( Assuming the absence of nucleases 'hen !A is stored in a saline solution 'ith p%5(B, the most common form of damage is "ia o,idation( +he rate of o,idation is enhanced by the presence of trace metals #e(g( 1e;C, Cu2C& due to the production of free radicals "ia 1enton-type reactionsB(
+he rate of o,idation is enhanced by the presence of trace metals #e(g( 1eDC, CuEC& due to the production of free radicals "ia 1enton-type reactions?(
and Iiagen recommend that samples are tha'ed *uic-ly at ;>4C rather than slo'ly at room temperature10( +here is some contro"ersy regarding !A damage resulting from repeated cycles of free9etha'ing and it is common practice to store !A in ali*uots to minimise the number of times the !A is tha'ed( )nterestingly, a study by Hethesda Research Maboratories11 found no e"idence that free9e-tha'ing cycles causes !A damage( +hey made the obser"ation that pre"ious studies e,amining the effect of repeated free9ing and tha'ing used radio-labelled !A and the radioacti"e label itself 'as causing damage to the !A rather than the number of free9e tha' cycles( %o'e"er, as a cautionary note, this study utilised high *uality !A( <toring ali*uots of !A 'ould still be beneficial in order to minimise degradation, 'hich could occur at higher temperatures due to impurities, and to a"oid contaminating the main !A stoc-(
Summary
+o ensure high *uality microarray results, 'e recommend the follo'ing !A storage strategies:
<hort-term storage #'ee-s& at ?4C in +ris-K +A Medium-term storage #months& at 3504C in +ris-K +A Mong-term storage #years& at as 3504C as a precipitate under ethanol Mong-terms storage #decades& at 317?4C or dried
Oil Palm
7orang pernah wat minya& masa& sendiri x &t umah8 &orang tau x n& wat minya& tu cmne8 *aa............... sini a&u &asi a9ar n&8 hehehehe
Actually buda&+ .2&htisas ni yg 9d mangsa masing+ a&u pa&sa &e9e &t &ilang sawit a&u muahahahahhaha
A&u minta& tlg sorang pela9ar a&u ni ut& bawa buah sawit dr ladang yg ayah dia 9aga
)ila dh lerai..9adila sebi9i+ then a&u minta& tlg :ab Assistant a&u tolong rebus&an buah+an tempatan ni
7alo &orang na& tau buah &elapa sawit ni terdiri drpd beberapa bahagian tg& &t diagram ni
3inya& paling )A;<A7 se&ali diperolehi drpd 3=>O#A?' tapi minya& yg paling yg s&it ingat tu murid+AAAAA soalan biasa dlm >'3 ni..
)=?7@A:2T2
pla& dari
7=?;=:
tp dlm &uantiti
C. 'enghancuran
- mengoya&&an sabut dr tempurung (a&u suh buda&+ ni potong buah &elapa sawit tu then &uar&an endocarp D &ernel$ - menghancur&an dan mencerna buah &elapa sawit
A&u suh buda&+ ni bw& lesung batu dr omah tapi yg ni lesung bau ma&mal tenyeh betol+ &asi lumat itu mesocarp
2sh cmne pla& boleh ada &umbang tai& di antara bunga+ tu eh8
-. 'ene&anan (penge&stra&an$
- minya& diperah daripada sabut dengan mengguna&an te&anan hidrauli&
;i alat ut& te&an mesocarp yg dh ditumbu& td tp lobang idong sapa pla& tu eh8
.. 'enurasan
- mengeluar&an bendasing pepe9al (x buat pon &t lab a&u ni hari tu$ B$
,. 'enulenan
- stim dialir&an melalui minya& untu& menying&ir&an sebarang bau - minya& &elapa sawit dialir&an melalui &arbon yang dia&tif&an untu& menghilang&an warna
sbb lema& ta& tepu adalah lema& yg terhasil drpd tumbuh+an dan lagi 1 info yg a&u n& bgtau &orang suma warna oren yg ada pd minya& &elapa sawit tu adalah )=TA
ia 9uga mengurang&an risi&o mengidap penya&it &anser% penya&it 9antung dan &atara&
A% E% =% 7