Documente Academic
Documente Profesional
Documente Cultură
Equipment Description
1.0 Fuel oil system design documents 1.1 Ignition oil (LDO) Item Kinematic viscosity at 38 Pour point Mec anical impurity !lose cup "las point %ul"ur &uality percent 'ater volume percent *s &uality percent !ar+on residual &uality ( summer12,winter18 non #$$ 1.8 ).25 ).)2 1.5 unit cst Medium value 2.5-15.7
percent 1.2 Combustion supporting oil (HFO ) ! aracteristics *cidic mineral *s &uality percent ,i/ calori"ic power -las pointmin Kinematic viscosity at 5)cst1ma23 4esidual &uality percent1ma23 5otal sul"ur &uality percent1ma23 'ater content volume percentma2 7itumen &uality percentma2 ,-. none ).1 11)))cal0/ $$ 18)cst ).25 6.5 1.) ).25
1. Fuel oil system description Indian 8,*4%9:9;* independent power plant pro<ect 6=$))mw units +oiler is 26 tan/ential swin/, ori>ontal and dense dilute +urners are divided into $ layers and assi/ned to t e "our an/les at t e +ottom o" t e +oiler? t e coal powder and air are conveyed "rom t e "our an/les and +urned in tan/ential circle in t e +oiler. 5 e +oiler uses t e composite -uel oil wit @i/ t ;iesel .il 1@;.3 and ,eavy -urnace .il 1 ,-.3 . 7oiler startup to 1)(7M!4As "uel is t e @;. and t e lower load operation "uel is t e ,-.. .il +urner total input eat is 3)( o" M!4. 5 e +oiler
i/nition system uses t e i/ ener/y electric sparBle to li/ t t e @;., t en li/ t t e ,-., coal powder. 9se t e steam actuator to control t e in and out o" t e i/ ener/y electric i/niter. 5 is +oiler is desi/ned to ave one layer @;. /uns and t ree layers ,-. /uns. In t e oil Pump ,ouse area, t ere are 5wo ,-. %teel 5anBs 1 * C 73 Dac !apacity 2))) K@, 5wo ,-. ;ay tanB1 *C 73 Dac !apacity 2)) K@ , 5wo @;. tanB1 * C 73 Dac capacity 3)) K@ . 5 e oil pumps ave t ree ,-. %upply Pumps, two @;. %upply pumps -or Main 7oiler and one @;. %upply Pump "or %tartup +oiler 1*u2iliary 7oiler3 maBe up. 5 e oil unloadin/ system as two ,-. unloadin/ pumps and two @;. unloadin/ pump. 7esides t ere is one dirty oil pump, one waste water disposal pump, two ;rain water pumps and ot er e&uipment. Dac pump inlet is mounted wit oil "ilter and ,-. pump outlet is mounted wit 5wo ,eater 11 2 1))(3. 5 e ,-. tanBs are mounted wit %team !oils w ic ,-. 4eturn oil to t e ,-. ;ay tanB. 1.6 -uel oil system main au2iliary unitAs speci"ications 1.6.) LDO !"LO#DI"$ %!&%
Fo. 1 1.1 1.2 1.3 1.6 1.5 1.$ 1.7 2 2.1 2.2 2.3 2.6 2.5 2.$ Item P9MP Guantity 5ype and model Installation mode -low rate li"t revolutions % a"t power &otor model manu"acture 4ated power Protection level rated volta/e0rated current 4ated "re&uency covera/e 4ated speed J0* ,> r0min B' 9nit .il unloadin/ pump %in/le sta/ed centri"u/al oil pump 5wo 1 1 2 1)) (3 8)*HP$)* ,ori>ontal type 5) ).6 2I3) 15 H71$)M2-2 Kiamus>e motor maBer 15 IP55 615028.$ 5)K5( 2I3)
au2iliary steam ,eader 19 E23 system. 5 ere is 5wo oil cooler 122 5)(3 "or !oolin/
1.'.1 LDO (upply pumps Fo. 1 1.1 1.2 1.3 1.6 1.5 1.$ 1.7 2 2.1 2.2 2.3 2.6 2.5 2.$ item pump Guantity 5ype and model Installation mode -low rate li"t revolutions % a"t power Motor model manu"acture 4ated power Protection level
4ated Jolta/e 0rated current
unit
8)*H5)LI ,ori>ontal type 61 6.8 2I5) I6.7 H7315M-2 Kiamus>e motor maBer 132 IP55 6150233.2 5)K5( 2I8)
1.'.) (t*rt up +oiler &*,e up %ump Fo. 1 1.1 1.2 1.3 1.6 1.5 1.$ 1.7 2 2.1 2.2 2.3 2.6 2.5 2.$ item pump Guantity 5ype and model Installation mode -low rate li"t revolutions % a"t power Motor model manu"acture 4ated power Protection level
rated volta/e0rated current
unit
6)*H35L3 ,ori>ontal type $.25 1)) 2I)) $.$ H71$)M-2 Kiamus>e motor maBer 11 IP55 615021.5 5)K5( 2I3)
1.'. HFO !nlo*ding pumps Fo. 1 1.1 1.2 1.3 1.6 1.5 1.$ 1.7 2 2.1 2.2 2.3 2.6 2.5 2.$ item pump 5ype and model Guantity Installation mode -low rate li"t revolutions % a"t power Motor model manu"acture 4ated power Protection level
4ated volta/e0rated current
unit
m0 M Pa r0min B'
,ori>ontal type 7) 1.) 165) $.$ H7225%-6 Kiamus>e motor maBer 37 IP55 6150$I.I 5)K5( 168)
1.'.' Dr*in -*ter pump Fo. 1 2 3 6 5 $ 7 8 I item pump 5ype and model Guantity Installation mode -low rate li"t Inlet steam pressure
.utlet steam pressure1 Ma23
unit
m0 M Pa M Pa M Pa
%team 5emperature
1.'.. HFO (upply pump Fo. 1 1.1 1.2 1.3 1.6 1.5 1.$ 1.7 2 2.1 2.2 2.3 2.6 2.5 item unit ,-. %upply pump 5 ree screw oil pump ,%F,13))-62
5 ree 11 2 1)) (3
pump 5ype and model Guantity Installation mode -low rate li"t revolutions % a"t power Motor model manu"acture 4ated power Protection level rated volta/e0rated current 4ated "re&uency0"re&uency covera/e 2.$ 4ated speed
m0 M Pa r0min B'
,ori>ontal type 5$ 2.8 165) 68.$ H728)%-6 Kiamus>e motor maBer 75 IP55 61501)3.3 5)K5( 168)
1.'./ Dirty oil pump Fo. 1 1.1 1.2 1.3 1.6 1.5 1.$ 1.7 1.8 2 2.1 2.2 2.3 2.6 item pump 5ype and model Installation mode -low rate li"t revolutions % a"t power Motor model manu"acture 4ated power Protection level
rated volta/e0rated current
unit
;irty oil pump :ear oil pump 2!H201.) ,ori>ontal type 2 1.) 162) 1.2 H71))@-6 Kiamus>e motor maBer 2.2 IP55 6150$.78 5)K5( 162)
1.'.0 Direct Lin, %ump Fo. 1 1.1 1.2 1.3 1.6 1.5 1.$ 1.7 2 2.1 2.2 2.3 2.6 2.5 item pump 5ype and model Guantity Installation mode -low rate li"t revolutions % a"t power Motor model manu"acture 4ated power Protection level
rated volta/e0rated current 4ated "re&uency0"re&uency covera/e
unit
m0 M Pa r0min B'
,ori>ontal type 8) ).5 2I)) 16.2 H18)-2P-2 Kiamus>e motor maBer 22 IP55 615061 5)K5( 162)