Sunteți pe pagina 1din 4

Sheree Ann M.

Labe Bachelor of Science in Architecture ARCHT 26 A ASSIGNMENT Shallow Foundation Shallow or spread foundations are employed when stable soil of adequate bearing capacity occurs relatively near to the ground surface. They are placed directly below the lowest part of a substructure and transfer building loads directly to the supporting soil by vertical pressure. Deep Foundation Deep foundations are employed when the soil underlying a foundation is unstable or of inadequate bearing capacity. They extend down through unsuitable soil to transfer building loads to a more appropriate bearing stratum of rock or dense sands and gravels well below the superstructure. Pole Foundation Pole Foundation elevate timber structures above the ground plane require minimal, and preserve the natural features and existing drainage patterns of a site. They are particularly useful when building on steep and in areas subject to periodic flooding. Pile Foundation A pile foundation is a system of end-bearing or friction piles, pile caps, and tie beams for transferring building loads down to a suitable bearing stratum. Caisson Foundation Caissons are cast in-place, plain or reinforced concrete piers formed by boring with a large auger or excavating by hand a shaft in the earth to a suitable bearing stratum and filling the shaft with a concrete. For this reason, they are also referred to as drilled piles or piers. Underpinning Underpinning refers to the process of rebuilding or strengthening the foundation of an existing building, or extending it when a new exaction in adjoining property is deeper than the existing foundation. Footing A foundation unit constructed in brickwork, masonry or concrete under the base of a wall or column for the purpose of distributing the load over a large area. Footings are critical to the structural stability of a cottage. Footings are designed based on site topography, soil type, stability, and any other local requirements during the design process.

Sheree Ann M. Labe Bachelor of Science in Architecture ARCHT 26 A ASSIGNMENT Types of footings A. Strip Footings They are suitable for stable sites (Class A or S sites) that are flat or sloping. Timber framed construction with brick up to floor level may be constructed onto strip footings in reactive clay areas (Class M and H sites).

B.Pier and beam footings Footing beams for brick and brick veneer cottages on reactive clay soils (Class M and H) generally require piering to stable ground. Piering is always required where footings are influenced by adjacent drainage or Water Board sewer mains. Sites containing extremely reactive ground or uncontrolled filling require piering for footings of all types of construction.

C. Foundation Slabs (Raft Slabs) Types include: the conventional concrete slab with perimeter and internal beams and the (waffle pod) slab which has internal ribs 110mm wide spaced at 1200mm centres in both directions. This type of footing is used for all types of construction on all site classifications, however, there usage is generally

Sheree Ann M. Labe Bachelor of Science in Architecture ARCHT 26 A ASSIGNMENT restricted to sites containing less than 2.0m of fall. For steeply sloping sites other types of footing construction should be considered.

Sheree Ann M. Labe Bachelor of Science in Architecture ARCHT 26 A ASSIGNMENT D. Elevated Construction Homes on steep sites or sites prone to flooding generally have elevated floors supported on timber poles, steel posts, brick piers or concrete columns. Bracing is required to control sidesway. Timber poles can be of treated pine or hardwood. Treated pine poles can be set into concrete filled holes drilled into the ground while hardwood poles should be supported by a concrete plug in the base of the drilled pier hole which is filled with gravel.

S-ar putea să vă placă și