Documente Academic
Documente Profesional
Documente Cultură
Model TCSR-
daidongs@hanmail.net
Features
_ Continuous supervision of complete
Description
The supervision relay TCSR is designed for the supervision of trip circuits and other important control and monitoring circuits. The supervision function is based on a low-level (~ 6 mA) current injection principle. The injected current is sensed by two opto-couplers. In normal condition the indicator LED glows red and output relays are in picked-up condition. In the event of a fault, the measuring current goes below the operating value of the relay or completely stops flowing. The supervision relay operates (drops-off) after a delay of 1.0 sec and the indicator LED turns red. The supervision relay, for its functioning requires an auxiliary voltage (AC or DC) of a rated value to be connected to the terminals of section 5. This voltage can be the same as that of the supervised circuit or it could be a separate source with same magnitude (AC or DC). Should a fault occur in the auxiliary voltage supply, the LED does not glow and the output relay drops off. Relays with differing rated voltage for supervision circuit and auxiliary supply can be supplied as a special execution
trip circuit, independent of the circuit breaker position _ Detects faults in the supervised circuits, such as loss of voltage, circuit breakage, contact degeneration in connections and increased resistance in wires, contacts and coils _ Low-level measuring current enables application in sensitive or high resistance circuits _ Operation delay to avoid spurious signals. (For instance, on circuit breaker operations) _ Operation indication by a single dual-colour LED _ Complete range of rated voltages (either AC or DC) _ Galvanic isolation is possible between the auxiliary source and supervised circuit _ Very low burden on the auxiliary source
Application
The supervision function is particularly important when there is only one tripping coil and CB tripping is vital. (For instance, in the case of generator circuit breakers or any other important circuit breaker in distribution networks.) The supervision relay type TCSR is intended for continuous supervision of a circuit breaker trip circuit and to sound an alarm for loss of auxiliary supply or faults on the tripcoil or its wires. This is independent of the breaker position, faults on the breaker auxiliary contacts and faults in the supervision relay itself.
daidongs@hanmail.net
Technical data
1.Energizing quantities, rated values and limits
Rated voltage of super voided and auxiliary circuit UAUX Operative voltage range Operate (Drop-off) time at rated voltage UAUX & 25 Burden at rated voltage Auxiliary circuit(W) Supervision circuit(W) Mechanical durability 48, 110-125, 220V DC 80-110% of rated UAUX 0.8 1.0sec. 48 0.54 0.11 110 0.54 0.60 125 0.85 0.63 220 2.7 1.2
2.Contact data
Contact configuration (self reset) Max voltage with inconstant system Rated current Max. switching current Max. switching power Operating time Electrical endurance 1 C/O(1ab) 240V / AC 30V /DC 5A 8A 1250VA/240W Max.20msec 100,000 operations, at 30 operation/minute,
daidongs@hanmail.net
TCSR 1B11
TCSR 2B11
daidongs@hanmail.net
6.Dimensions
TCSR 1B11
TCSR 2B11
daidongs@hanmail.net