Dl
EZ-PATH I
OPERATIONS
AND
PROGRAMMING MANUAL
March 1996
Code No. 11865457
Rev. Bii
COPYRIGHT 1996 BRIDGEPORT MACHINES, INC., ALL
RIGHTS RESERVED
i
‘This manual describes software that contains published and unpublished works of
authorship proprietary to Bridgeport Machines, Inc. It is made available for use and
fnaintenance of our products, Under copyright laws, this manual, or the software it
escribes may not be copied in whole, of in part, without prior written consent of
Bridgeport Machines, Inc, except in normal software use, as described in the
software license agreement.
“The information in tis document is subject to change without notice and should
fot be construed as a commitment by Bridgeport Machines, Inc.
All software package identifying names appearing herein prefaced with BZ are
tradematks of Bridgeport Machines, Inc., All Rights Reserved. FZ-CAM® and any
‘oiher references to Bridgeport applications software are protected by copyright 1996
‘of Bridgeport Machines, Inc. All Rights Reserved.
KeTABLE OF CONTENTS
SECTION PAGE
Chapter 1
EZ-PATH HARDWARE
Ez-Path Hardware
‘Conwol Panel
Handwheels von
Operator's Panel
Computer Hardware
Chapter 2
STARTING UP THE EZ-PATH
Introduction ...
‘Tuming on the BZ-Path
Homing the Axes
Moving the Axes
Jogging the Axes
Reading the CRT
24
2a
24
Chapter 3
EZ-PATH TUTORIAL
Introduction
Cuting a Part onsen
‘Beginning the Part
Setting Tool Offsets ...
Roughing the Part
‘Making a Groove
Making Threads
Chapter 4
CONTROLS and BASIC OPERATION
‘Basic Operation
Key Functions ...
FLT LIB ston
¥2T OFFS
3 STOPS
ABS-TMP
INCH-MM
DR OVR
= SAVE PT
RUN enn
OPWRFD .
1 TL CHG
SaSSESEE