Documente Academic
Documente Profesional
Documente Cultură
Submitted by: 1.__Connell Marcus Wilson____ 2.__Adrain Williams___________________________ Course Instructor: ___________________________ Date the Experiment Completed: _____________ ECPI Honor Pledge
I pledge to support the Honor System of ECPI. I will refrain from any form of academic dishonesty or deception, such as cheating or plagiarism. I am aware that as a member of the academic community, it is my responsibility to turn in all suspected violators of the honor code. I understand that any failure on my part to support the Honor System will be turned over to a Judicial Review Board for determination. I will report to the Judicial Review Board hearing if summoned.
Signature:
__Connell Wilson_________
Table of Contents
1. Objective of the Experiment .............................................................................1 2. Theory ...................................................................Error! Bookmark not defined. 3. List of Equipment Used .....................................................................................1 4. Procedure............................................................................................................1 5. Data .....................................................................................................................1 6. Analysis of Data .................................................................................................2 7. Discussion of Results..........................................................................................2 8. Conclusions .........................................................................................................2
ECPI University
1.
The objective of the experiment is to measure the resistance of color coded resistor and potentiometer using a DMM, calculated value using a color coded resistor and potentiometer chart and compare results. 2. To measure the resistance at various turn on a DMM Calculated the resistor using chart Compare the measure and calculated resistance of the resistor Theory
In theory, the measured and calculated value should be the same or within a limited range. The device should give a more accurate reading compared to a calculated value.
3.
4.
Procedure
We collected the above items to measure a potentiometer using a DMM to see the measured reading after a counter clock wise, 1/3 clock wise and2/3 clock wise turn. We measured and calculate the collected color coded resistors value and compared measured value from the DMM. We measured the one and three node, as well as the two and three node.
5.
Data
6.
Analysis of Data
The lab experience met expectations. The data measured and calculated were acceptable values. Over all, the lab expert was a success.
7.
Discussion of Results
The data measured and calculated confirms the devices are calibrated and are working properly. The data measured and calculated findings confirmed the color coded resistors are label correctly. Also, the data determined which resistors must be discarded.
8.
Conclusions
In conclusion the experiments confirmed the theory the measured and calculated value should be the same or within a limited range. The device should give a more accurate reading compared to a calculated value. The data measured and calculated confirms the devices are working properly. The data measured and calculated confirms the color coded resistors are label correctly. Finally, the data determined which resistors must be discarded.
ECPI University