2004 American Honda Motor Co., Inc - All Rights Reserved.
AII 27345 (0409) 1 of 2 08P21-SHJ-1000-91
INSTALLATION INSTRUCTIONS Application Publications No. Issue Date SEP 2004 2005 ODYSSEY Accessory FENDERWELL TRIM P/N 08P21-SHJ-100 PARTS LIST Left front fenderwell trim Right front fenderwell trim Left rear fenderwell trim Right rear fenderwell trim NOTE: Fenderwell trims cannot be installed on a vehicle equipped with a front nose mask. 2 Inner protector TOOLS AND SUPPLIES REQUIRED Flat-tip screwdriver Pliers Rubber mallet Shop towel Liquid dishwashing soap and water INSTALLATION NOTE: These installation instructions show the left fenderwell trims being installed; the same procedure applies to installing the right fenderwell trims. Each fenderwell trim is identified by a label attached to the inside surface. Installing the Front Fenderwell Trims 1. Turn the steering wheel all the way counterclockwise. 2. Remove the expansion clip that secures the inner fender. Push in on the inner fender to release the clip. 3. Clean the area to be covered, and wax it with a high-quality paste wax. AII 27345 EXPANSION CLIP INNER FENDER Do not remove. 2 of 2 AII 27345 (0409) 2004 American Honda Motor Co., Inc - All Rights Reserved. 4. Pull the inner fender down, and position the fenderwell trim between the inner fender and the fender flange. 5. While holding the left front fenderwell trim firmly against the fender, squeeze the two mounting tabs around the fender flange as shown. If necessary, use pliers over a shop towel to bend the mounting tabs around the fender flange. 6. Attach the left front fenderwell trim and the inner fender to the front fender with expansion clip removed in step 1. 7. Turn the steering wheel all the clockwise and repeat steps 1 through 6 to install the right front fenderwell trim. Installing the Rear Fenderwell Trims 8. Position the left rear fenderwell trim on the fender flange, and align the rear of the fenderwell trim with the rear bumper. While holding the fenderwell trim firmly against the fender, bend the three mounting tabs around the fender flange. 9. Using a rubber mallet, install the inner protector over the fender flange and fenderwell trim. 10. Repeat steps 8 and 9 to install the left rear fenderwell trim. 4312051Y FENDERWELL TRIM RUBBER MALLET INNER PROTECTOR Apply dishwashing soap and water solution to the inside of the inner protector. FENDERWELL TRIM INNER PROTECTOR 4312034Y FRONT BUMPER LEFT FRONT FENDERWELL TRIM INNER FENDER LEFT FRONT FENDERWELL TRIM MOUNTING TAB EXPANSION CLIP INNER FENDER MOUNTING TAB FENDER FLANGE 4312041Y MOUNTING TAB MOUNTING TABS (3) REAR BUMPER FRONT LEFT REAR FENDERWELL TRIM LEFT REAR FENDERWELL TRIM LEFT REAR FENDERWELL TRIM FENDER FLANGE