Sunteți pe pagina 1din 1

PERMPAVE

Version no. 2,2


Project: ferhadija
Client: design & qc
Person responsible for this analysis: mboss
Date: 03-18-2012 Time: 14:03:30
PROJECT OBJECTIVE AND APPLICATION
Permeable pavement functional objective: Stormwater flood mitigation
Permeable pavement functional operation is: Infiltration and pipe discharge.
Type of Traffic Application: ROAD PAVEMENTS carrying normal traffic such as cars, trucks and buses licensed to use public highways
Required Service Life :10 years
SUMMARY OF INPUT DATA
Location is: Melbourne
Permeable paving area: 2000 m2
Contributing non-permeable paving area: 0 m2
Average Recurrence Interval: 20 years
Storm duration:10 min
Average Rainfall Intensity: 93 mm/hr
Peak outflow reduction :300 %
HYDROLOGICAL RESULTS
Peak runoff flow to the paver system is: 55,8 L/s
Peak runoff flow leaving the paver system is: 0 L/s
Peak runoff flow leaving at the paver surface is: 0 L/s
Storage volume required : 18,0000002682209 kL
Minimum depth of basecourse is: 100, mm
Discharge pipe diameter: 10, mm
PAVEMENT DETAILS
Type of Porous Paver: Pavers with widened joints
Assumed Infiltration Rate: 500 L/s/ha
Required Thickness of Porous Pavers: 80mm Min
Jointing Material: Use 1 to 3 mm clean aggregate. Alternatively, if feasible, use bedding material in joints also.
Bedding Material: Use 2 to 6 mm clean aggregate
Type of Basecourse: Open Graded Asphalt with 9 % voids
Thickness of Basecourse required for Flood Control : 100, mm
Geofabric: A permeable geofabric (filter fabric) must be installed between the pavement and subgrade
Subgrade Type: n/a
Subgrade Permeability: 0,5 m/s
Design Subgrade CBR: 2 %
IMPORTANT NOTICE The PERMPAVE software package is only a tool to aid
design and for general guidance. The results given above are not a substitute
for engineering skill and judgement and in no way replace the services of
experienced and professionally qualified civil engineering consultants. Full
responsibility for the use of these results and this software package for any
project remains wholly with the user.
WARNING The PERMPAVE program only calculates the pavement thicknesses
needed for Flood Control, Water Quality or Water Harvesting. You have chosen an
application that may carry trucks or other heavy vehicles. Accordingly, you need
to verify that the thicknesses given by PERMPAVE are also adequate to carry Vehicle
Loads and Traffic. You should, therefore, run a structural analysis such as LOCKPAVE
for the conditions summarised above, to determine the thicknesses needed to resist
traffic and then adopt the greater of the thicknesses given by PERMPAVE or the
structural (LOCKPAVE) analysis.

S-ar putea să vă placă și