Documente Academic
Documente Profesional
Documente Cultură
18. Rubber seals which have been stored for more than four years should be checked for deterioration by stretching the
seal to
a) 10% of their internal dia and seeing for crack under XIO magnification
b) 20% of their internal dia and seeing for crack under XIO magnification
c) 10% of their external dia and seeing for crack under XIO magnification
d)20% of their external dia and seeing for crack under XIO magnification
19. Test flight of an Indian airlines a/c will be carried out
a) During C of A renewal
b) After top-overhaul
c) After block-overhaul
d) None
20. A private aircraft shall be flight tested
a) During C of A renewal
b) Subsequent to change of an engine
c) For the purpose of evaluation of an engine power
d) ATA
21. On a four-engine aircraft the test flight may not be carried out after change of
a) One engine provided satisfactory ground run has been carried out
b) Two engines provided satisfactory ground run has been carried out
c) Three engines provided satisfactory ground run has been carried out
d) Both (a) & (b)
22. Engine change means removal of an engine and its replacement by
a) An overhauled engine
b) Re-installation of the engine in the same position
c) Engine removed from any other position of the same aircraft or any other a/c
d) a & c
23. Test flight shall be conducted if practicable at
a) Maximum AUW b) Minimum AUW c) of maximum AUW d) maximum AUW
24. The routine test flight procedure will at least ensure
a) That the cruise speed at the cruising engine power is within the range specified
b) that the stalling speed has not increased beyond the figure specified by the manufacture/DGCA
c) All-engine-operating climb performance is within acceptance limits specified by the manufacturer/DGCA, while
effecting climb at the best climbing speed
d) ATA
25. The responsibility of recording the results of test flight lies entirely with
a) PIC
b) Co-pilot
c) Flight engineer
d) AME
26. The observed/actual climb performance is related to the test condition
a) Mean altitude
b) Mean temperature
c) Mean weight
d) ATA
27. After completion of test flight pilot has not observed any defect
a) The flight release shall be issued after NIL entry has been signed and dated by crew
b) The flight release can be issued after carrying out engineering maintenance
c) The AME can write NIL on behalf of pilot
d) The NIL report need not be signed
28. The expected climbed performance shall be obtained from
a) Flight manual
b) Form CA 56
c) Approved manufacturer test flight schedule
d) Test flight schedule approved by the DGCA
29. The observed actual climb performance (in terms of feet per minute) shall in no case be lower by more than
a) 2% of the expected climb performance b) 3% of the expected climb performance
c) 5% of the expected climb performance d) 7% of the expected climb performance
30. The test flight is not necessary for an engine change in an aircraft
a) Having 4 engines b) Having 2 engines
c) Having single engine
d) Only C above is wrong
31. The second section of propeller log book will contain
a) Hours flown date wise
b) Test flights
c) Overhaul records
d) Minor repairs
32. MTCS self extinguishing means
a) Material shall self-extinguish within a specified time after removal of flame
b) The material will not catch fire even if flame is continuously applied
c) Not susceptible to combustion to the point of propagating a flame after ignition source is removed
d)NOTA
33. Rule 58 of Aircraft rules 1937 requires that
a) All Indian registered aircraft should affix identification plate with nationality markings
b) Every aircraft shall be weighed and its CG determined
c) Deals with size and location of nationality and registration markings
d) ATA
54. MTCS
a) only original copies of documents shall be carried as per rule 7
b) Attested copies can be carried
c) Passenger safety information briefing card shall be kept at front and rear gallery d) None
55. MTCS
a) Each log book contain 5 sections
b) Routine inspection including flight release shall be certified in section 02 of log book
c) Modification records contained in 3rd section
d) None
56. The minimum requirements to be complied with by all the civil aviation operators is specified in rule no. _ of AR 1987
a) 134
b)140
c)141
d)57
57. Marginal deviations from approved specification not affecting the safety of aircraft may be approved by DGCA. This
Is called
a) Deferred defects
b) Alterations
c) Concessions
d) None
58. Normal category aircraft used for carrying passengers, goods or mails and having all up weight of 15000 Kg. or
above, Furnishing materials used in each compartment must be
a) Self extinguishing
b) Fire proof
c) Fire extinguishing
d) Flame resistant
59. an a/c having more than 500 passenger seats shall have
a) 5 medical kits and 1 FA box
b) 6 FA box and 01 medical kit
c) 3 medical kits and 1 FA box
d) None
60. An universal precaution kits for carriage on all aircraft that require ___ to be carried on Indian registered a/c
a) a cabin crew member
b) an air hostess
c) A MBBS doctor
d) None
61. Which is coming under empty weight of a/c
a) removable equipment
b) disposable load
c) fixed operating equipment
d) as in (c) trapped and unusable fuel
62. Limits of C.G are specified in
a) Certificate of air worthiness
b) Flight manual of an a/c
c) A or B
d) None
63. MTCS
a) Every a/c shall be weighed before the issue of certificate of airworthiness.
b) Aircraft weighing less than 2000 Kg need not be reweighed on routine basis
c) Aircraft weighing more than 2000 Kg shall be re-weighed every five years
d) ATA
64. Who all shall prepare wt schedule as per CAR
a) A person specifically approved by DGCA for the purpose in any organization
b) A person specifically approved by quality manager in an organization approved under CAR 145 provided procedure
for grant of such approval is documented in maintenance organization exposition
c) A category B licensed AME as reflected in term no. XIV(a) annexure to the CAR-66 license (privileges inherited
from the AME license held prior to CAR-66 license)
d) Any one of above as appropriate
65. MTCS
a) Aircraft Rule 7B requires every aircraft, registered in India, to carry on board Cockpit checklist and
Emergency check list
b) Guidance material on the application of human factors principles can be found in the Human factors training manual
(ICAO Doc. 9683)
c) Both a & b
d) None
66. Calibration of aircraft fuel qty gauge shall be done
a) Whenever fuel qty gauge is installed
b) During C of A renewal inspection
c) Nearest major check d) ATA
67. Hang glider need not be equipped with
a) Altimeter b) RPM gauge c) ASI d) ELT
68. A single seater powered hang glider shall be of AUW
a) 150 Kg
b) Less than 275 Kg
c) Less than 375 Kg
d) More than 375 Kg
69. Which section of log book specify information on total flight time since manufacture, time since last overhaul
a) Section 1 of a/c logbook
b) Section 2 of a/c logbook
c) Section 3 of logbook
d) None
70. The marking of break in points in an a/c shall be painted in
a) Red color
b) Yellow color
c) a or b
d) Purple
71. MTCS
a) The life of the lifed components are given in the quality cum maintenance system manual
b) The refueling and defueling procedure is given in the maintenance system manual
c) the list of navigational equipments to be carried on board the a/c is given in the operations manual
d) Both (a) & (c)
72. Mark the incorrect statement
a) Fabricated parts does not qualify for citification on form CA-1
b) Taxy permit is issued by the QCM of the organization
c) The validity of taxy permit is one year
d) None
73. Which weight of the following forms empty weight of a/c?
a) Removable equipment
b) Portable operating equipment
c)Engine coolant, hyd. Fluid, unusable fuel and oil
d) None
74. The calibration periodicity of weighing scales shall be specified in
a) Quality manual
b) Quality assurance manual
c) MOE
d) None
75. The radio equipment installed in Indian registered a/c shall be operated with a license issued under
a) Telegraph act 1988
b) Cat R
c) RTR (aero) d) Indian telegraph act 1885
76. Weight schedule of an a/c shall be retained for a duration of
a) Two years
b) Five years
c) Ten years
d) Till placed
77. MTCS
a) Mode S address is issued by ministry of Radio (WPC wing)
b) First 06 digits of mode S address indicates country code
c) Transponder certification/ inspection shall be done by type rated cat I/R AME
78. MTCS
a) The first page of JLB is approved by RAO b) First AID kit carried as per rule 57
c) Form 68c is to be used for renewal of AME license
79. Pressure test of group B hoses shall be carried out
a) twice the working pressure b) one and a half time the working pressure c) 2.5 times the max. pressure d) NOTA
80. The performance of the flight simulator is to be checked
a) As per qualification test guide/ approved test guide
b) The QTG / ATG is as per the JAR STD 1A and FAA AC-43-120-40BC
c) Both a & b
d) as per DGCA CAR
81. Hydraulic return line hoses comes under ____- group and the shelf life is
a) Group a and 10 years
b) Group b and 10 years
c) Group c and 10 years
d) None
82. A/C of MTOW up to 2000Kg, passenger standard weight for preparing of load sheet/ calculation of C.G
a) 85 Kg
b) Actual wt of the passenger c) 75 Kg excluding wt of hand bag
d) None
83. Which document need not be carried in an Indian registered a/c
a) ARC
b)attested copy of CRS
c)load & trim sheet
d)Troubleshooting chart
84. A/C log book & radio apparatus log book preservation period
a) one year after the A/C permanently withdrawn from use
b)two years of retirement of A/C
c)as long as a period the model of A/C in force
d) None
85. In no case ACAS shall be non serviceable for more than
a)7 days
b)10 days
c)the limit specified in MEL
d)one month
86. Mode S address is alotted by
a)WPC b)DGCA c)ATC d)AOTA
87. Requirement for ELT
a)All A/C operating over water beyond a distance of 50 NM from sea shore shall be equipped with at least two water
activated ELT
b) All A/C operating over water beyond a distance of 100 NM from sea shore shall be equipped with at least two water
activated ELT
c) it should meet the FAA specification TSOC-112
d)AOTA
88. For installing new radio equipment or replacing the existing one
a) Long term aeromobile license is issued b)short term aeromobile license is issued by ministry of communication
c)Short term aeromobile license is issued by DGCA
d)NOTA
89.An indication given to the flight crew recommending a maneuver intended to provide separation from all threats
a)SSR b)TA c)RA d)ACAS
90.MTOW of an A/C is to be referred from
a)C of A
b)Flight manual
c)Both (a) & (b) d)None
91.Limits of C of G of an A/C is specified in which document
a)C of A
b)Weight schedule
c)Flight manual
d)AOTA
92. For allotment of exit seat the age requirement as stipulated by DGCA is
a) Not less than 12 years b) Not less than 15 years c) Not less than 18 years d) NOTA
93. MTCS regarding flight simulator
a) Flight simulator is a requirement for all a/c with AUW exceeding 5700Kgs
b) Flight simulators are classified as Level A, B, C and D
c)The technical complexity of the simulator & the level of training imparted is least for level A and highest for level D
d)AOTA
94.Each compartment of Aerial work/pvt. A/C,the furnishing material used should be of
a)flame resistant
b)self extinguishing
c)composite material
95.A/C seats should be furnished with
a)Resistance to fire material b)Covering the seat cushions with a fire blocker
c)Comply standards of FAR 25 d)AOTA
96.Category II of civil a/c operation is when
a) RVR is not less than 550 M and DH is less than 60 M but not less than 30 M
b) RVR is not less than 300 M and DH is less than 30M but not less than 15 M
c) RVR is not less than 200 M and DH is less than 15 M
d) No RVR and no DH
97.In respect of each newly manufactured A/C /engine the log books are to be issued by
a)operator b)manufacturer
c)DGCA
98.Minimum radio equipments to be installed on A/C according to
a)CAR section 2 series I part II
b) CAR section 2 series R part III
c)Rule 57
d)AOTA
99.Transponder are to be operated in accordance with ICAO
a)Annex. 10 vol.IV
b) Annex. 10 vol.III
c) Annex. 6 vol.III
d) Annex. 10 vol.VI
100.An ACAS system which provides traffic advisories(TA) but does not provide resolution advisories (RAS) is
a)ACAS-I
b)ACAS-II
c)Both (a) & (b)
d)NOTA