Documente Academic
Documente Profesional
Documente Cultură
!
!
!
Advantages
!
!
!
Standards compliance
Conplast SP337 complies with BS5075 Part 3 and with
ASTM C-494 as Type A, Type F and Type G,
depending on dosage used.
Conplast SP337 complies with the requirements of the
United Kingdom Water Fittings Byelaws Scheme and is
listed in the Directory of Materials as suitable for use in
contact with potable water under its previous name of
Conplast SP337
Air entrainment:
Alkali content:
Description
Conplast SP337 is a chloride free high performance
water reducing admixture based on specially selected
and blended organic polymers. It is supplied as a
brown solution, which instantly disperses in water.
Brown liquid
Storage
Conplast SP337 has a minimum shelf life of 12 months
o
provided the temperature is kept within the range of 2 C to
o
50 C. Should the temperature of the product fall outside this
range then contact Fosroc Department for advice.
o
Freezing point - Approximately - 3 C
Precautions
Health and safety
Conplast SP337 does not fall into the hazard classifications
of current regulations (see notes 1 and 2 below). However, it
should not be swallowed or allowed to come into contact with
skin and eyes.
Dispensing
The correct quantity of Conplast SP337 should be measured
by means of a recommended dispenser. Normally, the
admixture should then be added to the concrete with the
mixing water to obtain the best results. Contact Fosroc for
advice regarding suitable equipment and is installation.
Effects of overdosing
An overdose of double the amount of Conplast SP337 will
result in an increase in retardation as compared to that
normally obtained at the intended dosage. Provided that
adequate curing is maintained, the ultimate strength of the
concrete will to be impaired by increased retardation and will
generally be increased. The effects of overdosing will be
further increased if sulphate resisting cement or cement
replacement materials are used.
Over dosage may also cause increased air entrainment,
which will tend to reduce strength. The degree of this effect
will depend on the particular mix design and overdose level.
Estimating - Packaging
Additional Information
Fosroc manufactures a wide range of products specifically
designed for the repair and refurbishment of damaged
reinforced concrete. This includes hand-placed and spray
grade mortars, fluid micro-concretes, chemical resistant
epoxy mortars and a comprehensive package of protective
coatings. In addition, a wide range of complementary
products is available. This includes a joint sealants,
waterproofing membranes, grouting, anchoring and
specialized flooring materials.
Jeddah Showroom
Dammam
Yanbu
Medinah
Head Office & Factory
Important note: Fosroc products are guaranteed against defective materials and manufacture and are sold subject to its standard terms and conditions of
sale, copies of which may be obtained on request. Whist Fosroc endeavors to insure that any advice, recommendation, specification or information it may give
is accurate and correct, it cannot, because it has no direct or continuous control over where how its products are applied, accept any liability either directly or
indirectly arising from the use of its products, whether or not in accordance with any advice, specification, recommendation or information given by it
SAU/CONPLAST SP337/07/01/A