Documente Academic
Documente Profesional
Documente Cultură
service@dalicworld.com
26.05.2008
Code: 10021, document code: FDS10021
1/5
service@dalicworld.com
26.05.2008
2/5
Diethanolamine
Average value (8h):
3
3 ppm (or 15 mg/m ,
INRS file ND 2098)
service@dalicworld.com
26.05.2008
3/5
PERSONAL PROTECTION
Provide a shower, a powerful tap and sink unit and an eye basin near the work place.
Respiratory protection: no in normal conditions of use as described in the technical data sheet (ambient
temperature, 10% dilution).
Hand protection: wear gloves (in latex or nitrile for example).
Eye protection: wear glasses with lateral protections. Do not wear contact lenses.
Skin protection: wear overalls and safety boots.
________________________________________________________________________________________________
9 - PHYSICAL AND CHEMICAL PROPERTIES
Appearance: pale yellow liquid.
Odour: odourless.
pH: 10.5.
Relative density: 1.04
Solubility: miscible in water.
Boiling point: approximately 100C.
Crystallisation / melting point: -3C.
Flammability: nil.
Oxidising properties: nil.
Other properties: not applicable.
________________________________________________________________________________________________
10 - STABILITY AND REACTIVITY
STABILITY
Good at ambient temperature with water evaporation for only risk.
Good in humidity. Slow oxidation and slight possible yellowing with air and light.
CONDITIONS TO AVOID
Incompatible components, heat (decomposition of some constituents from 230C).
MATERIALS TO AVOID
In particular, if accidentally the preparation is in a concentrated or dehydrated state:
Exothermic reaction with acids, powerful oxidizers,
Attack of copper, aluminium and their alloys,
Reaction with nitrozating agents (for example, nitrites, nitrogen oxides). Some nitrosamines can grow in particular
conditions. They proved to be carcinogenic in animal experimentation.
HAZARDOUS THERMAL DECOMPOSITION PRODUCTS
The combustion gives notably nitrogen oxides and carbon oxides.
________________________________________________________________________________________________
11 - TOXICOLOGICAL INFORMATION
No data are available regarding the preparation. The evaluation of health hazards has been realised thanks to
directives 67/548/EC, 1999/45/EC and bibliographical data.
SKIN
The risk of skin allergies is probably very weak but it can appear on some sensitive people.
EYE MUCOSA
Is not classified as irritating.
RESPIRATORY SYSTEM
The risk of respiratory allergies is probably very weak but it can appear on some sensitive people.
IN CASE OF INGESTION
Possible gastrointestinal troubles.
OCCUPATIONAL DISEASES: tables n49 and 49a (France, aliphatic amines, ethanolamines).
________________________________________________________________________________________________
12 - ECOLOGICAL INFORMATION
There are no ecological data on the preparation.
ECOTOXICITY
Bibliographic data concerning Diethanolamine:
FISHES - LC50 (96 h) = 250 - 301 mg/L, DAPHNIAS - EC50 (48 h) = 55 mg/L, ALGAE - LC50 (72 h) = 75 mg/L.
MOBILITY - PERSISTENCE AND DEGRADABILITY - BIOACCUMULATIVE POTENTIAL OTHER ADVERSE
EFFECTS
According to the available data, the involved raw materials are easily biodegradable and are not bioaccumulative.
With regard to the applicable EC directives, it is not appropriate to apply theN symbol DANGEROUS FOR THE
ENVIRONMENT to this preparation.
________________________________________________________________________________________________
service@dalicworld.com
26.05.2008
4/5
13 - DISPOSAL CONSIDERATIONS
This product, even if diluted at 10 %, must not be thrown away notably because of its alkaline pH. It must be processed
within the firm or destroyed by an approved organization.
Contaminated packaging if not re-used with the same product is also a special waste to be sent to an approved
organization for recycling or disposal.
Classification according to the commission directive 2000/532/EC of 3 May 2000 and its modifications (in particular
2001/118/EC, OJ L47). Use the mandatory documents to follow-up the waste products.
11 01 11*
15 01 10*
NOTE: in addition to the community provisions, it can be specific legislative and administrative, national or local
provisions on this topic.
________________________________________________________________________________________________
14 - TRANSPORT INFORMATION
A.D.R. (road transport), I.M.D.G. (sea transport), I.A.T.A. (air transport)
Not regulated.
________________________________________________________________________________________________
15 - REGULATORY INFORMATION
This safety data sheet has been established in accordance with the Corrigendum to Regulation (EC) n 1907/2006 of the
European Parliament and of the Council of December 18, 2006, OJ L136, 29.05.2007.
th
The preparation labelling has been established in compliance with the directive 67/548/EC (until the 29 adaptation:
directive 2004/73/EC of April 29, 2004) and the directive 1999/45/EC reviewed in last in January 23, 2006 by the
directive 2006/8/EC.
EC LABELLING: NO SPECIFIC RISK
Alkaline aqueous preparation.
Is not classified but contains at least one dangerous compound with a non regulated concentration (with regard to the
th
67/548/EC directive until the 29 modification)
A safety data sheet is available.
S26: in case of contact with eyes, rinse immediately with plenty of water and seek medical advice.
HEALTH SURVEILLANCE
Council Directive 98/24/EC of 7 April 1998 on the protection of the health and safety of workers from the risks related to
chemical agents at work
An appropriate health surveillance of workers must be carried out according to the risk.
For each worker who undergoes this health surveillance, individual health and exposure records are to be made and kept
up-to-date.
Other paragraphs in the French version of this safety data sheet summarize French rules regarding:
occupational diseases,
service@dalicworld.com
26.05.2008
5/5
OTHER INFORMATION
This sheet is provided to complement, not replace, the user instructions.
Information contained herein is bona fide and based on current knowledge relating to the product on the date of
publication. Furthermore, the attention of the user is drawn to the risks, which may be incurred when the product is used
for purposes other than those for which it is designed.
Information provided herein relates to this product only; it cannot take account of every situation, which may arise at
every work place. This safety data sheet therefore represents only a part of the information required for establishing a
safety programme.
Under no circumstances does this sheet dispense the user from the need to know and to apply all of the regulations
governing its activity, which are not all necessarily quoted herein in an exhaustive manner.
________________________________________________________________________________________________