Documente Academic
Documente Profesional
Documente Cultură
*Question 1
1:33:45
Mark: 4
A certain appliance uses 700 W. If it is allowed to run continuously for 36 days, how many
kilowatt-hours of energy does it consume?
Variable
KwH
Answer
Units
KwH
604.8
Correct to
1 decimal
Time Remaining:
*Question 2
1:32:44
Mark: 4
A.
Fixed biasing
B.
C.
D.
1)
cutoff
Time Remaining:
*Question 4
1:32:04
Mark: 4
Alpha particles enter an electromagnetic field where the electric intensity is 600 V/m and the
magnetic induction is 0.150 T. Find the velocity of the alpha particles.
Variable
Answer
4000
Units
Meters/sec
Correct to
0 decimal
Time Remaining:
*Question 5
1:31:30
Mark: 4
When the current through the coil of an electromagnet reverses, the direction of the magnetic
field also reverses.
True
False
Time Remaining:
Question 6
1:31:18
Mark: 4
Large cable sizes are formed as individual conductors that may be comprised of several smaller
strands to
A.
B.
C.
D.
Question 7
1:31:04
Mark: 4
A.
Electrons
B.
Neutrons
C.
Protons
D.
Holes
Time Remaining:
*Question 8
1:30:49
Mark: 4
Answer
Units
NA
Correct to
0 decimal
Time Remaining:
Question 9
1:30:39
Mark: 4
Which of the following is/are necessary precaution(s) for paralleling an AC Generator with live bus
bars?
I.
Generator frequency should be close to but slightly lower than bus bar frequency
II.
Generator voltage should be equal to bus bar voltage
III.
Current in generator circuit should be less than bus bar current
IV.
Generator voltage should be in phase with bus bar voltage
A.
B.
I, II and IV
C.
I, II and III
D.
II and IV only
Time Remaining:
*Question 10
1:30:24
Mark: 4
The opposition to the establishment of magnetic lines of force in a magnetic circuit is called the
circuit's
A.
resistance
B.
reluctance
C.
impedance
D.
inductance
Time Remaining:
Question 11
1:30:00
Mark: 4
Ripple factor of a full rectified wave form using two diodes from a sinusoidal wave will
be
A.
0.842
B.
0.482
C.
0.248
D.
0.428
Time Remaining:
Question 12
1:29:49
Mark: 4
While starting a main propulsion synchronousmotor, the ammeter pegs out at maximum and then
returnstothe proper value after synchronization.This indicates that the
A.
B.
C.
D.
*Question 13
1:29:35
Mark: 4
Which of the following are TRUE with regards to incorrect synchronization of Alternators?
A.
B.
C.
D.
Time
Remaining:
1:29:16
Mark: 4
F.
A.
as an RF
amplifier
B.
as stereo
amplifier
C.
in communication
sound equipment
D.
as distortion
generator
Time Remaining:
Question 15
1:28:53
Mark: 4
A.
B.
C.
D.
voltmeterinserieswiththe resistance.
Time Remaining:
*Question 16
1:28:37
Mark: 4
Open-loop transfer function of a system having one zero with positive real values is called
(1)________ phase function.
1)
NON MINIMUM
Time Remaining:
*Question 17
1:28:24
Mark: 4
Which of the listed precautions should be taken when cleaning the internals of a motor with
compressed air?
A.
B.
C.
D.
*Question 18
1:28:10
Mark: 4
A.
B.
C.
D.
E.
Question 19
1:27:41
Mark: 4
A.
B.
C.
D.
Second electromagnet.
Time Remaining:
*Question 20
1:27:25
Mark: 4
A.
B.
C.
D.
E.
Time Remaining:
Question 21
1:27:12
Mark: 4
A.
B.
C.
D.
*Question 22
1:26:59
Mark: 4
Alternating current circuits develop resistance, inductance and capacitance. The inductance of a
coil is expressed in
A.
ohms
B.
mhos
C.
henrys
D.
farads
Time Remaining:
*Question 23
1:26:48
Mark: 4
Two inductors of inductance 6H and 8H are connected in series. The mutual inductance between
them is 3H, which is aiding. Calculate the effective inductance.
Variable
Answer
20
Units
Henry
Correct to
0 decimal
Time Remaining:
Question 24
1:26:29
Mark: 4
A poly-phase motor driving an engine room pump fails to start. When trying to identify the cause
of failure, which of the following steps are applicable?
A.
B.
C.
D.
*Question 25
1:25:31
Mark: 4
A.
true power
B.
lead power
C.
induced power
D.
reactive power