Documente Academic
Documente Profesional
Documente Cultură
Which statement is true about any soft starters used in electrical motor
a. Soft starters are based on semiconductors
b. Used to control the stopping of motor
c. Use of soft starters initially result in lower motor torque
d. Soft starters progressively increase motor voltage which course torque or
current peak
Ripple factor of a full rectified wave form using two diodes from a sinusoidal wave
will be
A.
0.842
B.
0.482
C.
0.248
D.
0.428
Which of the following are true about a temp measuring ckt employed in in a data
logger system
1. A Wheatstone bridge can be used in conjunction with a Wheatstone bridge
induction thermometer
2. Thermometer is energized using a constant current source and voltage
developed is measured in potentiometer type method
3. Inductance of thermometer will change with change in temp
Barrier
56. In three phase electrical equipment, the immediate action in the event of fuse blowing in one of
the phases would be
a. to replace with a fuse of correct rating
b. to replace fuses on all three phases
c. to try to repair the fuse
d. to investigate the fault that led to blowing the fuse
11. The winding resistance of a coil can be increased by _______ the number of turns or using a
______ wire.
A. increasing, thicker
B. decreasing, thicker
C. increasing, thinner
D. decreasing, thinner
which of the following are benefits ofmodifyinf ward leonard control system by replacing the
motor set with a thyristor speed controller(mcq) A.enhanced speed regulation by making the
motor accelertion uniform B. increases efficiency of system especially lightly loaded C. educes
the overall cost of the system D. reduces system maintainance E. increases operating speed
range of system F. reduces overall space required