Documente Academic
Documente Profesional
Documente Cultură
In class we looked at deriving the rocket equation, which provides a relationship for
the change in velocity of a rocket to parameters such as the exhaust velocity and mass
fraction. The sketch below shows a rocket accelerating in a perfectly vertical orientation.
V(t) is the velocity of the rocket relative to
an inertial observer
M
x
Ve
Neglecting all forces acting on the rocket and Pe=Pa, the momentum equation in the ydirection can be written as shown below:
d
u y dV u y u n dS 0
dt V
S
Or, written explicitly employing a moving control surface (which is fixed to the rocket):
d
u y dV u y u u cs n dS 0
dt V
S
The volume integral (the first term in either case) is evaluated as:
d
d
dM
dV
u y dV M t V t
V M
dt V
dt
dt
dt
The key to these problems is to pay strict detail to the sign convention and deal with the
outward-normal on the control surface properly.
Below is the solution for the momentum flux term, which is the second term of the
Equations 1 and 2. Also, for simplicity, the integral of the area is Ae and the density is e,
both of which are constant.
Part 1: Solution using Equation 1
Using Equation 1:
u u n dS 0
y
S.1
e Ae u y u n 0
S.2
We have to be very careful in evaluating each of these terms, but remember that we are
interested in velocities and fluxes across a surface. The surface that we are interested in is
the exit plane of the rocket. This is the only place on the control volume where a velocity,
mass or momentum flux is crossing a surface.
Now look at each term:
The first one is uy, which is the velocity of the exit propellant in the inertial frame
(ground-based observer). The velocity of that exit propellant can be determined as
follows in an inertial frame.
o What is the velocity of the quantity that is crossing the control surface? It
is Ve, but it is negative based on our sign convention (it is in the negative
y direction).
o Next, what is the velocity of the control volume (or the control surface)?
Its velocity is V and it is positive since it is in the positive y-direction.
o The sum of these is the inertial velocity of the propellant that is crossing
the control surface: -Ve+V, or V-Ve. This is the velocity that an inertial
observer would measure for the exit propellant.
o Note: There is no dot product on this term, it is done.
The next term is u n , which is the velocity of the propellant crossing the
control surface in the relative frame. Also note that this is the dot product of two
vectors, which means that we need to pay careful attention to the direction of the
normal vectors to the control surface (which always point outward). We can
evaluate this term as follows:
o What is the velocity of the propellant? It is Ve, since it is in the negative
y-direction. The normal vector is drawn pointing outward and it is also in
the negative y-direction.
o The dot product of Ve in the direction of n is Ve.
e Ae u y u n e Ae V Ve Ve 1 0
S.3
Simplifying, we have:
eV m
eVe 0
e Ae u y u n e AeVVe e AeVe2 m
S.4
The momentum flux term in the y-direction (the only direction with a flux term) is:
eV m
eVe
e Ae u y u n m
S.5
cs
S.6
We have to be very careful in evaluating each of these terms, but remember that we are
interested in velocities and fluxes across a surface. The surface that we are interested in is
the exit plane of the rocket. This is the only place on the control volume where a velocity,
mass or momentum flux is crossing a surface.
Now look at each term (same as above, this term never changes between the two forms):
The first one is uy, which is the velocity of the exit propellant in the inertial frame
(ground-based observer). The velocity of that exit propellant can be determined as
follows in an inertial frame.
o What is the velocity of the quantity that is crossing the control surface? It
is Ve, but it is negative based on our sign convention (it is in the negative
y direction.
o Next, what is the velocity of the control volume (or the control surface)?
Its velocity is V and it is positive since it is in the positive y-direction.
o The sum of these is the inertial velocity of the propellant that is crossing
the control surface: -Ve+V, or V-Ve. This is the velocity that an inertial
observer would measure for the exit propellant.
o Note: There is no dot product on this term, it is done. Also notice that it is
identical to the operations performed in Part 1.
The next term is u u cs n . This entire quantity is the velocity of the propellant
crossing the control surface in the relative frame. Within this quantity the first u
is inertial and the second is the velocity of the control surface. Lets look at it piece
by piece:
o The first term, u , is the same as above. It is the velocity of the propellant
across the control surface as observed from an inertial frame, V-Ve
o The second term is the velocity of the control surface. The control surface
e Ae u y u u cs n e Ae V Ve V Ve V 1
S.7
Simplifying, we have:
e Ae u y u u cs n e Ae V Ve Ve 1 e AeVVe e AeVeVe
S.8
The momentum flux term in the y-direction (the only direction with a flux term) is:
eV m
eVe
e Ae u y u u cs n e AeVVe e AeVeVe m
S.9
Comparing Equations S.5 and S.9, we see that the result of using either form of the
momentum equation will result in the same answer.
Part 3: Application of this result to the development of the idea rocket equation
These momentum flux terms can be combined with the part that I gave you in Equation 3
to derive the rocket equation. Combining these results:
dM
dV
eV m
eV e 0
V M
m
dt
dt
S.10
m
dt
dt
S.11
eV M
m
dV
eV m
eVe 0
m
dt
S.12
S.13
dV
eVe
m
dt
Employing Equation S.11 and solving for the incremental velocity change dV:
dV
eVe
m
dM
dt Ve
M
M
S.14
We can now integrate Equation S.14, from initial to final conditions, and making the
assumption that Ve is constant.
Vf
Mf
Vi
Mi
dV Ve
S.15
dM
M
Integration gives:
Mf
Mi
V f Vi Ve ln
Mi
M
f
Ve ln
S.16
d
d
dM
dV
u y dV M t V t
V M
dt V
dt
dt
dt
dt V
dt
dt
dt
3.RC
This is because the rocket car is moving in the negative x-direction and hence its velocity
is in the negative x-direction. The structure of the terms is the same, the direction has
changed.
Now look at the momentum flux terms:
For the vertically launched rocket, we showed using Equation 1, that:
eV m
eVe
e Ae u y u n m
S.5
e Ae u x u n e Ae Ve V Ve 1 m eV m eVe
S.5 RC
It is almost the same as S.5, except the signs are flipped, because the sign convention was
flipped. We can do the same thing using Equation 2, and the result that was shown for the
vertically launched rocket, from Equation S.7 was:
e Ae u y u u cs n e Ae V Ve Ve 1 e AeVVe e AeVeVe
S.8
e Ae u x u u cs n e Ae Ve V Ve V V 1 e AeVVe e AeVeVe S.8 SR
Notice that just the signs switched, but notice that the sign of the momentum flux term
relative to the rocket or the rocket car didnt change. This again is because of convention.
Whenever there is an outward momentum flux it will yield a positive value.
If we proceed to combine these terms, we can derive the rocket equation for the car.
Combining terms we have:
dM
dV
eV m
eVe 0
V M
m
dt
dt
S.17
eV M
m
dV
eV m
eVe 0
m
dt
S.18
dV
eVe
m
dt
S.19
This is exactly the same result which was obtained in the vertical rocket case, shown in
S.13. That means that the same rocket equation will result when Equation S.19 is
integrated.
But wait! If the coordinate system has switched signs, shouldnt the resulting direction of
V change in the final result of the rocket equation?
The answer is no. This equation is predicting velocity in the direction you drew the
velocity vectors in. For example, in the rocket car, the velocity vector of the car was
drawn in the x-direction. The result for a positive Ve will be a positive V from the
equation, but you have to look at your velocity vector to determine which direction the
car is going, which is always in the opposite direction of Ve. The same is true of the
vertically launched rocket.