Documente Academic
Documente Profesional
Documente Cultură
com
RYERSON UNIVERSITY
MEC323
STATICS AND MECHANICS OF MATERIALS
Final Exam
July 2012
Notes:
Student Number:
Name:
1- Time- 3 hours
2- Answer all questions. All questions have the same value.
3- Appropriate free body diagrams are expected for all problems
4- Closed book examination
5- If you think there is missing or ambiguous information in this exam, make appropriate assumptions, state
them clearly, and then solve the problem on the basis of those assumptions.
6- All numerical answers must have appropriate units.
7- Write your answers legibly.
MECU
Page 1 of 7
www.ryemecu.com
.. ..
. .,. .__ 3m
3m
...
r"
MECU
3m
l
Page 2 of 7
www.ryemecu.com
Q2
?On1m
C
U
---235 mm - -...1"'"---1
MECU
Page 3 of 7
www.ryemecu.com
Q3
275 tnm
500mm C
500mm
300mm
MECU
Page 4 of 7
www.ryemecu.com
Q4
Obtained from Ryerson's Mechanical Engineering Course Union (MECU) www.ryemecu.com
a) Determine the internal resultants FG, VG' and MG on the cross section at G of the
horizontal frame member. The uniformly distributed load on member AC has a
magnitude ofw0 =220 lb/ft.
b) IfBD has a rectangular cross section measuring 0.50 in. X 2.00 in., what is the
axial stress in member BD.
c) The pin at Dis in fact a bolt as shown in Figure b. If the bolt is made of a kind of
steel with shear yield strength of 43 ksi and a factor of safety of 3 is required, what .
should be the diameter of the bolt. For this calculation you can assume the bolt to
be a smooth pin.
E
C
4tl
Fig. b
MECU
Page 5 of 7
www.ryemecu.com
5 in.
... ..
5 in.
...
Qs
Steel rods (A = 0.050 in 2, E = 30 X 103 ksi, a =
Obtained from Ryerson's Mechanical Engineering Course Union (MECU)
www.ryemecu.com
6.5 X 10- 6/F) are attached at points A and C to the ''rigid''
right-angle bracket in Fig..
The bracket is supported
by a stnooth pin at B, and the rods at A and C are initially
stress-free. (a) Determine the axial stresses induced in rods
(1) and (2) if the temperature of rod (1) is decreased by 50F.
{b) Determine the transverse shear force V n and bending
moment MD on the cross section at D that result from this
temperature change.
5
8 in. (1)
+-----
MECU
(2)
Page 6 of 7
8 in.--_,..
www.ryemecu.com
Iin.
Q6
E
C
MECU
Page 7 of 7
www.ryemecu.com