Documente Academic
Documente Profesional
Documente Cultură
CT1060AEN03GLA2
CT1060AEN03GLA2
CT1060AEN03GLA2
CT1060AEN03GLA2
CT1060AEN03GLA2
CT1060AEN03GLA2
CT1060AEN03GLA2
CT1060AEN03GLA2
CT1060AEN03GLA2
10
CT1060AEN03GLA2
11
CT1060AEN03GLA2
12
CT1060AEN03GLA2
13
CT1060AEN03GLA2
14
Instructions
Perform the steps below in the listed order until the BTS Fault
disappears.
1. Check the connection with adjacent BTS based on whether the X2
link is broken respectively.
2. Check if the adjacent BTS is operational. If this fault happens right
after a commissioning or a configuration change, verify the IP
address of the adjacent BTS
CT1060AEN03GLA2
15
CT1060AEN03GLA2
16
Perform the steps below in the listed order until the BTS fault
disappears.
1. Check the other active BTS faults and act accordingly.
2. Check the cables between the System Module and RF Module.
Note that dirty optical connectors may cause the signal level to
drop too low.
3. Depending on the fault source, reset the RF Module and/or System
Module by blocking/unblocking it.
4. Replace the alarming module's Small Form Factor Pluggable
(SFP). Check also the SFP in the other end and replace it, if
needed.
5. Replace the alarming RF Module.
6. If the System Module is the only alarming source or replacing the
RF Module does not clear the fault situation, replace the alarming
System Module.
CT1060AEN03GLA2
17
CT1060AEN03GLA2
18
CT1060AEN03GLA2
19
CT1060AEN03GLA2
20
CT1060AEN03GLA2
21
CT1060AEN03GLA2
22
Effect
In case of Subscriber trace activation, if the failed trace connection
was to be used for sending the Trace Reports, then the BTS considers
the trace activation for that subscriber as failed. In case of cell trace
and interface trace, if the failed trace connection was to be used for
sending the Trace Reports, then the BTS does not start tracing until
the trace connection is established successfully.
Instructions
Check the connection with iOMS/3rd Party tool.
CT1060AEN03GLA2
23
CT1060AEN03GLA2
24
CT1060AEN03GLA2
25
Radio Module (60W RRH)/the Filter (all others) has detected a VSWR
value exceeding the defined level. The antenna line is mismatched or
damaged.
1. Check the antenna cables, connectors, antenna and possible
antenna line devices.
2. Check the antenna line (TX-cable-antenna) impedance matching.
CT1060AEN03GLA2
26
CT1060AEN03GLA2
27
CT1060AEN03GLA2
28
CT1060AEN03GLA2
29
CT1060AEN03GLA2
30
CT1060AEN03GLA2
31
CT1060AEN03GLA2
32