Documente Academic
Documente Profesional
Documente Cultură
Model: AF-E9
8, Click the button RUN, and then the power source terminal +B
output 12v power, now the CUP starts to work.
Model: AF-E9
2, after waveform edition ends, in the end phase dialogue you need
to enter a crankshaft signal value after a working cycle of engine.
Note: this data is generated based on the crankshaft signal located
Phase value when it ends
2.
C. Finally, write waveform into AF-E9 by USB data cable.
AF-E9
AF-E9
AF-E9
AF-E9
AF-E9
AF-E9
AF-E9
AF-E9
meter, intake air pressure sensor, oxygen sensor and the connection
method to connect with ECU.
AF-E9