Documente Academic
Documente Profesional
Documente Cultură
CONSTRUCTION AIDS
PART 1 - GENERAL
1.01
RELATED DOCUMENTS
A.
1.02
1.
2.
DESCRIPTION OF WORK
A.
1.03
Furnish, install and maintain required construction aids; remove upon completion
of work.
PART 2 - PRODUCTS
2.01
MATERIALS
A.
2.02
2.03
Materials may be new or used, suitable for the intended purpose, but shall not
violate requirements of applicable codes and standards.
CONSTRUCTION AIDS
A.
B.
C.
TEMPORARY ENCLOSURES
A.
Provide temporary enclosures to separate work areas from the areas of existing
building occupied by Owner; to prevent penetration of dust, fumes, or moisture
into occupied areas, to prevent damage to existing equipment, to protect
01520-1
11/13
CONSTRUCTION AIDS
SECTION 01520
Owner's occupants and operations from construction work, and to prevent entry
of unauthorized persons. A two-hour fire rated construction barrier will be
required between the additions / renovated areas of each phase and the existing
occupied areas.
Doors in the construction barrier between the
additions / renovated areas are to be 90-minute rated.
B.
Provide temporary exterior and interior doors and frames with self-closing
hardware and padlocks. Doors shall be solid core wood or hollow metal, and
weather stripped.
C.
D.
Enclosures shall be 3 5/8, 20 gauge minimum metal stud frames with 5/8"
gypsum wallboard to meet two-hour rated construction. Frames shall extend
from floor to underside of metal deck and shall completely seal off all necessary
areas. On exterior enclosures, substitute 1/2" CDX plywood. Tape or otherwise
seal panel joints in gypsum board and plywood. Where exterior enclosures form
temporary means of egress, provide gypsum sheathing. Insulate exterior
enclosures with batt type insulation complying with the requirement of Section
07210, 2.01A.
E.
1.
2.
PART 3 - EXECUTION
3.01
PREPARATION
A.
Consult with Architect, review site conditions and factors which affect
construction procedures and construction aids, including adjacent properties and
public facilities which may be affected by the execution of the Work.
01520-2
11/13
CONSTRUCTION AIDS
3.02
GENERAL
A.
3.03
SECTION 01520
REMOVAL
A.
2.
B.
C.
D.
END OF SECTION
01520-3
11/13