Sunteți pe pagina 1din 8

Card Caddy Organizer Page 1 of 8

Card Caddy Organizer


By Shannon Hebert

http://northerngirlstamper-shannon.blogspot.com

Supplies:
 Tools, Dies, Templates
• Stampin Up Wide Punch
• 1” & 1 ¼ circle scallop punches
• Square Nestabilities
• Glue Dots
• Dimensionals
 Stamps
• Stampin Up – Delight in Life
 Card stock
• (3) 12 x 12 Black Card Stock will create 1 box
• (1) Vanilla Card Stock
 Printed Paper or Card Stock
• CTMH – 1 –er caddy
 Ink
• Stampin Up Basic Black
 Embellishments
• Heart Buttons
• Brads
• Ribbon

Tips
FOLD ALL SCORE LINES FRONT AND BACK. THIS HELPS IN THE
CONSTRUCTION OF CADDIES

Shannon Hebert – www.northerngirlstamper.blogspot.com


Card Caddy Organizer Page 2 of 8

Instructions:
1. Cut (1) from Black 9 ¾ X 12 for the back piece.
2. Starting on the short way score @ 6”.

5. To create the angles for the sides you will


measure down the long end edge with a ruler 1
½” and place a small dot for cutting
placement.

3. Turn and score @ 3 ¾ on both ends.

6. Do this on both edges.


7. Place on the cutter to cut the edges at an
angle.

4. You will now cut the slits at the bottom of the


scores (3 ¾ section lines).

Shannon Hebert – www.northerngirlstamper.blogspot.com


Card Caddy Organizer Page 3 of 8

8. Place the upper corner edge and the dotted


end on the cutter and cut the angle.
9. Do this for both top sides.

11. Adhere the two sides first and then the bottom
will be on the inside of the bottom back piece.
12. Set the back piece aside for now.
13. To create the front piece cut (1) from Black
Card Stock 8 ¼ x 12.
14. Score @ 3 ¾ on the 8 ¼ length.
15. Turn and score @ 3 ¾ on both ends on the 12”
length.

10. Now you will adhere the bottom to create


the back piece.

Shannon Hebert – www.northerngirlstamper.blogspot.com


Card Caddy Organizer Page 4 of 8

16. Cut out the two shorter bottom corner


squares.

18. Fold on score lines to create the front.


19. With the Wide Oval Stampin Up Punch, punch
17. Place each top end on the cutter and cut the top center of the center square. (I
at an angle top corner to bottom opposite measured 1” from both ends of score lines and
corner. placed a dot for placement of the punch
center).

Shannon Hebert – www.northerngirlstamper.blogspot.com


Card Caddy Organizer Page 5 of 8

22. Turn on the 4 ¾ length score @ 3/8, 7/8,


2 5/8, & 3 1/8.
23. Fold on all score lines and construct step.

20. Adhere the front panel to the bottom


back piece on the outside and the sides to the 24. For the permanent divider cut a piece
inside of the back piece. from Black Card Stock 5 ½ x 3 3/4 .
25. Score from both ends on the 5 ½ length
½” on each end.

26. Adhere the height step to the bottom of


21. To create the back height incert you will the divider.
cut a piece from Black Card stock 4 ¾ x 4 ¼.
Shannon Hebert – www.northerngirlstamper.blogspot.com
Card Caddy Organizer Page 6 of 8

The following measurements are for the


printed paper.

Cut from Vanilla Card Stock


(1)4 ¼ x 4 ¼ for front
(1) 4 ¼ x 5 ¾ for back
(2) 3 5/8 x 5 ¾ for sides. You will measure down
1 ½ inches on the ends again to get the
angle cut. (Remember when you are doing
prints you will need to cut one on the
opposite side)

27. Adhere to the inside of the Caddy being


sure that the height step is up against the back
panel. Adhere to the sides.

Cut from Printed Paper


(1) 4 1/8 x 4 1/8 for front
(1) 4 1/8 x 5 5/8 for back
(2) 3 ½ x 5 5/8 for sides. You will measure down
1 ½ inches on the ends again to get the
angle cut. (Remember when you are doing
prints you will need to cut one on the
opposite side).
28. Your caddy is now complete.

Shannon Hebert – www.northerngirlstamper.blogspot.com


Card Caddy Organizer Page 7 of 8

33. Print the categories.


34. With the 1” punch, you will punch out all
Base for Caddy the categories.
29. Cut (1) from Black Card Stock 9 ½ x 11 35. Adhere the Categories to the black
30. Score all 4 sides @ 7/8. scallop with a dimensional.
36. Adhere the category to the divider.

31. Cut slits (red lines) and adhere to sides to form


bottom base.

37. Adhere the button to the center with a


glue dot.

32. Cut (24) from Black Card Stock @ 4 7/16


x 5 ¼ for the dividers.

Shannon Hebert – www.northerngirlstamper.blogspot.com


Card Caddy Organizer Page 8 of 8

DECORATE AS YOU DESIRE ENJOY!!!!!

Shannon Hebert – www.northerngirlstamper.blogspot.com

S-ar putea să vă placă și