Documente Academic
Documente Profesional
Documente Cultură
Wireless
: Yes
Bluetooth setup
Link device list
My device info
Wireless
: Yes
Bluetooth setup
Link device list
My device info
Mode
Authentication : No
Check sum
5. Set Link.
Select a companion device from
among the Bluetooth devices
registered in the ES using {K}/
{L}.
CRegistering devices:
PROCEDURE Registering
Bluetooth companion devices
: Slave
: No
Mode
:Master
Link
DEVICE1
Authentication :Yes
Passkey
****
Check sum
:No
37
$
Set other parameters according to
the communication settings for the
device you are using.
ACK/NAK
CR,LF
ACK mode
:No
:No
:Standard
38
Wireless
: Yes
Bluetooth setup
Link device list
My device info
Device (Details)
Name:
DEVICE2
BD_ADDR:
0123456789AB
PREV
DEVICE1
deletion
Confirm?
No
NEXT
NO
YES
Device registration
Name:
DEVICE1
BD_ADDR:
0123456789AB
SEARCH
REG
Inquiry...
0123456789AB
123456789ABC
23456789ABCD
3456789ABCDE
STOP
OK
39
Wireless
: Yes
Bluetooth setup
Link device list
My device info
Bluetooth ID:
XXXXXXX, XXXXXXXX
Firmware: X.X.X
BD_ADDR:
ABCDEF012345
PROCEDURE
1. Complete the necessary settings
for Bluetooth communication.
C "10.1 Necessary settings for
Bluetooth communication"
40
]/
OBS
SD
ZA
HA-R
OBS
SD
ZA
HA-R
$
When "Mode" in "Bluetooth setup" is set to "Slave", the establishing of a
connection can only be initiated from the "Master" Bluetooth device.
When "Mode" in "Bluetooth setup" is set to "Master", ES will attempt to
establish a connection with the designated Bluetooth device (specified in "Link" in
"Bluetooth setup").
Softkeys (in OBS mode)
[
]:Press to enter waiting status ("Mode" is set to "Slave")/establish a
connection ("Mode" is set to "Master")
[
]:Press to cancel the connection/exit waiting status ("Mode" is set to
"Slave")/stop establishing or cancel a connection ("Mode" is set to
"Master")
Audio tones
(While connecting/disconnecting)
Start paging/waiting:
Connection successfully established:
Connection canceled/being canceled:
Paging failed/waiting time out:
short beep
long beep
two short beeps
two short beeps
41
42
Comms input
Waiting for
connection...
43
Comms output
Format
Sending
44
Comms output
Waiting for
connection...
SDR33
12
2.
Connect
the
ES
device using the cable.
CCables:
"36.2
accessories"
to
Select
Comms
mode.
Set communication conditions.
setup
C"33.1
Mode-"
the
external
Optional
Configuration
in
Config
-Config