Documente Academic
Documente Profesional
Documente Cultură
Component Terminology
1.
Metalwork : Metalwork refers to tensioner hooks or attachment fittings.
2. Attachment fittings : Metal fittings located at the base of the net that attach
the net to the pallet. Fittings are either Double Stud or Double Stud with Ring or
Single Stud types.
3. Double Stud Floor fitting : Industry standard component designed to interface
with pallet edge track. Fittings are permanently attached to the net.
4. Double Stud with Ring floor fitting : Double stud fitting with a welded steel
ring attached through the hole. Fittings are permanently attached to the net.
Tensioner Hooks
8. Border : Refers to the high strength cord running at the edge of each net
panel. Floor fittings are attached to this cord.
9. Border Cord
Joining method used to form an intersection within the net by intersecting two
separate cords
11.Lashing Line
Single cord used to close and tension each corner of
Separate item that can be used to temporarily bridge damaged parts of a net to
make it serviceable for limited use prior to repair. The strap can only be used
temporarily for certain types and levels of damage and has specific restrictions
and limitations.
Damage Terminology
Slight Abrasion
Breaking of a small amount of the outer most surface yarns. The visual
appearance of these protruding fibres gives a slightly fluffy appearance
Snagging
When one or more yarns or strands are pulled away from the cord structure
forming a loop.
PartiallySevered Cords
Cords that have severed strands within the braided construction. Will cause
strength loss.
It is recommended that the nets are periodically inspected and assessed for
serviceability before every use,.
It is often difficult for operators to track and monitor when nets enter service, thus
the recommended 3 year life of the net is set from the only authenticated datethe date of manufacturer that can be found within the serial number stated on the
identification label.
The Additional Information Label helps operators monitor the recommended 3
year service life by recording when the net was taken out of storage and first
entered service. This allows operators to store nets for a period of time without
affecting recommended service life.
CLEANING
The net assembly or components may be washed if required in clean water and
washed parts should be completely dry before return to use.