Documente Academic
Documente Profesional
Documente Cultură
RIP short for "Routing Information Protocol" is a routing protocol used to select the suitable route
for packets with in network. RIP basically an open standard dynamic routing protocol and not relate
to any particular vendor.
The latest version of RIP is RIP version 2 with some new features, for example RIP v2 is class less
protocol that sends subnet mask information with routing updates and support VLSM (variable
length subnet masking also).
From the global configuration mode, configure the hostname then configure the console and enable
passwords on each router.
To configure RIP v2, first enter global configuration mode to run the following commands.
First run the command show ip route to view the IP routing table for router A before RIP v2.
RouterA(config-router)#exit
RouterA(config)#
Configure the routing protocol on Router B.
First run the command show ip route to view the IP routing table for router B before RIP v2.
RouterB(config-router)#exit
RouterB(config)#
First run the command show ip route to view the IP routing table for router C before RIP v2.
RouterC(config-router)#exit
RouterC(config)#
From the enable mode, examine the routing table entries using the show ip route command on each
router.