Documente Academic
Documente Profesional
Documente Cultură
Features
This product is applicable to: the use of new two-way high-power thyristor can be very convenient to adjust
the mains current up to 25 A, and solve the the overcurrent problem of the heating wire resistance is too small
in the case of cooling causing good; the output voltage is adjusted anywhere between 90 ---- 220 volts for use
with electrical appliances. Such as: electric stove, water heater tune thermal, lighting dimmer, small motor
speed, electric iron thermostat. So as to achieve dimming, thermostats, pressure regulator effect.
2. The electrical parameters
PCB Board Size: 4.1cm * 5.3cm;
Voltage: AC 220V;
MAX Power: 2000W;
Voltage Regulation: AC50-220V;
Size: FR - 4 a-class circuit board;
3. The wiring diagram
4. Schematic diagram
5. Mechanical drawing
serial number
Component
Label
Footprint
Q1
resistor
R1
resistor
R2
C1,C2
DG7.62-2P socket
P1
500K potentiometer
R3
Potentiometer stents
BTA24-1200B
10
M3*6 screw
AXIAL-0.8
Value
100
Number
Note
Q2
TO-220
http://www.aliexpress.com/item/High-quality-2000W-Adjustable-Dimming-Dimmer50-220V-AC-25A-Voltage-Regulator-for-Lamps-speed-voltage/1697841628.html
http://electronics-diy.com/1000w-ac-motor-speed-controller.php
http://anycircuitfree.blogspot.com/2011/01/swing-machine-motor-speedcontroler.html
Triacsfire more symmetrically when used along with diac in AC power control
applications. The diac is a bidirectional trigger diode which does not conduct (except
for a small leakage current) until the break over voltage is reached. Its function is
designed specifically to trigger a triac or SCR.
In the beginning triac Ql is not conducting; C1 is charged through variable resistor
R3. This charge is coupled to Diac through R1, R3. When trigger level of the diac is
reached (about 36 V), D1 fires and Triac TR1 is switched on. R3 and C1 combination
sets the firing point of the triac from zero crossing along with Rl and R2. LI and C3
combination acts radio frequency filter for the radio interference caused by triac
firing.
Entire circuit operates on mains. Care must be exercised when mounting
components on normal Veroboard is risky. Remove alternate tracks and mount
components. Triac should be mounted on a small heat sink as the triac tends to get
hot particularly at lower speeds. All capacitors are polyester or polycarbonate rated
at 600V or more. Rl is a preset for minimum speed control. Adjust this according to
your requirement. R2 is the linear variable resistor like the volume control in the
radios. Use the one with plastic shaft. L1 is a radio interference choke. Take 28 gage
winding wire and make 10 turns on a 6 mm former. It can be wound on a round
capacitor for C3 and even one end can be soldered to it also.