Documente Academic
Documente Profesional
Documente Cultură
FAQ 006
Question
I want to use Simulink blocksets or MATLAB toolboxes in my real-time simulation. How can I find out
which blocksets and toolboxes are supported by the Real-Time Interface (RTI) and
ConfigurationDesk?
Relevant Products
Real-Time Interface (RTI) and ConfigurationDesk
Solution
Refer to the following pages:
General information on the compatibility to the blocksets and toolboxes from The MathWorks
is available at http://www.dspace.com/go/blocksets or http://www.dspace.com/go/toolboxes
(identical links)
If you are looking for information about Simulink blocksets or MATLAB toolboxes not listed
under http://www.dspace.com/go/blocksets, please check the Simulink Coder documentation
(formerly Real-Time Workshop documentation) of your active MATLAB Installation whether
the Simulink blocksets or MATLAB toolboxes are generally supported by the Simulink Coder
(formerly Real-Time Workshop):
o
Up to MATLAB R2008a: Real-Time Workshop > Getting Started > Introduction >
MathWorks Products Supported by the Real-Time Workshop Software
MATLAB R2008b MATLAB R2010b: Real-Time Workshop > Getting Started >
Getting Started with Real-Time Workshop Technology > How the Technology Can Fit
Into your Development Process > Tools for Algorithm Development
MATLAB R2011a: Simulink Coder > Getting Started > Product Overview > Related
Products
MATLAB R2011b: Simulink Coder > Users Guide > Model Architecture and Design >
Modeling > Supported Products and Block Usage > Related Products
Since MATLAB R2012b: Simulink Coder > Model Architecture and Design > Modeling
> Supported Products and Block Usage > Related Products
If the Simulink blocksets or MATLAB toolboxes are supported by the Simulink Coder (formerly
Real-Time Workshop) but no compatibility information can be found at
http://www.dspace.com/go/blocksets the compatibility with RTI or ConfigurationDesk cannot
be guaranteed.
For the listed blocksets and toolboxes from The MathWorks, which are listed at
http://www.dspace.com/go/blocksets, the compatibility with RTI and ConfigurationDesk is
tested with selected demo models taken from the MATLAB installation and/or with test models
designed especially for this purpose. These tests naturally cannot cover the complete
functionality range of the blocksets. Although most possibilities are taken into account, the
complexity resulting from the number of Simulink blocks and their possible parameterizations
is far too large to guarantee tests with 100% coverage.
Related FAQs
dSPACE recommends that you use the support request form on the Internet to contact
dSPACE Support.
It is available at:
http://www.dspace.com/go/supportrequest
Important Notice
This document contains proprietary information that is protected by copyright. All rights are
reserved. Neither the documentation nor software may be copied, photocopied, reproduced,
translated, or reduced to any electronic medium or machine-readable form, in whole or in part,
without the prior written consent of dSPACE GmbH.
Copyright 2013 by:
dSPACE GmbH
Rathenaustrae 26
33102 Paderborn
Germany
This publication and the contents hereof are subject to change without notice.
A list of registered dSPACE trademarks is available at:
http://www.dspace.com/go/Trademarks