Documente Academic
Documente Profesional
Documente Cultură
Classification of CA
Intra-band CA: Capable to aggregate 2 carriers within the same band class.
CA UE can use idle resource blocks (RBs) on two CCs to minimize the waste
of resources
Carrier management involves addition, activation, deactivation, and removal of an SCell for
a UE.
A2:
A4:
capable for CA, and eNodeB will activate the measurement for SCell frequency by default.
It utilizes the specific A4 and A2 event for PCell management. The event descriptions are
the same as handover, but the threshold could be separated.
When a UE sends an A4 measurement report that contains a cell whose RSRP exceeds the
related threshold for event A4 and that is in the same CA group as the PCell, the eNodeB
delivers an RRC Connection Reconfiguration message to the UE to configure the cell as an
SCell for the UE.
After the SCell is configured for a UE, the eNodeB can take the following carrier
When the traffic volume of the UE is low, the eNodeB can deactivate the SCell to
reduce UE power consumed by data transmission/reception and blind decoding, as
well as overhead for uplink channel state information (CSI) reporting.
When the traffic volume of the UE is high, the eNodeB can quickly activate the
SCell to increase the UE throughput.
After the SCell is configured for a UE, the eNodeB can take the following carrier
When the traffic volume of the UE is low, the eNodeB can deactivate the SCell to
reduce UE power consumed by data transmission/reception and blind decoding, as
well as overhead for uplink channel state information (CSI) reporting.
When the traffic volume of the UE is high, the eNodeB can quickly activate the
SCell to increase the UE throughput.
Connection Reconfiguration message to remove the SCell and then performs an intrafrequency handover for the UE.
If CA is enabled for the new PCell (that is, the target cell of the handover), the serving
eNodeB delivers an A4 measurement configuration to the UE after the RRC connection is
established. Later, if the UE sends A4 measurement reports that contain a cell (for example,
cell 1) in the same CA group as the new PCell, the eNodeB configures cell 1 as an Scell for
the UE.
During the inter-frequency handover, the target PCell might be the SCell in the same CA
group of the source eNodeB. As a result, it is likely that the UE is handed over from its
PCell to its SCell.
Be aware of that, two cells that are to be configured as a CA group are configured as a
neighboring cell of
each other.
Parameters description
Parameters
Description
CarrAggrA2
ThdRsrp
Indicates the Reference Signal Received Power (RSRP) threshold for reporting event
A2 in a secondary cell. When the RSRP of a UE is lower than this threshold, event A2
is reported.
CarrAggrA4
ThdRsrp
Indicates the Reference Signal Received Power (RSRP) threshold for a UE to report
event A4 in a secondary cell. When the RSRP of the UE is greater than the threshold,
event A4 is reported
CarrierMgtS
witch
Indicates the carrier management switch. If this switch is turned on, a secondary
component carrier (SCC) is activated and deactivated based on the traffic volume,
which reduces the UE power consumption when a carrier aggregation (CA) UE
performs no service or a few services. If this switch is turned off, the SCC is always
active after being configured, a CA UE can use the SCC immediately when the traffic
volume is large.
ActiveBufferL
enThd
DeactiveBuf
ferLenThd
ActiveBuffer
DelayThd
DeactiveThr
oughputThd