Documente Academic
Documente Profesional
Documente Cultură
ritten first.
2. Pipe identifier length issue fixed. Pipe identifier length exceeding 8 cha
racters was
truncated on import that resulted in more than one different pipes getting
the same ID.
3. Code year mapping for B31.1 is fixed. The code years for B31.1 which are n
ot available in
AutoPIPE have been mapped to next available code year and a warning is sho
wn to the user
about this particular change.
4. The analysis flag is off now for analysis sets by default. To analyze a gi
ven set, it
has to be enabled within AutoPIPE from Tools->Statis Analysis set dialog.
5. Specific gravity calculation error for pipe properties has been fixed.
1.0.0.9
Following Fixes/Changes were made.
1. Added stress summary translation as an *.xml file for ASME Class 1, 2 and
3 piping codes
2. Analyze flag for static analysis set to 'On' due to stress summary impleme
ntation
3. Added support for translating single response spectrum files (SRS)
4. Added map file for acquiring default properties for piping code and code y
ear
5. Merged double instruction valves without stem also to single valve
6. Fixed problem of bends following a reducer and reducer end pipe properties
not updating correctly
7. Added the option (SAM card) to run SAM case analysis after import
8. A new drop down list to select a version of AutoPIPE installed to open the
translated file
9. Multiple ADI files selection for translation in one go
10. Shortcut is created under a new program group Programs> Bentley AutoPIPE T
ranslators > ADLPipe Translator
1.0.0.10
Following Fixes/Changes were made.
1. Increased precision of coordinates in NTL to 5 decimals
1.0.0.11
Following Fixes/Changes were made.
1. Pressure units fixed for SI units (bar to N/mm2).
2. Alpha*DT factors fixed for SI units and metric units(conversion factor mm/
m added).
3. Yield (SY) was not exported for ASME Class 1 & 3 piping codes.
4. Hot modulus property for material has been fixed.
1.0.0.12
Following Fixes/Changes were made.
1. Unit files used by ADLTranslator that are shipped with AutoPIPE v9.4 are u
pdated with unit factor fixes: eng_adl.unt, met_adl.unt, si_adl.unt, simd_adl.un
t
9879 ADL Translator: Some unit factors not set correctly when importing to
AutoPIPE (see tracker for more details)
1.0.0.13
No changes
1.0.0.14
Following Fixes/Changes were made.
1. Rename nodes in ADLPipe with names lying in the reserved range 9000-9999 o
f node numbers.
1.0.0.15
Build version update