Documente Academic
Documente Profesional
Documente Cultură
SECTION 1.
TURCO 5351
Product Name:
Proper Shipping Name: TOXIC LIQUID, CORROSIVE, ORGANIC, N.O.S. (CONTAINS 54% w/w
DICHLOROMETHANE AND 17% w/w PHENOL)
Product Code(s):
Use:
Supplier:
SECTION 2.
HAZARDS IDENTIFICATION
DATE OF ISSUE:
Page 1 of 5
24.02.09
REVISION OF:
28.04.06
PRODUCT NAME:
SECTION 3.
COMPOSITION/INFORMATION ON INGREDIENTS
INGREDIENTS:
CHEMICAL ENTITY
CAS NO.
Dichloromethane
[75-09-2]
Phenol
[108-95-2]
Sodium dichromate,anh.
[10588-01-9]
Petroleum sulphonate
Other ingredients determined not to be hazardous
SECTION 4.
PROPORTION
54% w/w
17% w/w
<1% w/w
low, less than 5% w/w
to 100% w/w
Ingestion:
Skin:
If skin contact occurs, immediately remove any contaminated clothing and wash
affected areas with soap and water, then methylated spirit or polyethylene glycol
300 or 400 if available. Seek medical attention or contact a Poisons Information
Centre (Phone 13 11 26).
Eyes:
Hold eyelids apart and flush the eye with running water for at least 15 minutes.
Seek medical attention or contact a Poisons Information Centre
(Phone 13 11 26).
Inhalation:
Advice to doctor: Treat symptomatically. Symptoms of lung oedema may not become apparent
until several hours after exposure1.
First Aid facilities: Eye wash and safety shower
SECTION 5.
Suitable extinguishing media: Water fog, foam, carbon dioxide, dry chemical.
Hazards from combustion products: Under fire conditions, it will produce highly toxic fumes of
phosgene and acrid smoke.
Precautions for fire fighters and special protective equipment: If product is involved in a fire, then
fire fighters must be warned of hazardous nature of material. No flash point in conventional closed
tester, but will form explosive air mixtures in an oxygen enriched atmosphere or if exposed to strong
heat or flame. Wear full protective clothing and self-contained breathing apparatus.
Hazchem Code: 2XE
SECTION 6.
Wear impervious gloves, chemical goggles and waterproof boots. Contain and collect spillage with
absorbent materials (e.g. sand, earth, vermiculite). Transfer to sealable containers suitable for storing
spilled material. Flush areas in contact with spilled material with adequate water to render the area
DATE OF ISSUE:
Page 2 of 5
24.02.09
REVISION OF:
28.04.06
PRODUCT NAME:
Engineering controls:
Personal protective equipment: Use good industrial hygiene. Avoid contact with skin and eyes.
Wear suitable protective clothing, safety footwear, silver shield/4H gloves and chemical splash
goggles or full face shield. Use in a well ventilated area. If inhalation risk exists, wear an organic
vapour respirator or air supplied mask complying with the requirements of AS 1715 and AS 1716.
SECTION 9.
Physical data:
Appearance:
Specific gravity
Odour:
Solubility:
Boiling point:
SECTION 10.
TOXICOLOGICAL INFORMATION
HEALTH EFFECTS:
Acute:
Ingestion:
DATE OF ISSUE:
Page 3 of 5
Toxic if swallowed. This product can cause serious burns to the mouth, throat
and digestive tract. Systemic effects by ingestion may include nausea,
vomiting, stomach pain, blood disorders, convulsions, a change in cardiac rate,
coma and damage to the liver, kidneys and pancreas.
24.02.09
REVISION OF:
28.04.06
PRODUCT NAME:
Toxic and corrosive to skin. Absorption of this product through the skin may
cause serious effects to the central nervous system, liver, kidneys and spleen.
May cause sensitisation by skin contact.
Eyes:
Liquid contact with the eyes can cause severe burns which may result in
permanent injury or even blindness.
Inhalation:
Inhalation of vapour or mist may cause respiratory irritation and burns to the
mucous membranes. Exposure to high concentrations of vapour may cause
irregular heartbeat, headache, lung congestion and narcosis. May cause
respiratory sensitisation.
Chronic:
This material can cause corrosive damage to skin tissue. Long term inhalation
exposure may lead to blood disorders, kidney and liver damage, chest pain and
harmful effects on the central nervous system. Dichloromethane is regarded as
a Category 3 Carcinogen. This product contains less than one percent sodium
dichromate, which is classified as a Category 2 Carcinogen, Category 2
Mutagen and is Toxic to reproduction (Category 2)
:
:
:
ECOLOGICAL INFORMATION
Do not contaminate waterways and soil. This product will cause harmful effects to aquatic life.
Dichloromethane is not readily biodegradable.
Fish toxicity:
DISPOSAL CONSIDERATIONS
Dispose of residues in chemical waste disposal area in accordance with relevant State and Federal
requirements. Empty containers should be left open to allow residual solvents to evaporate and then
triple rinsed with fresh water prior to disposal to drum reconditioner or approved landfill site.
SECTION 14.
TRANSPORT INFORMATION
UN Number:
Proper Shipping Name:
Class:
Subsidiary Risk:
Packing Group:
Hazchem code:
Emergency Information:
SECTION 15.
2927
TOXIC LIQUID, CORROSIVE, ORGANIC, N.O.S. (CONTAINS 54% w/w
DICHLOROMETHANE AND 17% w/w PHENOL)
6.1, Toxic
8, Corrosive
II
2XE
Dangerous Goods-Initial Emergency Response Guide (SAA/SNZ HB 76),
Guide 36 or EPG 6J4.
REGULATORY INFORMATION
DATE OF ISSUE:
Page 4 of 5
24.02.09
REVISION OF:
28.04.06
PRODUCT NAME:
SECTION 16.
OTHER INFORMATION
Abbreviations/acronyms:
ASCC - Australian Safety and Compensation Council
SUSDP - Standard for the Uniform Scheduling of Drugs and Poisons
TWA - Time-weighted average
References:
1. NIOSH, International Chemical Safety Cards, Phenol, October 2001
2. NICNAS Alert No.3. Caution required for Methylene Chloride in Paint Stripping, Existing
Chemicals, July 2004
3. Quick Selection Guide to Chemical Protective Clothing, Fifth Edition, 2007: Forsberg and
Mansdorf, Wiley-Interscience3.
4. Sax and Lewis, Dangerous Properties of Industrial Materials, 7th Edition (1989).
5. Ecological data: Merck MSDS for Dichloromethane, Aug. 2001
6. Ecological data: Merck MSDS for Phenol, Jan. 2003
DISCLAIMER:
The percentage weight (% w/w) of ingredients is not to be taken as a specification guaranteed by
Henkel Australia Pty. Limited, but only as an approximate guide to the content of hazardous
ingredients in the material. The information contained herein does not constitute a guarantee by
Henkel Australia Pty. Limited concerning the properties of the material.
The information contained in this Material Safety Data Sheet is offered in good faith and has been
developed from what is believed to be accurate and reliable sources. The information is offered
without warranty, representation, inducement or licence and Henkel Australia Pty. Limited assumes
no legal responsibility for reliance upon same. Henkel Australia Pty. Limited disclaims any liability for
loss, injury or damage incurred in connection with the use of the material or its associated Material
Safety Data Sheet.
This information is not to be construed as a representation that the material is suitable for any
particular purpose or use except those conditions and warranties implied by either Commonwealth or
State statutes. Customers are encouraged to make their own enquiries as to the material's
characteristics and, where appropriate, to conduct their own tests in the specific context of the
material's intended use.
DATE OF ISSUE:
Page 5 of 5
24.02.09
REVISION OF:
28.04.06
PRODUCT NAME: