Documente Academic
Documente Profesional
Documente Cultură
inspection (MPI)
Magnetic Flow/Coil Test Piece
test ring
mtu block
central conductors
berthold penetrameter
polyspray
powder dispenser
contact block
magnaglo applicator
contact pads
Our contact pads and plates prevent arc burn by maintaining proper electrical contact between test parts and contact heads.
Available in a variety of sizes, they are manufactured to fit most MPI units see table below.
Part number
031C003
Model
MAG 50
Area (mm)
145 x 125
Material
Copper braid, neoprene
Copper braid
031C010
MAG II/20
45 x 65
031C012
MAG II/20F
60 x 65
Brass mesh
031C014
MAG III
96 x 125
Copper braid
031C016
MAG 40 series
100 x 120
Brass mesh
031C020
MAG 50 series
145 x 125
Copper braid
NOTE: Quick Break is installed on all Magnaflux units with 3 phase - full-wave DC output (coil
circuits).
connectors
Connectors for attaching 4/0 cables to Magnaflux magnetising equipment, including wet benches,
power packs, and mobile units.
Part number 1238: 4/0 Either end connector. Allows quick cable disconnect for maximum flexibility
Part number 1238A: Connector Boot only
Part number 1574: Either end Lug Adaptor, changes lug terminals to either end terminals
Part number 1576: Either end Lug Adaptor, 90. Same as above but for easier cable placement.
Part number 2590: 4/0 Lug for permanent attachment to magnetising equipment.