Documente Academic
Documente Profesional
Documente Cultură
Purpose:
This is a simple document to help on the antennas alignment with XPIC XPD, here is the steps
for a simple and quick way, as well alerting for the most common problem.
Alignement
1. Mechanical optimization
1. Make sure the function Automatic Transmitter Power Control (ATPC) is turned
off during alignment.
2. Adjust the antenna for maximum alignment value.
3. Tighten the locking screw when maximum value is achieved.
4. Repeat steps 2 to 3 until the maximum alignment value is achieved.
5. Measure the alignment level and record the value.
6. Verify if the RX level is according to the Call Off.
Make sure all screws are tightened when the alignment procedure is finished.
Kamalrul Ariffin
Kamalrul Ariffin
Polarization adjustment
1. Slightly loosen 2pcs of polarization screws.
2. Adjust polarization by turning radio interface (OMT) 5.
3. Tighten 2pcs of polarization screws with 24Nm 5% (17Nm if A2-70).
Polarization screws, 2pcs
Polarization -5
Polarization +5
Kamalrul Ariffin
Kamalrul Ariffin
Polarization -5
Kamalrul Ariffin
Polarization +5
Kamalrul Ariffin
Kamalrul Ariffin
Polarization: Horizontal
Polarization: Horizontal On
Nominal point between Horizontal and Vertical is 33.0 / 33.9dB before XPD Alignment.
Kamalrul Ariffin
Polarization: Horizontal On
New nominal point between Horizontal and Vertical is 27.0 / 27.9dB after XPD Alignment.
~ END MOP ~