Documente Academic
Documente Profesional
Documente Cultură
constructive solutions
Typical Properties
Specific Gravity:
Alkali Content:
Sulphate Content:
Air Entrainment:
Chloride Content:
Constituents:
Fibre Thickness:
Min.
Specific
Surface Area
Storage Life:
Advantages
Youngs Modulus:
Tensile Strength:
Melting Point:
0.91 g/cm3
Nil
Nil
Air content of concrete will not
be significantly increased
Nil
Virgin Polypropylene C3H6
18 micron
220 M2 / KG
Minimum 12 months from date
of manufacture.
5500-7000 MPA
350 MPA
160 C
Specification
Concrete shall be manufactured using crack controlling
additives such as Fosfiber P1. The crack controlling
additive shall be based on a polypropylene fibre with an
individual fibre thickness of 18 micron.
Dispensing
Fosfiber P1 is supplied ready for use, and in measured
quantities for addition to the concrete mix whether at the
batching plant or on site.
Effects of Overdosing
Page 1
Fosfiber P1
Addition Dispensing Rates
The performance of Fosfiber P1 is best assessed after
preliminary trials in the laboratory, or on site using the actual
mix constituents under consideration to determine the effect
on concrete properties.
As a guide to trials, the following dosage levels of Fosfiber
P1 are recommended.
Product
Fibre Length
Aggregate Size, max
Dosage
Typical areas of
application
10 mm
6 mm
32mm
3
0.6/0.91 kg/ m
Ready mix concrete,
mortars, grouts, screeds
Technical support
Fosroc offers a comprehensive range of high performance,
high quality products suitable for use within all aspects of
the concrete repair and protection industry. In addition, the
company offers a technical support package to specifiers,
end users and contractors, as well as on-site assistance.
Supply
Fosfiber P1 10 mm is available in 0.6 kg and 0.91 kg bags.
All bags are supplied in cardboard box containers.
Storage
Should be stored in dry conditions, similar to cement.
Additional Information
Fosroc manufactures a wide range of products specifically
designed for the repair and refurbishment of damaged
reinforced concrete. This includes hand-placed and spray
grade mortars, fluid micro-concretes, chemical resistant
epoxy mortars and a comprehensive package of protective
coatings. In addition, a wide range of complementary
products is available.
This includes joint sealants,
waterproofing membranes, grouting, anchoring and
specialised flooring materials.
Important note:
Fosroc products are guaranteed against defective materials and manufacture and are sold subject to its standard Conditions
for the Supply of Goods and Services, copies of which may be obtained on request. Whilst Fosroc endeavours to ensure that
any advice, recommendation, specification of information it may give is accurate and correct, it cannot, because it has no direct
or continuous control over where or how its products are applied, accept any liability either directly or indirectly arising from the
use of its products, whether or not in accordance with any advice, specification, recommendation of information given by it.
www.fosroc.com
email: fosam@fosroc.com
Regional Offices
Jeddah Sales Office
Jeddah Showroom
Riyadh
Dammam
Khamis Mushayt
Registered Office: Industrial Area, Phase 4, Road No. 414, Street No. 407
Page 2
FO SA/Fiber P1/04/A