Sunteți pe pagina 1din 84

Chapter 1

INTRODUCTION
1.1 GENERAL INTRODUCTION
Beams with large depths in relation to spans are called deep beams. As per
Clause 29 of IS456: 2000 [1], a simply supported beam is classified as deep when the
ratio of its effective span L to overall depth D is less than 2. Continuous beams are
considered as deep when the ratio L/D is less than 2.5. The effective span is defined
as the centre-to-centre distance between the supports or 1.15 times the clear span
whichever is less. According to ACI-318:2008 [2] the deep beam is defined as the
ratio of effective span to depth is less than or equal to four. RC deep beams have
many useful applications in building structures such as transfer girders, wall footings,
foundation pile caps, floor diaphragms, and shear walls. Particularly, the use of deep
beams at the lower levels in tall buildings for both residential and commercial
purposes has increased rapidly because of their convenience and economic efficiency.
Deep beams have depth comparable to its span so the volume of the beam is very high
as compared to the floor beams. ACI 318 [2] provides design method for deep beams.
Strut and tie model is commonly used for the design of deep beams.
Strut is compression member and tie is tension member assumed inside the
deep beam. Design of these member in such a way that compressive force in the strut
never exceeds the permissible compressive force in concrete and tensile force never
exceed the permissible tensile force in reinforcement. Selection of strut and tie model
for deep beams need knowledge about the compression region and tension region
inside it. Concept of strut and tie model was obtained from the steel design concept.
For example jib of crane and large truss work for roofs. Here the truss member in
compression and tension region designs separately. In the deep beam tension zone and
compression zone is designed using strut and tie model. The Strut-and-Tie model
(STM) approach evolves as one of the most useful design methods for shear critical
structures. Strut-and-tie modelling (STM) is an approach used to design discontinuity
regions (D-regions) in reinforced and pre-stressed concrete structures. A STM reduces

complex states of stress within a D-region of a reinforced or pre-stressed concrete


member into a truss comprised of simple, uniaxial stress paths. Each uniaxial stress
path is considered a member of the STM. Members of the STM subjected to tensile
stresses are called ties and represent the location where reinforcement should be
placed. STM members subjected to compression are called struts. The intersection
points of struts and ties are called nodes. Knowing the forces acting on the boundaries
of the STM, the forces in each of the truss members can be determined using basic
truss theory. With the forces in each strut and tie determined from basic statics, the
resulting stresses within the elements themselves must be compared with specification
permissible values. Since a STM is comprised of elements in uniaxial tension or
compression, appropriate reinforcement must be provided. Through the use of this
approach, an estimation of strength of a structural element can be made and the
element appropriately detailed. Unlike the sectional methods of design, the strut-and
tie method does not lend itself to a cook book approach and therefore requires the
application of engineering judgment.
Forces in the strut and tie are determined by equilibrium equation. This
procedure becomes cumbersome when the STM is complex. It will occur in the beam
column joint, continuous deep beam etc. Computer Aided Strut and Tie (CAST) is the
software used for finding the forces in member. It is only an existing windows-based
application for STM with rich of graphical user interfaces. CAST has been developed
by the University of Illinois since 2001.It was used to serve students and practicing
engineers to grasp the concept and to try various idealized strut-and-tie models with
ease. CAST components comprise of nodes and elements. Elements represent struts or
ties meeting at nodes. For particular cases, stabilizer is necessary to make the model
numerically stable. The stabilizer is a strut with zero force. Three types of boundary
conditions can be applied at exterior nodes: plate, point loads, and supports. Body
force and support can also be applied to interior nodes within D-region. The model
must be restrained to prevent rigid body movement. In CAST, positive value of forces
is point outward from node and vice versa. Since the direction of point loads on the
boundary will follow the axis of the strut, no element connectivity is allowed on
boundary.
2

Deep beam designed by strut and tie is heavy beam. Literature review shows
that its volume can be decreased without affecting its performance. The process of
arranging the material inside a body for resisting external load is called optimisation.
Extensive research has been undertaken in the field of topology optimization,
particularly in the past few decades. Largely due to the critical importance on weight
savings in aerospace structures, the topology optimization methods have been
developed primarily for applications in elastic isotropic and composite laminate
material. On the contrary, weight saving is not such a critical factor in civil
engineering design problems, and perhaps because of this, topology optimization for
these applications have been studied with less enthusiasm.
Most of structural optimization methods for RC are based on cost optimization
where the cost is assumed to be directly proportional to the amount of material. Thus
the objective function is equivalent to that of the fully stressed design, which is to
minimize the structures volume or mass. Gradient-based methods such as Lagrangian
methods have been applied to sizing problems of reinforcement in a concrete beam.
Optimization of shape of concrete sections as well as sizing of reinforcement has been
formulated as a non-linear mathematical programming problem and solved for
optimal concrete section geometry, reinforcement amount and locations and for
location of the neutral axis. These methods however, do not alter the arrangements of
struts nor ties and hence offer a limited design improvement.
Structural optimization is one application of optimization. Here the purpose is
to find the optimal material distribution according to some given demands of a
structure. Some common functions to minimize are the mass, displacement or the
compliance (strain energy). This problem is most often subject to some constraints,
for example constraints on the mass or on the size of the component. The problem of
structural optimization can, be separated in three different areas: sizing optimization,
shape optimization and topology optimization
Sizing optimization is the simplest form of structural optimization. The shape
of the structure is known and the objective is to optimize the structure by adjusting

sizes of the components. Here the design variables are the sizes of the structural
elements. Topology optimization is a mathematical approach that optimizes material
layout within a given design space, for a given set of loads and boundary conditions
such that the resulting layout meets a prescribed set of performance targets. Using
topology optimization, engineers can find the best concept design that meets the
design requirements.
Shape optimization is part of the field of optimal control theory. The typical
problem is to find the shape which is optimal in that it minimizes a certain cost
functional while satisfying given constraints. In many cases, the functional being
solved depends on the solution of a given partial differential equation defined on the
variable domain.
Topology optimization is a mathematical approach that optimizes material
layout within a given design space, for a given set of loads and boundary conditions
such that the resulting layout meets a prescribed set of performance targets. Using
topology optimization, engineers can find the best concept design that meets the
design requirements. TOP OPT, SOLID THINKING, OPTISTRUT, TOSCA,
GENESIS, ANSYS etc. are software that used for topology optimisation. Topology
optimisation with the help of ANSYS is used for optimisation of deep beam for this
project. ANSYS is complex software that gives all the necessary details for this
project. ANSYS is simulation software developed by United States. Fluid mechanics,
heat transfer, structural, electromagnetic are the some field of ANSYS. Structural
design of modern vehicle part is carried out in ANSYS. In the field of civil
engineering ANSYS analysis is very difficult. ANSYS analysis is based on finite
element method. The accuracy of the entire project is depends on the size of the
element. Finer mesh analysis is more accurate and vice versa. Finer mesh analysis of
large building very complex and need super computers. These disadvantages make the
low popularity of software in civil engineering.
Deep beam with span 7m is modelled and optimised in ANSYS. Design of
deep beam was done based on ACI: 318 2008 and IS 456: 2000. Both the design
yield approximate same result. ANSYS 12.1 with civil FEM is used for this project.
4

ANSYS can per form 100 number of iteration for optimisation. Solution stops only
when results converge. Optimisation is possible only with element modelled using
solid 95 elements. This is unable to crack or crush. In order to obtain crack pattern
and deflection beam models repeated using solid 65 elements. Result of optimisation
shows new beam without decreasing performance. In this project volume is optimised
50% without loss of strength. For validation of the project an experimental study is
conducted. Due to the unavailability of modern laboratory equipment, models of deep
beam and optimised beam were tested in the laboratory. Optimised beam and deep
beam modelled in ANSYS using SOLID 65 element for determining deflection and
crack pattern. Deflection, cracking and ultimate load bearing capacity was checked
and compared with experimental results. Universal testing machine (UTM) with
maximum load capacity of 600kN was used for loading purpose. Dial gauge is used to
find deflection at mid span.
1.2 SOFTWARE USED FOR PROJECT
Analysis and optimisation of the project is carried out in Computer Aided
Strut and Tie and ANSYS respectively. Computer Aided Strut and Tie (CAST) used
for creating strut and tie model for a deep beam. On analysing the model we obtain
the compressive force in strut and tensile force in tie. Much software that is available
for topology optimisation is explained in above paragraph. Selection of software
depends on the nature of the problem. Topology optimisation is very common in
mechanical engineering field for the optimisation of vehicle parts. In civil engineering
reinforced concrete is a composite material. It can be modelled using ANSYS.
Topology optimisation of composite material can be done in ANSYS. ANSYS
analysis spread over the field of fluid mechanics, structural design, electromagnetic
problem, heat transfer problem etc. Here ANSYS software is used for optimisation of
deep beam. Degree of freedom in three directions, stress intensity, von Mises stress
field, crack pattern, stress in steel, topology optimisation density plot etc. can be
obtained from ANSYS.

1.3 ORGANISATION OF THESIS


Chapter 1 gives introduction to this project with previous study made in this
category. All the ideas about the topics and software are used in this project depicted
in introduction. Details of software used at various at portion of project are also
described. Details of experimental programme such as type of experiment,
instruments used are discussed in this section.
Chapter 2 deals with all the past study details on this topic. All the researchs
in this topic from last 20 years included in literature reviews. Each and every paper
was studied well and all the core details such as purpose of study and method of study
was consolidated and explained in these section. Literature review was then
concluded with importance of present study. This section contains main objective of
the project. Methodology of this project is provided in last section of this topic for
explain the details of project work.
Chapter 3 is core of this paper that is topology optimisation theory and
procedure. Different type of optimisation, definition, importance of each types,
mathematical explanation, why topology optimisation, different software available for
topology optimisation, why ANSYS etc. are explained in this section. Topology
optimisation by ANSYS software is done in this chapter.
Chapter 4 gives idea about conventional design of deep beam with ACI 318
2008 code. Design based on IS 456 2000 was done in this chapter. A comparison of
this to were provided there. All terms used in the code like strut, tie, nodal zone, etc.
were explained in this section. Beam analysed using computer aided strut and tie
(CAST) and designed using ACI and IS methods. Detailing is also provided for both
the design methods for easy assessment of section details.
Chapter 5 deals with experimental investigation part of the project. Here
design analysis and details of test specimen is described. As in every lab tests such as
test on aggregates and cube test details are explained in this chapter. Test set ups and
modelling explained with the help of figures.

1.4 SUMMARY
Introduction to the project topics is discussed in this chapter. Various software
used for analysis and two design method of Indian standard and ACI method were
explained. Details of experimental investigation also described. Details of each
chapter in this project are explained in organisation of thesis section.

Chapter 2
LITERATURE RIEVEW
2.1 INTRODUCTION
Optimisation in concrete beam is used for finding the optimum reinforcement,
removing the inefficient material, optimum layout of strut and tie reduce the cost of
structure etc. optimisation on concrete structure is difficulty because the composite
nature of reinforced concrete. Yet numbers of research were found for literature
review in reinforced concrete beams.
Choi and Kwak [3] presented a simple and effective algorithm for cost
optimization of rectangular beams and columns of RC frames by using a direct search
method according to the American (ACI 318-89) and Korean Codes. Design sections
for concrete elements are selected from some predetermined discrete sections which
have been accepted as suitable sections. The cost function included the costs of
concrete, reinforcement and formwork. The optimization of the entire structure was
accomplished through optimization of the individual members. A simple beam and a
10-storey RC building with two spans in each direction have been optimized as two
examples.
Chakrabarty [4] applied the geometric programming to find minimum cost
design of rectangular singly reinforced concrete beams. The area of tensile steel
reinforcement, the depth and width of the beam were the design variables. The
objective function was the cost of unit length of beam including the cost of tensile
reinforcement, concrete and formwork. He considered the strength constraints but
ignored the ductility and side constrains in his formulation. He did not introduce any
specific design code requirements in the constraint equations.
Moharrami and Grierson [5] studied minimum cost of RC building
frameworks. The width, depth and area of longitudinal reinforcement of member
sections are taken as the design variables. They used OC method to minimize the total
cost of building including the costs of concrete reinforcement and formwork, subject

to constraints on strength and stiffness to the American Code (ACI 318-89). The
columns have rectangular cross-sections and beams can be rectangular, L or T shapes.
Although in practice the design variables of the problem take discrete values, in this
approach they have been assumed continuous.
Das Gupta et al. [6] considered minimum cost design of RC frames in
accordance with the British Code (BS 8110). The objective function is the total costs
of concrete, steel, and formwork. Design variables are width and depth of the crosssection of each member and area of reinforcement in specific sections of members.
The problem has been transferred into an equivalent unconstraint minimization
problem using the exterior penalty function method of sequential unconstraint
minimization technique.
Khaleel et al. [7] made a comprehensive study on the optimization of simply
supported partially pre-stressed concrete girders under multiple strength and
serviceability criteria is presented, Using sequential quadratic programming a set of
optimal geometrical dimensions, amounts of pre-stressing and non pre-stressing steel,
and spacing between shear reinforcements are obtained. Results point to the need for
non pre-stressing steel to obtain economical designs; this study automates the design
of partially pre-stressed concrete girders and provides needed design solutions to
problems which are of importance to practicing engineers.
Adamu et al. [8] used continuum-type optimality criteria (COC) approach for
economic design of RC singly reinforced beams with rectangular cross section to the
European Code (CEB). The cost function consists of the cost of concrete, longitudinal
reinforcement and formwork of the beam. The design variables are the width,
effective depth, and steel ratio of a cross-section. The optimality criteria are derived
using the calculus of variation on an augmented Lagrangian function. An iterative
procedure based on optimality criteria is applied to optimize design of a RC beam
with fixed support at one end and simple support at the other end with variable depth
and width along its length.

Al-Salloum and Siddiqi [9] presented minimum cost design of singly


reinforced rectangular concrete beams based on the American Code (ACI 318- 89)
provisions. The cost function contains the cost of concrete, bending reinforcement and
formwork of the unit length of the beam. They presented a closed-form solution for
optimal depth and steel ratio of a beam with given width and design moment in terms
of material costs and strength parameters.
Zielinski et al. [10] investigated optimum design of RC short-tied rectangular
columns under biaxial bending based on the Canadian Code (CAN3-A23.3- M84).
The cost components of the objective function are the cost of concrete, longitudinal
reinforcement and formwork. Design variables are the cross sectional dimensions of
the column and the area of tension and compression bars or, alternatively, the number
of reinforcement along the width and depth of a column cross-section. Then the
problem is solved by the Powells method.
Fadaee and Grierson [11] presented the optimal design of three-dimensional
RC skeletal structures with rectangular section members subjected to biaxial
moments, biaxial shears, and axial loads to the American Code (ACI 318-95). They
used OC method to minimize the cost of concrete, steel and formwork for the
structure. The design variables are concrete cross-sectional dimensions and the area of
longitudinal bars in member sections. In another paper [38] considered optimization
of three-dimensional RC structures having shear walls, which can be subjected to pure
shear. The design variables for shear walls are the thickness of the wall, the area of
vertical reinforcement, horizontal distance between the vertical stirrups, the area of
horizontal reinforcement, vertical space between the horizontal stirrups and the area
of vertical flexural reinforcement. They used the method for design optimization of a
one-bay and one-storey space framework.
Balling and Yao [12] studied optimization of three-dimensional RC structures
with rectangular T or L-shape beams according to the ACI Code (ACI 318-89) by two
different methods. The first method is a bi-level method that optimizes concrete crosssection dimensions in one level and the number, diameter and topology of
reinforcement in another level. The second method represents the number, diameter
10

and topology of reinforcement through a single design variable, which is the total area
of steel. In this method, the area of steel and the cross-sectional dimensions of
members are optimized simultaneously. They concluded that the optimum costs
obtained from these two methods are very close to each other. Based on this
conclusion; they proposed a simplified method for cost optimization of space frames.
The cost function consisted of material, fabrication, and placement costs of the
concrete and reinforcement.
Aguilar et al. [13] was conducted study for determining the shear capacity of
deep beam based on ACI 318 2008. They tested four reinforced concrete deep beams.
The behaviour of the deep beams is described in terms of cracking pattern, loadversus-deflection response, failure mode, and strains in steel reinforcement and
concrete. The test specimens were designed with two different approaches, which
consisted of: 1) the procedure described in Sections 10.7 and 11.8 of the ACI 318-99
Code (ACI Committee 318 1999); and 2) the Strut-and-Tie Method given in
Appendix A of the ACI 318-02 Building Code. The experimental failure load of each
specimen is compared with the load capacities calculated using the procedures given
in the ACI 318-99 Code, and Appendix A of the ACI 318-02 Building Code.
Barakat et al. [14] presented a general approach to the single objective
reliability based optimum (SORBO) design of pre-stressed concrete beams (PCB).
Several limit states were considered, including permissible tensile and compressive
stresses at both initial and final stages, pre-stressing losses, ultimate shear strength,
ultimate flexural strength, cracking moment, crack width, and the immediate
deflection and the final long term deflection. The results consist of the initial and final
pre-stressing forces, Pre-stressing losses, immediate and final deflections, and upper
and lower bounds on the parabolic tendon profile.
Sahab et al. [15] studied the cost optimisation of reinforced concrete flat slab
buildings according to the British Code of Practice (BS8110). The objective function
was the total cost of the building including the cost of floors, columns and
foundations. The cost of each structural element covers that of material and labour for
reinforcement, concrete and formwork. Cost optimisation for three reinforced
11

concrete flat slab buildings is illustrated and the results of the optimum and
conventional design procedures are compared.
Govindaraj and Ramasamy [16] presented the application of Genetic
Algorithms for the optimum detailed design of reinforced concrete continuous beams
based on Indian Standard specifications. The produced optimum design satisfies the
strength, serviceability, ductility, durability and other constraints related to good
design and detailing practice. The optimum design results are compared with those in
the available literature. An example problem is illustrated and the results are
presented. It was concluded that the proposed optimum design model yields rational,
reliable, economical and practical designs.
Liang [17] presented the performance-based optimization of strut-and-tie
models in reinforced concrete beam-column connections. The performance-based
optimization (PBO) technique was employed to investigate optimal strut-and-tie
models in reinforced concrete beam-column connections. Developing strut-and-tie
models in reinforced concrete beam-column connections was treated as a topology
optimization problem. The optimal strut-and-tie model in a concrete beam column
connection was generated by gradually removing inefficient finite elements from the
connection in an optimization process. Optimal strut-and-tie models for the design
and detailing of opening knee joints, exterior beam-column connections and interior
beam-column connections are presented. He concluded PBO technology was an
effective tool for the design and detailing of structural concrete particularly the Dregions such as beam-column connections.
Liang et al. [18] conducted topology optimization of strut-and-tie models in
non-flexural reinforced concrete members by using the Evolutionary Structural
Optimization (ESO) method for plane stress continuum structures with displacement
constraints. It was shown that the proposed procedure can effectively generate optimal
topologies of strut-and-tie models in non-flexural reinforced concrete members such
as deep beams and corbels. It was concluded that on removing inefficient materials
from the concrete member, the strut and-tie model within the member was gradually
evolved towards an optimum.
12

Guerra and Kiousis [19] conducted study for achieve optimal design of
reinforced concrete (RC) structures. Optimal sizing and reinforcing for beam and
column members in multi-bay and multi-storey RC structures incorporates optimal
stiffness correlation among all structural members and results in cost savings over
typical-practice design solutions. He incorporated material and labour costs for
forming and placing concrete and steel as a function of member size. He fined
MATLABs (The math works.) sequential quadratic programming algorithm is highly
efficient and accurate for the design optimization of RC structures.
Guanand and Doh [20] developed strut-and-tie models of a total of fourteen
concrete deep beams with varying size and location of web openings using a topology
optimisation approach. By systematically eliminating inefficient materials from an
over-designed discretized domain, the load transfer mechanism in deep beams was
progressively characterised by the residual part of the structure. He used topology
optimisation method with stress and displacement constraints are employed with the
aim of maximising the material efficiency and overall stiffness of deep beams. The
method was used successfully to automatically produce the strut-and-tie models for a
total of 14 concrete deep beams with varying size and location of web openings. He
concluded that optimal topology (strut-and-tie model) was a fully stressed design and
accurately represents the actual stress path and the load transfer mechanism.
Mohammed and Ismail [21] was presented design optimization of structural
concrete beams using Genetic Algorithm (GA) technique. Two types of structural
beams were studied, namely: simple reinforced concrete beams and simple prestressed concrete beams. These beams were designed according to the requirements of
the ACI 318-05 code. The cost function comprises the cost of concrete and the cost of
reinforcement. He concluded that the GA optimizer does a remarkable effort on
minimizing the expensive material in the objective function of the numerical
examples. This effort was devoted to reduce the amount of this material since it has
the higher percentage of the total cost. Therefore, he concluded that the GA search
and optimization technique was powerful and intelligent.

13

Nagarajan and Madhavan [22] developed strut and tie models for simply
supported deep beams using topology optimization. The design of deep beams using
topology optimization was illustrated using an example and was compared with
available code recommendations. STM can be easily developed by using topology
optimization and it can be used to design deep beams subjected to any type of loading.
His conclusion was area of steel calculated using STM is less than that required
according to IS 456: 2000 recommendations.
Boualem and Fedghouche [23] conducted structural design optimization of
reinforced concrete T-beams under ultimate design loads. An analytical approach of
the problem based on a minimum cost design criterion and a reduced number of
design variables, was developed. It was shown, among other things, that the problem
formulation can be cast into a nonlinear mathematical programming format. Typical
examples were presented to illustrate the applicability of the formulation in
accordance with the current French design code BAEL-99. The results were then
confronted to design solutions of reinforced concrete T-beams derived from current
design practice. The optimal solutions show clearly that significant savings can be
made in the predicted amounts and consequently in the absolute costs of the
construction materials to be used.
Siradech and Benjapon [24] were used topology optimization as a tool to
determine the optimal reinforcement for reinforced concrete beam. The topology
optimization process was based on a unit finite element cell with layers of concrete
and steel. The thickness of the reinforced steel layer of this unit cell was then adjusted
when the concrete layer could not carry the tensile or compressive stress. At the same
time, unit cells which carried very low stress were eliminated. The process was
performed iteratively to create a topology of reinforced concrete beam which satisfied
design conditions.
Alankar and Chaudhary [25] aims to develop a Genetic Algorithm (GA)
based model to minimize the cost of single span steel concrete composite bridges with
precast decks. The cross-sectional dimensions have been considered as decision
variables in the present optimum design model along with the number of days for
14

which the precast slabs should be placed in a casting yard. The model formulation
accounts for the cost of concrete, steel beam and slab storage in the casting yard. The
cost optimization problem has then been formulated and implemented using
MATLAB by employing GA which is computationally efficient in solving such types
of complex optimization problems.
Kaveh and Sabzi [26] applied big bang-big Crunch algorithm for optimal
design of reinforced concrete planar frames under the gravity and lateral loads.
Optimization was based on ACI 318-08 code. Columns were assumed to resist axial
loads and bending moments, while beams resist only bending moments. The main aim
was to minimize the cost of material and construction of the reinforced concrete
frames under the applied loads such that the strength requirements of the ACI 318
code are fulfilled. In this paper, the big bang - big Crunch algorithm was proven able
to find optimal design of 2D reinforced concrete frames. BB-BC was applied for the
first time to this kind of discrete optimization problems. Numerical results
demonstrate the feasibility and efficiency of the proposed approach.
Bhalchandra and Adsul [27] conducted optimum design of simply supported
doubly reinforced beams with uniformly distributed and concentrated load has been
done by incorporating actual self-weight of beam, parabolic stress block, and
moment-equilibrium and serviceability constraints besides other constraints. The
principal design objective was to minimize the total cost of a structure. The result of
his study was genetic algorithm optimization technique showed a cost that was less
than the cost obtained from the generalized reduced gradient technique and interior
point optimization technique.
Amir [28] studied topology optimisation procedure for reinforced concrete
structure. Here he explained the procedure for designing beam using strut and tie
model. FEA method was used for topology optimisation. His major conclusion was
that Load-bearing per unit weight improved by over 20% for a given range of
displacements and topology optimisation was also used for finding the optimal layout
of the reinforcement in beams.

15

Gahtani et al. [29] was concerned with the cost minimization of pre-stressed
concrete beams using a special differential evolution-based technique. The optimum
design is posed as single-objective optimization problem in presence of constraints
formulated in accordance with the current European building code. This paper
investigated the application of the constrained differential evolution algorithm (ICDE)
for the optimum design of pre-stressed concrete beams. Ultimate and serviceability
limit states from the current European building code have been considered, and the
manufacturing cost has been assumed as objective function to be minimized.
Adib [30] presented optimization of thin walled column elements under axial
load, optimum design of wing structure, minimum cost design of grid floor, elevated
water tank staging and minimum weight design of sheet-stringer panels. Genetic
algorithm was used for optimisation purpose. His major conclusions were stress
constraint was the only active constraint at the optimum point and the optimal design
is sensitive to the way in which this constraint is defined. And the optimal design was
sensitive to the degree of correlation between member stresses.
2.2 COMMENTS ON LITERATURE REVIEW
Literature review has found that though there are many papers on topology
optimisation techniques, there is little research being done on its application in
reinforced concrete design and verifying these methods through physical testing. It
was observed that these optimisation techniques are well developed methods that have
been verified through vigorous numerical analysis. Topology optimisation using FEM
software ANSYS is a highly accurate method. Here is a possibility of optimisation
using ANSYS. Here used ANSYS software for topology optimisation. Yet, physical
testing is essential as it has been well documented that physical behaviour of
reinforced concrete is hard to model using numerical modelling.
2.3 OBJECTIVES
The aims and specific objectives of this project are as follows:
Review of strut and tie model for concrete deep beam.
Analysis of deep beam using Computer Aided Strut and Tie (CAST) software.
16

Study of ANSYS software for topology optimisation.


To implement topology optimisation for concrete deep beam.
To be able to provide reinforced concrete designers a simple and effective
method of reducing the volume of deep beam without reducing its
performance.
2.4 METHODOLOGY
The methodology used to complete this dissertation is described in the following
steps:
1. Review of strut and tie model for design of deep beams.
2. Design the deep beam using ACI 318 2008 design approach.
3. Design the deep beam using IS 456 2000 design approach.
4. Research background information relating to topology optimisation.
5. Using ANSYS software to determine the optimum layout and design using

strut-and-tie method.
6. Concrete mix design for M25 mix.
7. Cube test for determining concrete compressive strength.
8. Prepare samples of deep beam and optimised beam.
9. Perform three point bending test on both beams and compare the result.

2.5 SUMMARY
In this chapter previous studies made in field optimisation, strut and tie model,
optimisation using genetic algorithm etc. were explained in literature review.
Comments on literature review were included for understanding the potential of the
problem. This chapter also explained the objectives and methodology of the project.

17

Chapter 3
TOPOLOGY OPTIMISATION IN DEEP BEAM
3.1 INTRODUCTION
This chapter explains about basics of topology optimisation. Optimisation
methods, Software used for topology optimisation, basics of topology optimisation by
ANSYS, beam modelling in ANSYS, different element used for modelling concrete
and steel and its property etc. are explained in the following sections. Modelled
images from ANSYS are also provided.
3.2 OPTIMISATION
Topology optimization is perhaps the most difficult of all three types of
structural optimization. The optimization is performed by determining the optimal
topology of the structure. The design variables control the topology of the design.
Optimization therefore occurs through the determination of design variable values
which correspond to the component topology providing optimal structural behaviour.
While it is easy to control a structures shape and size as the design variables are the
coordinates of the boundary (shape optimization) or the physical dimensions (size
optimization), it is difficult to control the topology of the structure. In this problem,
the design domain is created by assembling a large number of basic elements or
building blocks. By beginning with a set of building block representing the maximum
allowable region (region in space which the structure may occupy) each block is
allowed to either exist or vanish from the design domain, a unique design is evolved.
For example in the topology optimization of a cantilever plate, the plate is discretised
into small rectangular elements (building blocks), where each element is controlled by
design variables which can vary continuously between 0 and 1. When a particular
design variable has a value of 0, it is considered to be a hole, likewise, when a design
variable has a value of 1, it is considered to be fully material. The elements with
intermediate values are considered materials of intermediate densities. The
development of topological optimization can be attributed to [31]. They presented a
homogenization based optimization approach of topology optimization. They

18

assumed that the structure is formed by a set of non-homogenous elements which are
composed of solid and void regions and obtained optimal design under volume
constraint through optimization process. In their method, the regions with dense cells
are defined as structural shape, and those with void cells are areas of unnecessary
material. The maximization of the integral stiffness of a structure composed of one or
two isotropic materials of large stiffness using the homogenization technique was
discussed by [32]. Application of Genetic algorithm for topology optimization was
made by [33]. Given structures boundary conditions and allowable design domain, a
discretised design domain is created. The genetic algorithm then generates an optimal
structure topology by evolving a population of chromosomes, where each
chromosome, after mapping into the design domain creates a potentially-optimal
structure topology. [34] computed the effective properties of strong and weak
materials. It is shown that when 4-noded quadrilateral elements are used, the resulting
topology consists of artificially high stiffness material which is difficult to
manufacture. This material appears in specified manner and is known as the checker
board pattern due to alternate solid and void elements. [35] Investigated a continuous
topology optimization framework based on hybrid combinations of classical Reuss
and Voigt (stiff) mixing rules. To avoid checker boarding instabilities, the continuous
topology optimization formulation is coupled with a novel spatial filtering procedure.
[36] Summarized the current knowledge about numerical instabilities such as
checkerboards, mesh-dependence and local minima occurring in applications of the
topology optimization method. The checkerboard problem refers to the formation of
regions of alternating solid and void elements ordered in a checkerboard-like fashion.
The mesh-dependence problem refers to obtaining qualitatively different solutions for
different mesh-sizes or discretization. A local minimum refers to the problem of
obtaining different solutions to the same discretised problem when choosing different
algorithmic parameters. A web-based interface for a topology optimization program
was presented by [37]. The program is available over World Wide Web. The paper
discusses implementation issues and educational aspects as well as statistics and
experience with the program. [38] Studied a level-set method for numerical shape
optimization of elastic structures. The approach combines the level-set algorithm with

19

the classical shape gradient. Although this method is not specifically designed for
topology optimization, it can easily handle topology changes for a very large class of
objective functions. [35] Presented a node-based design variable implementation for
continuum structural topology optimization in a finite element framework and
explored its properties in the context of solving a number of different design
examples. Since the implementation ensures C0 continuity of design variables, it is
immune to element wise checker boarding instabilities that are a concern with
element-based design variables. The objective of maximizing the Eigen frequency of
vibrating structures for avoiding the resonance condition was considered by [38]. This
can also be achieved by maximizing the gap between two consecutive frequencies of
the given order. Different approaches are considered and discussed for topology
optimization involving simple and multiple Eigen frequencies of linearly elastic
structures without damping. The mathematical formulations of these topology
optimization problems and several illustrative results are presented. [36] Suggested a
new way to solve pressure load problems in topology optimization. Using a mixed
displacementpressure formulation for the underlying finite element problem, we
define the void phase to be an incompressible hydrostatic fluid. [8] Evaluated and
compared the established numerical methods of structural topology optimization that
have reached the stage of application in industrial software. [40] presented a new
penalization scheme for the SIMP method. One advantage of the present method is
the linear density stiffness relationship which has advantage for self-weight or Eigen
frequency problem. The topology optimization problem is solved through derived
Optimality criterion method (OC), which is also introduced in the paper. [18]
presented a stochastic direct search method for topology optimization of continuum
structures. In a systematic approach requiring repeated evaluations of the objective
function, the element exchange method (EEM) eliminates the less influential solid
elements by switching them into void elements and converts the more influential void
elements into solid resulting in an optimal 01 topology as the solution converges. For
compliance minimization problems, the element strain energy is used as the principal
criterion for element exchange operation. [28] Obtained topologically optimal
configuration of sheet metal brackets using Optimality Criterion approach through

20

commercially available finite element solver ANSYS and obtained compliance versus
iterations plots for various aspect ratio structures (brackets) under different boundary
conditions.
Topology optimization is a mathematical approach that optimises material
layout within a given design space, for a given set of loads and boundary conditions
such that the resulting layout meets a prescribed set of performance targets.
Mathematically one can pose a generic problem as follows:
Min

( )

(3.1)

Subjected to
1.

2. Design constraints
3. Governing differential equations
Objective function (

( )

This is the goal of the optimization study which is to be minimised over the
selection field. For example, one would want to minimise the compliance of a
structure to increase structural stiffness.
Design space ( )
Design space is the allowable volume within which the design can exist.
Assembly and packaging requirements, human and tool accessibility are some of the
factors that need to be considered in identifying this space. With the definition of the
design space, regions or components in the model that cannot be modified during the
course of the optimisation are considered as non-design regions.
The Discrete Selection Field ()
This is the field over which the discrete optimisation is to be performed. It
selects or deselects a point on the design space to further the design objective. By
selection it has to take the value, 1, and by de-selection it has to take the value, 0.

21

Design constraints
These are design criteria that need to satisfy. These could include material
availability constraints, displacement constraints, Design for flexure, Minimum
spacing between bars, and Maximum spacing between bars, Maximum and minimum
reinforcement ratios, Design for shear Deflection control etc.
Governing Differential Equation
This is the one that governs the physics of the structure to be built. For example
the elasticity equation in the case of stiff structures would be the governing
differential equation.
3.3 OPTIMISATION METHODS
Optimisation is widely uses in aerospace industry, automobile industry, etc. in
civil engineering especially structural engineering it creates new challenges. [17]
developed mat lab 99 line code for optimisation of concrete structure. It is modified to
88 line and 104 line codes and is known as modified mat lab codes.
Software such as ANSYS, OPTISTRUCT (Altair), TOSCA (Fe-design),
GENESIS, ABAQUS, etc. is available for topology optimisation. The software can
run direct topology optimisation by imputing the material property, loads and support
condition.
In this project topology optimisation is done in ANSYS software. ANSYS 12.1
with CIVIL FEM is used for optimisation of deep beams.
3.3.1 Topology optimization using ANSYS
The goal of topological optimization is to find the best use of material for a
body such that an objective criterion (i.e. global stiffness, natural frequency, etc.)
attains a maximum or minimum value subject to given constraints (i.e. volume
reduction). In this work, maximization of static stiffness has been considered. This
can also be stated as the problem of minimization of compliance of the structure.
Compliance is a form of work done on the structure by the applied load. Lesser

22

compliance means lesser work is done by the load on the structure, which results in
lesser energy is stored in the structure which in turn, means that the structure is stiffer.
Mathematically,
Compliance =

(3.2)

Where, u = Displacement field


f = Distributed body force (gravity load etc.)
= Point load on ith node
= ith displacement degree of freedom
t = Traction force
S = Surface area of the continuum
V = Volume of the continuum
ANSYS employs gradient based methods of topology optimization, in which
the design variables are continuous in nature and not discrete. These types of methods
require a penalization scheme for evolving true, material and void topologies. SIMP
(Solid Isotropic Material with Penalization) is a most commonly penalization scheme,
and is explained in the next section.
The SIMP method
The SIMP stands for Solid Isotropic Material with Penalization method. This
is the penalization scheme or the power law through which is the basis for evolution
of a 0-1 topology in gradient based methods.
In the SIMP method, each finite element (formed due to meshing in ANSYS)
is given an additional property of pseudo-density,

where 0<

, which alters the

stiffness properties of the material.


(3.3)
Where,
= Density of the jth element
= Density of the base material

23

= Pseudo-density of the jth element


This Pseudo-density of each finite element serves as the design variables for
the topology optimization problem. The stiffness of jth element
Pseudo-density

depends on its

in such a way that,


(3.4)

Where,

= Stiffness of the base material

= Penalization power
For,

= 0, which means no material exists

For,

= 1, which means that material exists

In SIMP

is taken to be greater than 1 so that intermediate densities are

unfavourable in the sense that that the stiffness obtained is small as compared with the
volume of the material. In other words, specifying a value of

higher than 1 makes it

uneconomical to have intermediate densities in the optimal design.


As a matter of fact, for problems where the volume constraint is active, results
shows that optimization does actually result in such designs if one chooses
sufficiently large (in order to achieve complete 0-1 designs,

is usually

required).
In ANSYS, the standard formulation of topology optimisation problem defines
the problem as minimising the structural stiffness and maximising the fundamental
frequency while satisfying a constraint on volume of the structure. Another problem is
the maximisation of natural frequency of the structure subjected to dynamic loading,
while satisfying a constraint on the volume of the structure.
The objective function (function which is to be minimized in topology
optimization) is generally the compliance of the structure. A constraint on usable
volume is applied on the structure. As the volume reduces, the structures stiffness
also reduces. So the volume constraint is of opposing nature. The Compliance of a
discretised finite element is given by,

24

C (x) =

(3.5)

The force vector (which is a function of the design variable

) is given by

K (x) u=F

(3.6)

Therefore, C(x) can be written as,


C(x) =
Subjected to

( )

(3.7)

V0

(3.8)

A lower bound on the design variables has been applied to avoid singularity in
the stiffness matrix
3.4 SPECIMEN GEOMETRY AND BOUNDARY CONDITIONS
In the present investigation, specimen geometry and boundary conditions
applied have been used as shown in the Fig.3.1.
Model
A simply supported deep beam of dimensions 700cmx36cmx15cm is shown in
Fig.3.1. The beam is acted upon by two concentrated load of 200kN each as shown in
figure.
233.3cm

233.3cm
200kN

700cm
Fig.3.1 Deep beam model
25

233.3cm
200kN

3.5 MODELLING IN ANSYS


ANSYS provides different solid element for modelling. Each of them is
different in property. Beam modelling in ANSYS based on the requirement of the
project. SOLID 65 can capable of crushing in compression and cracking in tension. It
is used for concrete modelling. Crack and crush at ultimate load can be obtained from
the

SOLID 65. Main objective of this project is topology optimization. SOLID 65

is not supported for topology optimization. So another element SOLID 95 is used for
modelling the deep beam for optimization. SOLID 95 unable to crack and crush at
ultimate loads. In the initial modelling of deep beam is done using SOLID 95 for
topology optimization. For obtaining crack pattern and ultimate loads deep beam is
again modelled in SOLID 65. Similarly optimized beam is modelled in SOLID 65 for
obtain crack and crush results. Details of SOLID 65 and SOLID 95 are explained in
next section.
Reinforcement can be modelled in different element such as beam (BEAM
188) and link (2D spar 8). These two types are not supported for topology
optimization. Discrete reinforcement is provided in solid 95 elements for topology
optimization. In this type of reinforcing tension, compression and shear reinforcement
is different. For detection of crack and crush reinforcement is modelled using BEAM
188 in SOLID 65. Both type reinforcing is explained below.
Solid65
SOLID65 (Fig.3.2) is used for the 3-D modelling of solids with or without
reinforcing bars (rebar). The solid is capable of cracking in tension and crushing in
compression. In concrete applications, for example, the solid capability of the element
may be used to model the concrete while the rebar capability is available for
modelling reinforcement behaviour. Other cases for which the element is also
applicable would be reinforced composites (such as fiberglass), and geological
materials (such as rock). The element is defined by eight nodes having three degrees
of freedom at each node: translations in the nodal x, y, and z directions. Up to three
different rebar specifications may be defined.

26

The concrete element is similar to the SOLID45 (3-D Structural Solid)


element with the addition of special cracking and crushing capabilities. The most
important aspect of this element is the treatment of nonlinear material properties. The
concrete is capable of cracking (in three orthogonal directions), crushing, plastic
deformation, and creep. The rebar are capable of tension and compression, but not
shear. They are also capable of plastic deformation and creep

Fig.3.2 SOLID65 element geometry


Solid95
SOLID95 (Fig.3.3) is a higher-order version of the 3-D 8-node solid element
SOLID45. It can tolerate irregular shapes without as much loss of accuracy. SOLID95
elements have compatible displacement shapes and are well suited to model curved
boundaries. The element is defined by 20 nodes having three degrees of freedom per
node: translations in the nodal x, y, and z directions. The element may have any
spatial orientation. SOLID95 has plasticity, creep, stress stiffening, large deflection,
and large strain capabilities.
Reinf264
The element is suitable for simulating reinforcing fibers with arbitrary
orientations (Fig.3.4). Each fiber is modelled separately as a spar that has only

27

Fig.3.3. SOLID 95 element geometry


uniaxial stiffness. We can specify multiple reinforcing fibres in one REINF264
element. The nodal locations, degrees of freedom, and connectivity of the REINF264
element are identical to those of the base element. REINF264 used with standard 3-D
link, beam, shell and solid elements.
REINF264 has plasticity, stress stiffening, creep, large deflection, and large
strain capabilities

Fig.3.4 REINF264 element geometry


28

Beam 188
BEAM188 (Fig.3.5) is suitable for analysing slender to moderately thick beam
structures. The element is based on Timoshenko beam theory which includes sheardeformation effects. The element provides options for unrestrained warping and
restrained warping of cross-sections.
The element is a linear, quadratic, or cubic two-node beam element in 3-D.
BEAM188 has six or seven degrees of freedom at each node. These include
translations in the x, y, and z directions and rotations about the x, y, and z directions.
A seventh degree of freedom (warping magnitude) is optional. This element is wellsuited for linear, large rotation, and/or large strain nonlinear applications. The element
includes stress stiffness terms, by default, in any analysis with large deflection. The
provided stress-stiffness terms enable the elements to analyse flexural, lateral, and
torsional stability problems (using eigenvalue buckling, or collapse studies with arc
length methods or nonlinear stabilization).
Elasticity, plasticity, creep and other nonlinear material models are supported.
A cross-section associated with this element type can be a built-up section referencing
more than one material.

Fig.3.5 BEAM 188 element geometry

29

3.5.1 Material properties of Concrete


Open shear transfer coefficient

=0-1

Closed shear transfer coefficient

=0

Uniaxial cracking stress

=1.6MPa

Uniaxial crushing stress

=25MPa

Modulus of elasticity

= 25000

Poisons ratio

=0.21

3.5.2 Material properties of Reinforcement


Modulus of elasticity

= 25000MPa

Poisons ratio

=0.21

Reinforcement modelled using REINF 264 is given in Fig.3.6

Fig.3.6.Reinforcement modelled using ANSYS


Reinforcement with concrete model is shown in Fig.3.7.
30

Fig.3.7. Beam modelled using ANSYS


3.6 SUMMARY
This chapter explained about of topology optimisation programme.
Optimisation methods, Software used for topology optimisation, basics of topology
optimisation by ANSYS, beam modelling in ANSYS, different element used for
modelling concrete and steel and its property are explained. Modelled images beam
and reinforcement from ANSYS are provided in this chapter.

31

Chapter 4
CONVENTIONAL DESIGN OF DEEP BEAM
4.1 INTRODUCTION
Design of concrete structure design can be done referring any standard codes.
Many papers were published for different design approach. ACI318:2008 [1] and
IS456:2000 [2] is used as design codes. Strut and tie method of design is adopted in
ACI 318: 2008 while IS 456: 2000 uses method of shear wall design. Here deep beam
designed using both methods.
4.2 STRUT AND TIE METHOD OF DESIGN
Reinforced concrete beam theory is based on equilibrium and the constitutive
behaviour of the materials, steel and concrete. Particularly important is the
assumption that strain varies linearly through the depth of a member and that, as a
result plane sections remain plane. St. Venants principle validated this assumption by
stating that strains around load or member cross section discontinuity vary in an
approximately linear fashion at distance greater than or equal to the greatest cross
sectional dimension h from the point of load application as shown in Fig. 4.1 and
Fig.4.2.
At points closer than the distance h to discontinuous load or member
dimensions, St Venants principle is not applicable. Reinforced concrete structures
can be divided into regions where beam theory is valid and regions where
discontinuities affect member behaviour. A region where beam theory is valid is
referred to as B-regions and a region with discontinuities is referred to as D-regions.
When the concrete is elastic and un-cracked, the stresses in D-regions can be
determined using finite element analysis and elastic theory. After concrete cracks the
strain field is disrupted and internal forces are redistributed. The internal force can be
represented by a statically determinate truss known as the strut-and-tie model, which
allows the complex problem to be simplified. Fig.4.3 shows examples of strut and-tie
model in typical reinforced concrete members.

32

Fig.4.1.Geometric discontinuity

Fig.4.2.Loading discontinuity

33

Fige.4.3 Examples of strut and-tie model


4.3 DEFINITIONS
The following terms are used in this section
B-region A portion of a structure in which the Bernoulli-Euler assumption
that plane sections remain plane can be applied.
Discontinuity An abrupt change in members geometry or loading.
D-region The portion of a member within a distance equal to the member
depth h from a force discontinuity or a geometry discontinuity. In D-regions
Bernoulli- Eulers assumption is not valid after the concrete cracks.
Node A point in a strut-and-tie model where the axes of the struts, ties and
concentrated forces acting on the joint intersect.

34

Nodal zone The volume of concrete surrounding a node that transfers strutand-tie forces through the node.
Strut A compressive member in a strut-and-tie model. A strut represents the
resultant of a parallel or fan-shaped compressive field.
Bottle-shaped strut A strut that is wider at mid-length than at its ends.
Strut-and-tie model A truss model of a structural member, made up of
struts and ties connected at nodes that are capable of transforming the factored
loads to the supports.
Tie A tension member in a strut-and-tie model.
4.4 KEY COMPONENTS OF STRUT-AND-TIE MODELS
Strut-and-tie modelling is considered the basic tool in the design and detailing
of structural concrete under bending, shear and torsion. The designer specifies a load
path and then designs and details the structure such that this load path is sufficiently
strong to carry the applied loads. The loads applied to the structural concrete member
are transferred through a set of compressive stress fields that are distributed and
interconnected by tension ties. The compression stress fields are idealised using
compression members called struts while tensile stress fields are idealised using
tension members called ties. Tension ties can be reinforcing steel bars or pre-stressed
tendons or concrete in tension. Concretes tensile strength is considerably less than its
compressive strength and normally concretes tensile resistance is ignored.
Struts
A strut is an internal compression member. It may have a prismatic, fan or
bottle shape as shown in Fig.4.4. Prismatic shape is an idealised representation of fan
or bottle shaped struts. The dimensions of the cross section of the strut are established
by the contact area between the strut and the nodal zone.
Bottle shaped struts are wider at the centre than the ends and as the
compression zone spreads along the length of bottle shaped struts, tensile stresses
perpendicular to the axis of the strut may cause longitudinal cracking. For simplicity
in design, bottle shaped struts are idealised as having linearly tapered ends and

35

Prismatic stress field

Fan stress field (no bursting forces)

Bursting forces

Bottle stress field

Fig.4.4 Types of concrete struts and related stress fields.


uniform centre sections as shown in Fig.4.5.The capacity of the struts is proportional
to the concrete compressive strength and it is affected by the lateral stresses in bottle
shaped struts. Because of longitudinal splitting, bottled shaped struts are weaker than
prismatic struts, even though they possess a larger cross section at mid-length.

36

Width used to compute Ac

Tie

Strut
Crack

Fig.4.5 Bottle-shaped strut.


Ties
A tie is a tension member in a strut-and-tie model. The ties consist of either
steel bar or a pre-stressed tendon. For design purpose, it is assumed that the concrete
within the tie does not carry any tensile force. Concrete does assist in reducing tie
deformation at service load.
Nodes
Nodes are points within strut-and-tie models where the axis of struts, ties and
concentrated loads intersect. For equilibrium, at least three forces must act on a node.
Nodes are defined by the sign of forces acting at it. Therefore, a CCC node resists
three compressive forces; a CCT resists two compressive forces and a one tensile
force. There can be multiple forces acting at a node but care must be taken to ensure
there is room for anchorage of tie reinforcements. Fig.4.6 illustrates some common
node classifications.
Both tensile and compressive forces place nodes in compression because
tensile forces are treated as if they pass through the node and apply compression in
the anchorage face. There are two types of nodes, non-hydrostatic and hydrostatic

37

nodes. A node is hydrostatic if all members are at right angles to the adjacent node
angle other than right angle, the node is non-hydrostatic as shown in Fig.4.7 (a) and
Fig.4.7 (b).

(a) C-C-C node


(b) C-C-T node

(c) C-T-T node

(d) T-T-T node

Fig.4.6. Classification of nodes.

(b) Non-hydrostatic node

(a) Hydrostatic node

Fig.4.7. Node types

38

Advantages of Using Strut-and-Tie Modelling


1. The designer can easily idealise the flow of internal forces in a structural
concrete member.
2.

The influence of shear and moment can be accounted for simultaneously and
directly in one model.

3.

The designer can give special attentions to the potential weak spots indicated
by the strut-and-tie model.

4.

It offers a unified, rational and safe design procedure for structural concrete.

Limitations of Strut-and-Tie Modelling


Strut-and-tie modelling is good for structures at overload, that is, after
extensive cracking and large deformations have occurred. It is not suited to
representing transitional behaviour when the structure is changing from un-cracked to
the fully cracked condition. The strut-and-tie model is a conservative design approach
which means that it is almost always over designed.
The strut-and-tie modelling offers the designer the flexibility to focus on
performance design while also providing a safe design. Different performance criteria
may be achieved with strut-and-tie modelling, however, the ultimate failure mode and
load cannot be predicted by strut-and-tie modelling.
4.5 DESIGN OF DEEP BEAM BASED ON ACI 318 2008
Here deep beam with span=7m and depth=3.6m is designed as per ACI 318
2008. Concrete grade assumed is M25 with two point load of 2000kN as shown in
Fig.4.8.
4.5.1 Analysis using Computer aided strut and tie (CAST)
Computer aided strut and tie (CAST) is software for analysis of deep beam
using strut and tie method (STM).CAST utilizes a single interface for creation or
modification of strut-and-tie models, truss analysis, selection of reinforcing steel and
capacity checks of the struts and nodes.

39

CAST has been developed by the University of Illinois since 2001. It was used
to serve students and practicing engineers to grasp the concept and to try various
idealized strut-and-tie models with ease.
CAST components comprise of nodes and elements. Elements represent struts
or ties meeting at nodes. For particular cases, stabilizer is necessary to make the
model numerically stable. Three types of boundary conditions can be applied at
exterior nodes: plate, point loads, and supports. Body force and support can also be
applied to interior nodes within D-region. The model must be restrained to prevent
rigid body movement. In CAST, positive value of forces is point outward from node
and vice versa. Since the direction of point loads on the boundary will follow the axis
of the strut, no element connectivity is allowed on boundary.
Strut and tie model is modelled in cast software. Analysis is done in cast
software for determining the load on strut, tie and its nature. Result of CAST analysis
is shown in Fig.4.8

Fig.4.8. CAST analysis result


4.5.2 Structural design
12345As per ACI 318 2008 nominal shear strength (Vn) for deep beams shall not
exceed 10

(ACI 318 Cl 11.7.2)

40

(4.1)

And

(4.2)

Where
=shear strength.
=cylinder compressive strength=0.8 fck=20MPa
b=width=0.6m
d=depth 0.9 h=3.24m
=capacity reduction factor=0.75
Substituting

=7244.86kN
=5433.65>1973

hence ok

Effective compressive force at nodes and struts-(ACI 318 A.5.2)


Nodes A and B
= 0.85

(4.3)

Where the value of n is given by


In nodal zones bounded by struts or bearing areas, or both

n = 1.0;

In nodal zones anchoring one tie

n = 0.80;

In nodal zones anchoring two or more ties

n = 0.60.

=0.850.80.820=10.88
=10.88MPa
Node C
=13.6MPa

41

Strength of strut (ACI 318.A.3)


Nominal compressive strength of strut without longitudinal reinforcement,
=

(4.4)

Where
fce= 0.85s fcassume bottled shaped strut s=0.75

(4.5)

fce=0.850.750.820=10.2MPa
Width of strut
=>0.75 2002.8

(4.6)

2670.4
From equation (3.4) we can calculate area of strut
=>2670.410.2
=261803.92sqmm
W (width of strut)= 261803.92/600=436.33mm
Width of tie- (ACI318 A.4)
Fnt= Atsfy+ Atp(fse+ fp) , where Atpis zero for non-pre-stressed members

(4.7)

Fnt= /=1160kN
From equation (3.7) area of tensile reinforcement is given by,
Ats=11601000/415=2795.18sqmm
No of 25mm diameter bars= 6
Development of standard hooks in tension
Develop length is provided for increase the friction between bar and concrete
from equation (4.8) we get development length for the bar in tension.

42

Ld=

db 12

(4.8)

Where
,

Then Ld = 556.77
Shear reinforcement
The area of shear reinforcement perpendicular to the flexural tension
reinforcement, Av, shall not be less than 0.0025bws, and s shall not exceed the
smaller of d/5 and 12 in.(s=150mm)

= 0.002512>0.0025 ok

(4.9)

The area of shear reinforcement parallel to the flexural tension reinforcement

= 0.002512>0.0025 ok
sini 0.003=46.39

(4.10)

Use 12mm dia stirrup at 150mm c/c


4.5.3 Detailing of deep beam designed by ACI method.
Detailing of beam is provided in Fig.4.9. Six no of 25mm diameter bar is
provided at the bottom of slab and 12mm bars are provided at 250mm c/c for shear
reinforcement on both face as shown in Fig.4.9

43

700

60

360

12mm dia @ 150mmc/c

60

Six no of 25mm dia bar

(All dimensions are in cm)


Fig.4.9 Details of deep beam designed by ACI method.
4.6 DESIGN OF DEEP BEAM BASED ON IS 456 2000
Determination of design bending moment
In a simply supported beam, the bending moment is calculated as in ordinary
beams. For a point load w, moment at mid spam
M=

(4.11)

=3500kNm
Determination of area of tension steel
The area of tension steel to carry the tension is determined by the empirical
method of assuming a value for the lever arm. IS 456 clause 29.2 [2] gives the
following value for z the lever arm length.
For simply supported beams,

44

Z=0.2(L+2D) when L/D is between 1and 2


=0.6L when L/Dis less than 1
Area of tension steel,
=Mu/fsZ

(4.12)

Where
Z=2840mm
Fs=0.87fy=361N/mm2
Area of tension steel is 3413.834mm2
Provide 7 no of 25mm diameter bars
Design for shear
Critical section for shear
The critical section for maximum shear is located at distance from the base of
0.5 Lw or 0.5 Hw (whichever is less)
=1.8m from the bottom
Nominal shear stress
The nominal shear stress

vw in

walls is given by

vw=Vu/td

(4.13)

Where
Vu= shear force due the design load
t= wall thickness
d= 0.8 x Lw

45

Lw=span
Then

vw=0.60

This never exceeds 0.17 fck in limit stat design.


0.17 fck=4.5<0.60 hence ok
Design shear strength of concrete (cl 32.4.3 IS 456)
The design shear strength of concrete in walls,

cw

, without shear reinforcement is

taken as
cw=(3.0-Hw/Lw

)K1

for Hw/Lw<1

(4.14)

Where
k1=0.2 for limit state method
K1=0.12 for working stress method
Then

cw=2.49

Design of shear reinforcement (cl 32.4.4 IS 456)


Shear reinforcement shall be provide to carry a shear equal to
Vu-

cwt(0.8Lw)

(4.15)

It is less than minimum required. Minimum reinforcement must be proved as


per cl.32.5 of IS 456:2000
Minimum requirement of reinforcement
Vertical reinforcement
Area of vertical steel/gross concrete area =0.0012 for bar with diameter <
16mm
Are of vertical steel=5040mm2

46

Spacing of 12mm diameter bar =155mm. it must be provide in both direction


Horizontal reinforcement
Area of horizontal steel/gross concrete area =0.002
Are of horizontal steel =4320mm2 it is greater than the steel required for
bending (3413mm2). So addition reinforcement must be provided at the top as holding
stirrup.
Provide 2 no of 25mm diameter bar at top.
Detailing as per the data is shown in Fig .4.10
4.6.1 Detailing of deep beam designed by IS 456 (2000) method.
Detailing of deep beam is shown in Fig.4.10. 7 no of 25mm diameter bars are
provided at the bottom as tie. Shear reinforcement (12mm) is provided at 155mm
centre to centre as shown in figure.

700

60

360

12mm dia @ 155mmc/c

60

7 no of 25mm dia bar

All dimensions are in cm


Fig.4.10. Details of deep beam designed by IS 456 (2000) method.

47

4.7 MODELLING IN ANSYS


Topology optimisation of deep beam is done in ANSYS. Modelling is
completed using solid 95 elements for concrete (which supports for topology
optimisation) and REINF 264 elements for reinforcement. Reinforcement modelled
using REINF 264 is given in Fig.4.11.Reinforcement with concrete model is shown in
Fig.4.12.

Fig.4.11.Reinforcement modelled using ANSYS

Fig.4.12. Beam modelled using ANSYS

48

4.8 RESULT OF OPTIMISATION IN ANSYS


Result of optimisation is given below in Fig 4.13. The different colours in this
represent material usefulness in the beam. Red region in the figure represent the
material with density is one. Which means that element must be there for resisting the
in applied load. Pure blue colour represents material with zero density, which means
there is no need of that element for resisting external load. In between blue and red
represent density between zero and one. The entire portion in blue can be removed for
fifty present of optimisation.
Stress in steel is represented in Fig 4.14. Reinforcement shows different
colours. Each colour represents the stress intensity. Red portion stands for highly
stressed steel while blue represent less stressed region. In between blue (minimum)
and red (maximum) stress state will vary.

Fig.4.13. Density plot of deep beam


49

Fig.4.14 Stress in steel for deep bam


4.8.1deflection
Deflection for deep beam calculated in ANSYS and is drawn in graph with
load in y axes and deflection in x axis (Fig.4.15). The maximum deflection obtained is
15.5mm.
Load deflection
10

Load x1000 kN

8
6
4
2
0
0

10
Deflection in mm

15

Fig.4.15. Load deflection graph for deep beam

50

20

Deep beams failed by shear failure. Cracks starts at the centre and extends to
support. Fig.4.16. show the cracks of deep beam.

Fig.4.16. Crack pattern for deep beam obtained from ANSYS


4.9 SUMMARY
In this chapter design of deep beam by various approaches were discussed.
Both ACI and IS code practice. Both design yield same result. ACI method based on
the strut and tie modelling while IS code based on shear wall design method. Analysis
for calculating force in strut and tie was completed in CAST software. This software
is useful for complex strut and tie models. Detailing for both design were included in
this chapter. Topology optimisation result from ANSYS included here. Load
deflection, crack pattern (obtained from ANSYS) is included in this chapter. In order
to verify the results, laboratory test was conducted on both optimised and deep beam.
This is described in following sections.

51

Chapter 5
EXPERIMENTAL INVESTIGATION
5.1 INTRODUCTION
Due to the lack of laboratory facility, small models of deep beam and
optimised beam were tested for validation of the project. Conventional design method
used here for designing deep beam are STM based of ACI 318 2008 and IS 456 2000.
Comparison of both methods is done in last section. Design of deep beam, mix
design, cube test, test setups for three point bending test on deep beam etc. are
explained in this chapter.
5.2 DESIGN OF DEEP BEAM (ACI 318-2008)
5.2.1. Data for design: - In this design beam span depends on the span of UTM
available in the laboratory. Other assumed data as follows.
Assume fy=415MPa,
fck=25MPa
Span is 60cm and Assume depth 35 cm, (L/D<2)
Design load-150kN.
5.2.2 Analysis
Concentrated load -150kN
Self-weight =0.60.35250.15=0.79kN
Total load =150.79kN
Analysis of deep beam
Manual analysis is done to calculate force in strut and tie. This value is then
checked by CAST analysis. Fig.5.1 shows support reaction for deep beam. Analysis is
done by equilibrium equation. Result of analysis is shown in Fig.5.2

52

150.79 kN

w/2 =75.39

w/2=75.39
Fig.5.1. Support reaction

Force in the member


Assume depth is 0.9H =31.5cm

150.79 kN
C
31.5cm

60cm

75.3 kN A

75.39 kN

Fig.5.2 Strut and tie model.


=46.39deg
Member force

=104.13kN

=104.13cos46.39=71.8kN
5.2.3 Analysis using Computer Aided Strut and Tie (CAST)
Computer Aided Strut and Tie can be used for calculation the load in strut and
tie. Fig .5.1.shows result of CAST analysis. From the figure strut and tie forces above
obtained is almost same to the CAST result.

53

Fig.5.3. CAST analysis result


5.2.4 Structural design
As per ACI 318-2008 Vn for deep beams shall not exceed 10/12
(ACI 318 Cl 11.7.2)
And

(5.1)

(5.2)

Where
=shear strength.
=cylinder compressive strength=20MPa
bw=width=15cm
d=depth=28.8cm
=capacity reduction factor=0.75
Substituting
=>

=176.01N
=120.747>75.39

kN

hence ok.
54

Effective compressive force at nodes and struts-(ACI 318 A.5.2)


Nodes A and B
= 0.85

(5.3)

Where the value of n is given by


In nodal zones bounded by struts or bearing areas, or both

n = 1.0;

In nodal zones anchoring one tie

n = 0.80;

In nodal zones anchoring two or more ties

n = 0.60.

Then,
=0.850.80.820=10.88
=10.88MPa
Node C
=17MPa
Strength of strut (ACI 318.A.3)
Nominal compressive strength of strut without longitudinal reinforcement,
=

(5.4)

Where
fce= 0.85sfcassume bottled shaped strut s=0.75
fce=0.850.750.825=12.75
Width of strut
=>0.75 104.13
138.84

55

(5.5)

From equation (5.4)


=138.813.6
=10205.88sqmm
W (width of strut) = 10205.88/150=68.03mm
Width of tie- (ACI318 A.4)
Fnt= Atsfy+ Atp(fse+ fp)Atpis zero for non-pre-stressed members

(5.6)

Fnt= /=95.733
Ats=95.7331000/415=230.68sqmm
Use 2 no of 8 mm diameter bars and 2 no of 12 mm diameter bars
Development of standard hooks in tension
Develop length is provided for in crease the friction between bar and concrete
from equation (5.7) we get development length for the bar in tension.
Ld=

db

Where,

(5.7)

Then Ld=267.25
Shear reinforcement
The area of shear reinforcement perpendicular to the flexural tension
reinforcement, Av, shall not be less than 0.0025bws, and s shall not exceed the
smaller of d/5 and 12 inch.(s =250)

= 0.00267>0.0025 hence ok
The area of shear reinforcement parallel to the flexural tension reinforcement

56

= 0.00267>0.0025

hence ok

sini 0.003=46.39
=>

sin46.39=0.0038>0.003 ok

5.2.5 Detailing
Detailing of reinforcement with spacing is given in Fig.5.4
8mm dia bar @250mmc/c in both directions

350mm

2 no of 8mm dia bar +2 no

12mm dia bar

150mm

700mm

Fig.5.4. Detailing of deep beam by strut and tie method.


5.3 DESIGN OF DEEP BEAM BASED ON IS 456 2000
Determination of design bending moment
In a simply supported beam, the bending moment is calculated as in ordinary
beams. For a point load w, moment at mid spam
M=

(5.8)

=26.25kNm
57

Determination of area of tension steel


The area of tension steel to carry the tension is determined by the empirical
method of assuming a value for the lever arm. Is 456 clause 29.2 [] follows the CEB
(committee euro international du beton) and gives the following value for z the lever
arm length.
For simply supported beams,
Z=0.2(L+2D) when L/D is between 1and 2

(5.9)

=0.6L when L/Dis less than 1


Area of tension steel,
Mu/fsZ

(5.10)

Where
Z=280mm
fs=0.87fy=361N/mm2
Area of tension steel is 260mm2
Provide 2 no of 12 mm bar and 2 no of 8mm bar
Design for shear
Critical section for shear
The critical section for maximum shear is located at distance from the base of
0.5 Lw or 0.5 Hw
=0.175m from the bottom
Nominal shear stress
The nominal shear stress

vw

in walls is given by

vw=Vu/td

(5.11)

58

Where
Vu= shear force due the design load
t= wall thickness
d= 0.8 x Lw
Lw=span
vw=0.89

This never exceeds 0.17 fck in limit stat design.


0.17 fck=4.5<0.89 hence ok
Design shear strength of concrete (cl 32.4.3 IS 456)
The design shear strength of concrete in walls,

cw

, without shear

reinforcement is taken as
cw=(3.0-Hw/Lw

)K1

for Hw/Lw<1

(5.12)

Where, k1=0.2 for limit state method


K1=0.12 for working stress method
cw=2.5

Design of shear reinforcement (cl 32.4.4 IS 456)


Shear reinforcement shall be provides to carry a shear equal to Vu-

cwt

(0.8Lw). Here Vu is small so no need to provide shear reinforcement. Yet minimum


reinforcement must be proved as per cl.32.5 of IS 456
Minimum requirement of reinforcement
Vertical reinforcement

59

Area of vertical steel/gross concrete area =0.0012 for bar with diameter <
16mmAre of vertical steel=126mm2
Spacing of 8mm diameter bar =250mm
Horizontal reinforcement
Area of horizontal steel/gross concrete area =0.002
Are of horizontal steel =105mm2
Spacing of 8mm diameter bar =250mm
5.3.1 Detailing: - Details of tension reinforcement and shear reinforcement is given in
Fig.5. 5
8mm dia bar @300mmc/c in both directions

350mm
150mm

m
2 no
of 8mm dia bar +2 no
700mm
12mm dia bar

700mm
Fig.5.5. Detailing of deep beam by IS 456 method.
5.4. MODELLING OF DEEP BEAM
DEEP beam (model 2) modelled using SOLID 95 element type.
Reinforcement is provided in discrete by using REINF 264 element type.
Reinforcement is shown in Fig.5.6.

60

Fig.5.6. Reinforcement modelling using REINF264 element


Deep beam with reinforcement is modelled in ANSYS as shown in Fig.5.7

Fig.5.7. Beam modelled using ANSYS


61

5.5 MODELLING OF OPTIMISED BEAM


Shape of optimised beam was determined by topology optimisation in
ANSYS. After getting density plot from ANSYS optimised beam is modelled in
ANSYS for comparing the load carrying capacity and crack pattern, optimised model
has particular shape. So it is difficult to model its shape in ANSYS. In that case it is
assumed that rectangular edge gives almost same result as that of optimised one.
Fig.5.8 shows model of rectangular modelled optimised beam.

Fig.5.8 Optimised beam modelled using ANSYS.


5.6 EXPERIMENTAL PROGRAMME
5.6.1 Specific gravity tests for aggregates
Specific gravity of aggregate is made use of in design calculations of concrete
mixes with the specific gravity of each constituent known. It weights can be converted
into solid volume and hence a theoretical yield of concrete per unit volume can be
calculated. Specific gravity of aggregate is also required to be considered when we
deal with light weight and heavy weight concrete.

62

Average specific gravity of rocks vary from 2.6 to 2.8


Specific Gravity of Fine Aggregate
Weight of empty cylinder, W1

= 3.55kg

Weight of empty cylinder + sand, W2

= 6.10kg

Weight of empty cylinder + sand+ water, W3

= 6.90kg

Weight of empty cylinder +water, W4

= 5.250kg

Volume of void (W3-W2)

=0.8cm2

Volume of container (W4-W1)

= 1.75kg

Weight of aggregate= (W2-W1)

= 2.55kg

Bulk density= (W2-W1) / (W4-W1)

= 1.485

Voids ratio= (W3-W2)/ {(W4-W1)-(W3-W2)}

= 0.8421

Porosity=Vv/V = W3-W2/W4-W1

= 0.4571

Specific gravity = wt. of fine aggregate/wt. of equal volume of water= 2.736


Specific gravity of coarse aggregate
Wt. of empty container (W1)

= 7.2kg

Wt. of container + aggregate (W2)

= 21.5kg

Wt. of container + aggregate +water (W3)

= 26.10kg

Wt. of container + water (W4)

= 17.1kg

Volume of voids (Vv) = (W3-W2)

= 4.6kg

Volume of container (V) = (W4-W1)

=9.8kg

Wt. of aggregate = (W2-W1)

=14.3kg

63

Bulk density= W2-W1/W4-W1

=1.459kg

Void ratio = Vv/V solid =W3-W2/ [(W4-W1)-(W3-W2)]

=0.8846

Porosity

=0.469

= Vv/V = W3-W2/W4-W1

Specific gravity

= Wt. of aggregate/Wt. of equal volume of water


=W2-W1/ [(W4-W1)-(W3-W2)]

=2.75

5.6.2 Concrete mix design (IS 10262:2009)


Concrete mix design is the method of correct proportioning of ingredients of
concrete, in order to optimise the above properties of concrete as per site
requirements. Concrete is an extremely versatile building material because, it can be
designed for strength ranging from M10 (10MPa) to M100 (100MPa) and workability
ranging from 0 mm slump to 150 mm slump. In all these cases the basic ingredients of
concrete are the same, but it is their relative proportioning that makes the difference.
Basic Ingredients of Concrete: 1. Cement It is the basic binding material in concrete.
2. Water It hydrates cement and also makes concrete workable.
3. Coarse Aggregate It is the basic building component of concrete.
4. Fine Aggregate Along with cement paste it forms mortar grout and fills the
voids in the coarse aggregates.
5. Admixtures They enhance certain properties of concrete e.g. gain of
strength, workability, setting properties, imperviousness etc.
Concrete mix design (IS 10262: 2009)
Grade of concrete

=25MPa

Cement

= OPC43

Maximum size of aggregate

=20mm
64

Minimum cement content

=320kg/m3

Maximum water cement ratio

=0.45

Workability

=100mm slump

Exposure condition

=Medium

Degree of super vision

=Good

Types of aggregate

=Crushed
angular aggregate
=450kg/m3

Maximum cement content


Calculation
Specific gravity of cement

=3.15

Specific gravity of
1. Fine aggregate

=2.736

2. Coarse aggregate

=2.75

Water absorption
1. Fine aggregate

=0.5%

2. Coarse aggregate

=1%

Free surface moisture


1. Fine aggregate

= Nil

2. Coarse aggregate

=Nil

Fine aggregate conforming to zone 1 is assumed for calculation purpose


=f1ck=f ck +1.65s

Target compressive strength

=25+1.65 4
=31.6N/mm2

65

Selection of water cement ratio


Maximum water content

=186kg

Water for 100mm slump =186+6/100 186

=197kg

Calculation of cement content


W-c ratio

=0.5

Cement content =197/.50

=394kg/m3

Mix calculation
(a) Volume of concrete

=1m3

(b) Volume of coarse aggregate

=0.60

(c) Volume of fine aggregate

=0.40

Mix calculation for 1m3 concrete.


Volume of concrete

=1m3

Volume of cement =393/3.15 1/1000

=0.125m3

Volume of water =197/1 1/1000

=0.197m3

Volume of all in aggregate =1-.125-.197

=0.678m3

Mass of coarse aggregate =0.678 0.6 2.736 1000

=1113kg

Mass of fine aggregate =0.678 0.40 2.75 1000

=745.8kg

Mix proportion for one m3 concrete,


Cement

= 394kg/m3

Water

=197 kg/m3

Fine aggregate

=746 kg/m3

Coarse aggregate

=1113 kg/m3

W-c ratio

= 0.5%
66

5.6.3 Result of cube test


Cubes are prepared and tested for checking the accuracy of the mix design. Six
cubes were casted and three of them tested in 7 days and remaining is tested 28 days.
Seven days compressive strength is 22.2MPa.
Twenty eight days compressive strength is 26.6MPa.
5.6.4 Casting of RC deep beam
Reinforcement details
All reinforcement conforming to IS: 1786- 2006, stirrups were made from
8mm diameter bars. 12mm diameter bars are used at bottom of each specimen.
The reinforcement details of beam are Main reinforcement provided in the
beam was12 mm diameter bars of 2Nos and 2 of Nos 8mm diameter bars at bottom.
The stirrups are 8 diameter bars at 25 mm c/c. reinforcement were bends at an Angele
of 90 degree both end to get adequate development length. Two numbers of 8mm bar
is provided at the top of the beam for holding the stirrups.
Concrete
Ingredients and mix proportion
All the concrete used for casting beam was made in laboratory. The concrete
mix was designed to provide 28 day cube strength of 25MPa. Normal weight river
sand was used as fine aggregate and crushed granite stones were used as coarse
aggregates, with a maximum size of 40mm. ordinary OPC cement is used for
concreting. All the ingredients were batched by weight, and mixed in drum mixer.
Water added as per the mix design results. Drum mixer has capacity of one cubic feet.
Four such batches were prepared for casting beams.
Casting and curing
The mould is arranged at floor of the laboratory. The sides of the mould is
oiled well to prevent side wall of the mould from absorbing water from the concrete
and to facilitate easy removal of the specimen. The reinforcement cage were placed in

67

mould and cover between cage and form provided was 20 mm. Concrete mix
designed for M25 (1:1:2.5)The concrete contents such as cement, sand, aggregate and
water were weighed accurately and mixed .The mixing was done till uniform mix was
obtained. The concrete was placed in to the mould immediately after mixing and well
compacted. Compaction is done using tamping road. The beam is cast in vertical
direction (in the load bearing direction). The test specimens were re moulded at end
of 24 hours of casting. They were marked identifications. They are cured in water for
28 days. After 28 days of curing the specimen was dried in air and tested.
5.6.5 Test set up
Deep beam and optimised beam are shown in Fig 5.9 and Fig. 5.10
respectively. Point loads at the middle span of the beam are applied by universal
testing machine (UTM) in the laboratory (It works on the basics of Pascals law). It
has maximum capacity of 600kN with maximum span of 70cm. Beam deflection at
the mid span is determined using dial gauge at the middle span as shown in the
Fig.5.11. Dial gauge has least count of .01mm. first 10 reading with each increment
of 10kN were recorded. Finally dial gauge were removed for finding ultimate load
carrying capacity.
Three point bending test was also conducted for optimised beam. Dial gauge
was set up at the middle bottom portion of the beam as shown in Fig.5.12.
Displacement corresponding to each increment of 10kN is recorded. Dial gauge was
removed after 100kN. At ultimate loading cracks were occurred. Cracks were marked
sequentially as they form. Ultimate load carry capacity recorded from UTM

Fig.5.9 Deep beam

Fig.5.10 Optimised beam


68

Fig.5.11 Test set up for deep beam.

Fig.5.12 Test set up for optimised beam.

69

5.7 SUMMARY
This chapter explained the experimental investigation of this project. The
project is validated through laboratory experiments. Laboratory test for mix design,
determining compressive strength of concrete, three point bending test, etc. were done
in laboratory.

70

Chapter 6
RESULT AND DISCUSSION
6.1 INTRODUCTION
Results of this project are explained in following section. Result of cube test,
results obtained by ANSYS such as deflection, cracking load bearing capacity are
explained in this section. Result of optimisation i.e. density plot from ANSYS is
included in this chapter. Discussion based on the result is provided in the last section.
6.2. RESULT OF OPTIMISATION
Optimisation is carried out in ANSYS for both beams. Result of optimisation
is given below in Fig.6.1. In this figure there are different colours. These coliour
represent meterial usefullness in the beam. Red region in the figure represent the
material with density is one.which means that material must be there for resisting the
in applied load. Pure blue colour represent material with zero density. Which mens
there is no need of that material. In bet ween blue and red represent density between
zero and one. All the portion in blue was removed for fifty persent of optimisation.

Fig.6.1. Density plot of deep beam

71

From the figure all the reinforcement are shown in red colours. So at the mid portion
there is only reinforcement (without concrete). This is difficult to cast. Stress in the
reinforcement in Fig.6.2 shown is all the steel is fully stressed. Portion in red colour
represent highly stressed region and portion shown in the blue region is less stressed.
Partially stressed section of reinforcement can be removed.

Fig.6.2 Stress in steel for deep beam


6.3. RESULT OF BENDING TEST OF CONVENTIONAL DEEP BEAM
6.3.1 Load carrying capacity
Deep beam is designed for 150kN capacity. In bending test the result obtained
is 135kN. Optimised beam had load carrying capacity of 128.5kN.
6.3.2 Deflection
Load deflection graph for deep beam in ANSYS is compared with laboratory
result is given in Fig. 6.3. from the graph ansys deflection is low as compared to test
result. This is because of the assumption made in ANSYS software ie there is no slip

72

between concrete and steel. The result varition may be due to the qulity of concrete
and lack of good compaction. Yet shape of the curve is same in both the result.
Sudden in crease in deflection at the end region is same nature in both cases.
Load deflection graph
30

load x10kN

25
20
Experimental

15

ANSYS model

10
5
0
0

Deflection in mm

10

12

14

Fig.6.3. Comparison of deflection in ANSYS and experimental result


6.4. COMPARISON BETWEEN OPTIMISED BEAM AND DEEP BEAM
6.4.1 Ultimate load carrying capacity
Optimisation is done in fifty present volume reductions. Result obtained for
conventionally designed beam is 135kN. That of optimised beam is 128.5kN. That is
about only 5

reduction of load carrying capacity. Optimised beam has volume

reduction of 50%. When we compare to its load carrying capacity it is not a huge
reduction as compared to its volume reduction.
6.4.2 Deflection.
From the graph it is shown that deflection for the two beams is almost same.
In the initial part of the graph optimised beam (Beam 1) shows nearly equal deflection
to that of deep beam (Beam 2) (Fig.6.4). After 110kN deflection of optimised beam is
larger than that of deep beam.

73

Load-deflection Graph
16

Load (x10kN)

14
12
10
8

Beam 2 beam
optimised

6
4

Beam 1

2
0
0

10

15

20

Deflection in mm

Fig.6.4 comparison of Deflection for beam 1 and beam 2


6.4.3 Crack pattern
Deep beams are fails by shear failure. Cracks starts at the centre and extends
to support. Fig.6.5. show the cracks of deep beam. It is compared with cracks of
optimised beam shown in Fig.6.6. Probability of cracking is also checked in ANSYS.
Crack pattern for deep beam obtained in ANSYS is shown in Fig.6.7. And crack
pattern for optimised beam obtained in ANSYS is shown in Fig.6.8

Fig.6.5. Crack pattern for the deep beam

74

Fig.6.6. Crack pattern for the optimised beam

Fig.6.7. Crack pattern for deep beam obtained from ANSYS

75

Fig.6.8. Crack pattern for optimised beam obtained from ANSYS


6.4.4 Failure mode
Deep beams are generally fails by shear failure. In this experiment deep beam
fails by shear failure. Intensity of point load is high as compared to the crushing
strength of concrete. Concrete under the load head was crushed due to this reason.
Fig.6.10. shows the crushing failure of concrete at the point of application of load.
ANSYS analysis is shown in Fig.6.9 shows theoretical formation of failure under the
load. Crushing failure of optimised beam obtained from ANSYS is shown in Fig.
6.11. The first failure of deep beam is crushing failure. Both test result and ANSYS
analysis gives the same output. First failure of optimised beam was concrete crush
under the point of application of load. Then crack starts. Order of formation of cracks
was ordered numerically as shown in Fig.6.5 for conventionally designed beam and
Fig.6.6 for optimised beam. Formation of first crack obtained from ANSYS for the
deep beam and optimised beam is shown in Fig.6.7 and Fig.6.8. This result shows that
deep beam fails by shear failure.

76

Fig.6.9. Concrete crushing at point of application of load obtained from


ANSYS

Fig.6.10. Concrete crushed at the point of application of load


77

Fig.6.11. crushing failure of optimised beam obtained from ANSYS


6.5 DISCUSSIONS
Topology optimisation is best method of weight saving of concrete structure
without reducing its performance. But its now emerging field of structural
engineering. Here our objective is to compare the performance of optimised beam and
conventionally designed beam. If comparisons show there is no reduction in
performance then we can conclude that topology is best method of weight saving in
concrete structures. But load carrying capacity of optimised beam is slightly less than
conventionally designed beam. The reason may be due to the accuracy of optimisation
or poor construction practice. There is probability of poor construction practice when
casting of optimises beam because of its shape. Compaction of optimised beam was
not as expected due to its shape. Recasting of optimised beam with new technique
with proper compaction may improve its property.

78

6.6 SUMMARY
In this chapter various results of this project were explained and compared.
Comparison between optimised beam and conventionally designed beam were
compared for its load carrying capacity, deflection, and crack pattern. Comparison of
results between ANSYS and test specimen were compared. Comparison of load
carrying capacity, deflection was explained with the help of graph. Finally a small
discussion based on the result obtained was done.

79

Chapter 7
CONCLUSION AND SCOPE FOR FURTHER WORK
7.1 CONCLUSION
The main conclusions drawn from the current research can be summarised as
follows:
1. Deflection and ultimate load bearing capacity of deep beam obtained from
finite element (FE) analysis is comparable to that of experimental value and
this shows that ANSYS software can be used for the analysis of deep beams
2. The variation in ultimate load carrying capacity of optimised beam is marginal
and is only 5% less than that of deep beam without optimisation. There for
topology optimisation method can be effectively used for deep beams.
3. Deflection profile for deep beam and optimised beam obtained in finite
element analysis were nearly equal.
4. Crack pattern of beams obtained in finite element analysis is almost similar to
that obtained in experimental programme.
7.2 SCOPE FOR FURTHER WORK
1. In this study optimised beam layout is obtained from FE analysis using
ANSYS. Additional research can be carried out by changing the software to
MAT LAB, SOLID THINKING, and TOP OPT etc.
2. Compaction is difficult in optimised beam due to non-uniform shape of the
beam and its formwork. So modification of mould or compaction method can
be considered for additional research.
3. In this experimental research small size beams were cast and tested, large size
beam can be considered for further research.

80

REFERENCES
1. IS 456:2000, (2002)plain and reinforced concrete code of practice forth
revision.
2. ACI Committee 318, (2008), Building code requirements for structural
concrete, ACI 318-2008, American Concrete Institute.
3. Choi, C. and Kwak, H, (1990), Optimum RC member design with
predetermined discrete sections, Journal of Structural Engineering, ASCE,
Vol. 116, No. 10, pp.2634-2655.
4. Chakrabarty, B.K, (1992), Models for optimal design of reinforced concrete
beams, Computers and Structures, Vol. 42, No. 3, pp. 447-451.
5. Moharrami, H. and Grierson D.E., (1993), Computer-automated design of
reinforced concrete frameworks, Journal of Structural Engineering, ASCE,
Vol.119, No. 7, pp. 2036-2058.
6. Das Gupta, N.C., Thevendran, V. and Tan, G.H, (1993), Optimal design
of reinforced concrete frames, 3rd International Conference on Computer
Aided Optimum Design of Structures 93, Southampton, Computational
Mechanics Publications, London, Elsevier Applied Science, pp. 43-55.
7. Khaleel M. A. and Itani R. Y, (1993), "Optimization of Partially Prestressed
Concrete Girders under Multiple Strength and Serviceability Criteria",
Computers and structures journal, Volume 49, Issue 3, PP. 427-438.
8. Adamu, A. and Karihaloo, B.L, (1995), Minimum cost design of RC frames
using the DCOC method, Part I: columns under uniaxial bending actions,
Structural Optimization, Vol. 10, No. 1, pp. 16-32.
9. Al-Salloum, Y.A. and Siddiqi, G.H, (1994), Cost-optimum design of
concrete beams, ACI Structural Journal, Vol. 91, No. 6, pp. 647-655.
10. Zielinski, Z.A., Long, W. and Troitsky, M.S. (1995), Designing reinforced
concrete short-tied columns using the optimization technique, ACI Structural
Journal, Vol. 92, No. 5, pp. 619-626.

81

11. Fadaee, M.J. and Grierson, D,(1998), Design optimization of 3D reinforced


concrete structures having shear walls, Engineering with Computers, Vol.
14, No. 2, pp. 139-145.
12. May, S.A. and Balling, R. J, (1992) , A filtered simulated annealing strategy
for discrete optimization of 3D steel frameworks, Structural Optimization,
No. 4, pp.142-146
13. Gerardo Aguilar, Adolfo B. Matamoros, Gustavo J. Parra-Montesinos,
Julio A. Ramrez, and James K. Wight,( 2002), Experimental Evaluation
of Design Procedures for Shear Strength of Deep Reinforced Concrete
Beams ACI Structural Journal, vol No. 4
14. Barakat S., Bani-Hani K. and Taha M, (1989), "Multi-objective ReliabilityBased Optimization of Pre-stressed Concrete Beams", Structural safety
Journal 26, pp. 311-342.
15. Sahab, M. G, (2002), Cost optimization of reinforced concrete flat slab
buildings, PhD thesis, University of Bradford, UK.
16. Govindaraj, V. and Ramasamy, J, (2005), Optimum detailed design of
reinforced concrete continuous beams using Genetic Algorithms, Computers
and Structures, Vol. 84. pp. 3448.
17. Qing Quan Liang, (2006), performance-based optimization of strut-and-tie
models in reinforced concrete beam-column connections University of
Southern Queensland, Australia.
18. Liang, Y.M. Xie1, G.P. Steven and L.C, (1999) Schmidt Topology
Optimization of Strut-and-Tie Models in Non-Flexural Reinforced Concrete
Members International Conference on Mechanics of Structures, Materials
and Systems.
19. Andres Guerra and Panos D. Kiousis, (2006), Design optimization of
reinforced concrete structures Computers and Concrete, Vol. 3, No. 5.
20. Hong Guan and Jeung-Hwan Doh, (2007), development of strut-and-tie
models in deep beams with web openings Griffith University Gold Coast
Campus, Queensland, Australia.

82

21. Mohammed A. Ismail, (2007), Design Optimization of Structural Concrete


Beams Using Genetic Algorithms Islamic university of Gaza, department of
civil engineering.
22. Praveen Nagarajan and T.M. MadhavanPillai, (2008). Development of
strut and tie models for simply supported deep beams using topology
optimization Department of Civil Engineering, National Institute of
Technology Calicut, India.
23. BoualemTliouine and Ferhat Fedghouche, (2010), Optimal Design of
Reinforced Concrete T-Beams under Ultimate Loads 2nd International
Conference on Engineering Optimization.
24. SiradechSurit

and

BenjaponWethyavivornv,

(2011),

Topology

optimization of reinforced concrete beams by a spread-over reinforcement


model with fixed grid mesh journal of science and technology, vol-33.
25. Kushagra Alankar and Sandeep Chaudhary, (2012), Cost Optimization of
Composite Beams using Genetic Algorithm and Artificial Neural Network
International Conference on Computer Technology and Science IPCSIT vol.
47.
26. Kaveh and O. Sabzi,( 2012), Optimal design of reinforced concrete frames
Using big bang-big crunch algorithm International Journal of Civil
Engineering, Vol. 10, No. 3.
27. Bhalchandra, P.K.Adsul, (2012), Cost Optimization of Doubly Reinforced
Rectangular Beam Section International Journal of Modern Engineering
Research, Vol. 2, Issue. 5.
28. Oded Amir, (2013), Topology Optimization Procedures for Reinforced
Concrete Design Israel Institute of Technology Symposium.
29. Al-Gahtani A. S., Al-Saadoun S. S. and Abul-Feilat E. A, (1995), "Design
Optimization of Continuous Partially Prestressed Concrete Beams", Computer
and structures journal, vol.55. No. 2, pp. 365-370.
30. Adib, A.K, (1975), Optimal design of reinforced concrete slab and its
column supports, Ph.D. Thesis, Louisiana Technology University, USA.

83

31. Bendsoe, M.P and Kikuchi N, (1988), Generating optimal topology in


structural design using a homogenization method Computer methods applied
Mechanical .Engineering. vol. 71, 197224.
32. Thomsen J, (1992). Topology optimization of structures composed of one or
two materials Structural Multidisciplinary Optimisation. Vol. 5: 108-115.
33. Choi, C. and Kwak, H, (1990), Optimum RC member design with
predetermined discrete sections, Journal of Structural Engineering, ASCE,
Vol. 116, No. 10, pp.2634-2655.
34. Duffin, R. J. Peterson, E. L., and Zener, (2005), Geometric programming
New York: Wiley.
35. Rahmatalla and Swan, (2004), A Q4/Q4 continuum structural topology
optimization implementation, Struct. Multidisc. Optim. Springer-Verlag, Vol
27: 130-135.
36. Sigmund and. Petersson J, (1998). Numerical instabilities in topology
optimization: A survey on procedures dealing with checkerboards, meshdependencies and local minima, Structural Optimisation. Vol .16: 68-75.
37. Sahab, M. G, (2002), Cost optimization of reinforced concrete flat slab
buildings, PhD thesis, University of Bradford, UK.
38. Peabody. V, (1939), Continuous frame analysis of flat slabs, Journal of the
Boston Society of Civil Engineers, Vol. 26, No. 3, pp.183-207.
39. Elperin, T, (1996), Monte Carlo structural optimization in discrete variables
with annealing algorithm, International Journal of Numerical Methods in
Engineering, Vol. 26, pp. 815-821.
40. Darwin, C, (1859), On the Origin of Species by Means of Natural Selection,
or the Preservation of Favoured Races in the Struggle for Life, John Murray
London.
41. IS 10262 (2009) Concrete mix proportioning-guideline first revision

84

S-ar putea să vă placă și