Documente Academic
Documente Profesional
Documente Cultură
International Code Council, ISBN ICC International Energy Conservation ■ 11. Amend § 435.303 to revise the
7801S04. Code, 2004 Supplement Edition, January section heading and paragraphs (a) and
(c) Availability of references. The 2005 (incorporated by reference, see (b) to read as follows:
building energy performance standard § 435.3).
§ 435.303 Requirements for the design of a
incorporated by reference is available
§ 435.6 Sustainable principles for siting, Federal residential building.
for inspection at:
(1) National Archives and Records design and construction. [Reserved] (a) The head of each Federal agency
Administration (NARA). For responsible for the construction of
§ 435.7 Water used to achieve energy
information on the availability of this efficiency. [Reserved]
Federal residential buildings shall
material at NARA, call (202) 741–6030, establish an energy consumption goal
or go to: http://www.archives.gov/ § 435.8 Life-cycle costing. for each residential building to be
federal_register/ Each Federal agency shall determine designed or constructed by or for the
code_of_federal_regulations/ life-cycle cost-effectiveness by using the agency, for which design for
ibr_locations.html procedures set out in subpart A of 10 construction began before January 3,
(2) U.S. Department of Energy, CFR part 436. A Federal agency may 2007.
(b) The energy consumption goal for
Forrestal Building, Room 1M–048 choose to use any of four methods,
a Federal residential building for which
(Resource Room of the Federal Energy including lower life-cycle costs, positive
design for construction began before
Management Program), 1000 net savings, savings-to-investment ratio
January 3, 2007, shall be a total point
Independence Avenue, SW., that is estimated to be greater than one,
score derived by using the micro-
Washington, DC 20585–0121, (202) 586– and an adjusted internal rate of return computer program and user manual
9138, between 9 a.m. and 4 p.m., that is estimated to be greater than the entitled ‘‘Conservation Optimization
Monday through Friday, except Federal discount rate as listed in OMB Circular Standard for Savings in Federal
holidays. Number A–94 ‘‘Guidelines and Discount Residences (COSTSAFR),’’ unless the
(d) Obtaining copies of standards. The Rates for Benefit-Cost Analysis of head of the Federal agency shall
building energy performance standard Federal Programs.’’ establish more stringent requirements
incorporated by reference may be for that agency.
obtained from the following source: the Subpart C—Mandatory Energy
International Code Council, 4051 West Efficiency Standards for Federal * * * * *
Flossmoor Road, Country Club Hills, IL Residential Buildings. [FR Doc. E6–20439 Filed 12–1–06; 8:45 am]
60478–5795, http://www.iccsafe.org/e/ BILLING CODE 6450–01–P
Each Federal agency shall determine buildings for which design of This AD requires actions that are
energy consumption levels for both the construction began before January 3, intended to address the unsafe
baseline building and proposed building 2007 except multifamily buildings more condition described in the MCAI.
by using the Simulated Performance than three stories above grade. DATES: This AD becomes effective
Alternative found in section 404 of the * * * * * December 19, 2006. The Director of the
VerDate Aug<31>2005 12:11 Dec 01, 2006 Jkt 211001 PO 00000 Frm 00010 Fmt 4700 Sfmt 4700 E:\FR\FM\04DER1.SGM 04DER1
Federal Register / Vol. 71, No. 232 / Monday, December 4, 2006 / Rules and Regulations 70285
Federal Register approved the considered in forming the engineering MCAI in order to follow FAA policies.
incorporation by reference of P&WC basis to correct the unsafe condition. Any such differences are described in a
Alert Service Bulletin PW500–72– The AD contains text copied from the separate paragraph of the AD. These
A30314, dated September 27, 2006, MCAI and for this reason might not requirements take precedence over the
listed in the AD as of December 19, follow our plain language principles. actions copied from the MCAI.
2006. FAA’s Determination of the Effective
Discussion
ADDRESSES: You may send comments by Date
Transport Canada, which is the
any of the following methods: An unsafe condition exists that
aviation authority for Canada, has
• DOT Docket Web site: Go to http:// requires the immediate adoption of this
issued Airworthiness Directive CF–
dms.dot.gov and follow the instructions AD. The FAA has found that the risk to
2006–22, dated October 26, 2006
for sending your comments the flying public justifies waiving notice
(referred to after this as ‘‘the MCAI’’), to
electronically. and comment prior to adoption of this
correct an unsafe condition for the
• Fax: (202) 493–2251.
specified products. The MCAI states rule because the flight hours per month
• Mail: Docket Management Facility,
that there have been three reported of some operators exceed the
U.S. Department of Transportation, 400
incidents of PW535A engines leaking compliance time of 50 hours. The
Seventh Street, SW., Nassif Building,
fuel in service. Investigation revealed statistical mean operating hours per
Room PL–401, Washington, DC 20590–
the manufacturing process of the fuel month is 37.8 hours with a maximum of
0001.
• Hand Delivery: Room PL–401 on manifold introduced characteristics that approximately 110 hours per month for
the plaza level of the Nassif Building, have resulted in a loss of sealing at a some operators based on a 1,710-engine
400 Seventh Street, SW., Washington, crimped joint. PW535A engine fuel sample size. Therefore, we determined
DC, between 9 a.m. and 5 p.m., Monday manifold leakage that could result in that notice and opportunity for public
through Friday, except Federal holidays. engine fire, in-flight shutdown or comment before issuing this AD are
• Federal eRulemaking Portal: http:// damage to the airframe. You may obtain impracticable and that good cause exists
www.regulations.gov. Follow the further information by examining the for making this amendment effective in
instructions for submitting comments. MCAI in the AD docket. fewer than 30 days.
responsibilities to identify and correct substantively from the information the authority described in ‘‘Subtitle VII,
unsafe conditions on U.S.-certificated provided in the MCAI and related Part A, Subpart III, Section 44701:
products. service information. General requirements.’’ Under that
This AD references the MCAI and We might also have required different section, Congress charges the FAA with
related service information that we actions in this AD from those in the promoting safe flight of civil aircraft in
VerDate Aug<31>2005 12:11 Dec 01, 2006 Jkt 211001 PO 00000 Frm 00011 Fmt 4700 Sfmt 4700 E:\FR\FM\04DER1.SGM 04DER1
70286 Federal Register / Vol. 71, No. 232 / Monday, December 4, 2006 / Rules and Regulations
air commerce by prescribing regulations Applicability requirements and has assigned OMB Control
for practices, methods, and procedures (c) This AD applies to Pratt & Whitney Number 2120–0056.
the Administrator finds necessary for Canada (P&WC) PW535A turbofan engines Related Information
safety in air commerce. This regulation that have fuel manifold, part number (P/N)
3025267–01, installed. These engines are (h) Refer to MCAI Transport Canada
is within the scope of that authority Airworthiness Directive CF–2006–22, dated
because it addresses an unsafe condition installed on, but not limited to Cessna
Airplane Co. model 560 Citation Ultra Encore October 26, 2006, and P&WC Alert Service
that is likely to exist or develop on airplanes. Bulletin PW500–72–A30314, dated
products identified in this rulemaking September 27, 2006, for related information.
action. Reason (i) Contact: Ian Dargin, Aerospace
(d) There have been three reported Engineer, Engine Certification Office, FAA,
Regulatory Findings incidents of PW535A engines leaking fuel in Engine & Propeller Directorate, 12 New
service. Investigation revealed the England Executive Park, Burlington, MA,
We determined that this AD will not
manufacturing process of the fuel manifold 01803; telephone (781) 238–7178; fax (781)
have federalism implications under 238–7199, for more information about this
introduced characteristics that have resulted
Executive Order 13132. This AD will in a loss of sealing at a crimped joint. AD.
not have a substantial direct effect on PW535A fuel manifold leakage that could
the States, on the relationship between Material Incorporated by Reference
result in engine fire, in-flight shutdown or
the national government and the States, damage to the airframe. (j) You must use Pratt & Whitney Canada
or on the distribution of power and Alert Service Bulletin PW500–72–A30314,
Actions and Compliance dated September 27, 2006 to do the actions
responsibilities among the various
(e) Accomplish the following, in required by this AD, unless the AD specifies
levels of government.
accordance with the instructions of P&WC otherwise.
For the reasons discussed above, I Alert Service Bulletin PW500–72–A30314, (1) The Director of the Federal Register
certify this AD: dated September 27, 2006. approved the incorporation by reference of
1. Is not a ‘‘significant regulatory (1) For engines with fuel manifold, part this service information under 5 U.S.C.
action’’ under Executive Order 12866; number (P/N) 3052627–01, that has a total 552(a) and 1 CFR part 51.
time since new (TTSN) of 1500 flight hours (2) For service information identified in
2. Is not a ‘‘significant rule’’ under the or higher: Within 50 flight hours or 60 days this AD, contact Pratt and Whitney Canada
DOT Regulatory Policies and Procedures after the effective date of this AD, whichever Customer Help Desk at 1–800–268–8000.
(44 FR 11034, February 26, 1979); and occurs first, replace fuel manifold, P/N (3) You may review copies at the FAA,
3. Will not have a significant 3052627–01, with a serviceable part. New England Region, Office of the Regional
economic impact, positive or negative, (2) For engines with fuel manifold, part Counsel, 12 New England Executive Park,
on a substantial number of small entities number (P/N) 3052627–01, that has less than Burlington, MA; or at the National Archives
under the criteria of the Regulatory a total time since new (TTSN) of 1500 flight and Records Administration (NARA). For
hours: Within 150 flight hours or 90 days information on the availability of this
Flexibility Act. after the effective date of this AD, whichever material at NARA, call (202) 741–6030, or go
We prepared a regulatory evaluation occurs first, replace fuel manifold, P/N to: http://www.archives.gov/federal-register/
of the estimated costs to comply with 3052627–01, with a serviceable part. cfr/ibr-locations.html.
this AD and placed it in the AD docket. Definition Issued in Burlington, Massachusetts, on
List of Subjects in 14 CFR Part 39 (f) A serviceable part is any replacement November 22, 2006.
part except fuel manifold, P/N 3052627–01. Peter A. White,
Air transportation, Aircraft, Aviation
FAA AD Differences Acting Manager, Engine and Propeller
safety, Incorporation by reference, Directorate, Aircraft Certification Service.
Safety. Note: This AD differs from the MCAI and/ [FR Doc. E6–20204 Filed 12–1–06; 8:45 am]
Adoption of the Amendment or service information as follows:
BILLING CODE 4910–13–P
(1) This AD is applicable to any engine that
■ Accordingly, under the authority has fuel manifold, (P/N) 3052627–01,
delegated to me by the Administrator, installed. DEPARTMENT OF TRANSPORTATION
the FAA amends 14 CFR part 39 as (2) This AD allows replacing fuel manifold
P/N 3052627–01 with a serviceable part as
follows: Federal Aviation Administration
defined in paragraph (f) of this AD.
PART 39—AIRWORTHINESS Other FAA AD Provisions 14 CFR Part 39
DIRECTIVES (g) The following provisions also apply to [Docket No. FAA–2004–19961; Directorate
this AD: Identifier 2004–CE–48–AD; Amendment 39–
■ 1. The authority citation for part 39 (1) Alternative Methods of Compliance
continues to read as follows: 14839; AD 2006–24–10]
(AMOCs): The Manager, Engine Certification
Authority: 49 U.S.C. 106(g), 40113, 44701. Office, FAA, has the authority to approve RIN 2120–AA64
AMOCs for this AD, if requested using the
§ 39.13 [Amended] procedures found in 14 CFR 39.19. Airworthiness Directives; Air Tractor,
(2) Airworthy Product: For any Inc. Models AT–501, AT–502, AT–502A,
■ 2. The FAA amends § 39.13 by adding requirement in this AD to obtain corrective
the following new AD: AT–502B, and AT–503A Airplanes
actions from a manufacturer or other source,
2006–24–08 Pratt & Whitney Canada: use these actions if they are FAA-approved. AGENCY: Federal Aviation
Amendment 39–14837. Docket No. Corrective actions are considered FAA- Administration (FAA), Department of
FAA–2006–26319; Directorate Identifier approved if they are approved by the State Transportation (DOT).
2006–NE–35–AD. of Design Authority (or their delegated
agent). You are required to assure the product ACTION: Final rule.
mstockstill on PROD1PC61 with RULES
VerDate Aug<31>2005 12:11 Dec 01, 2006 Jkt 211001 PO 00000 Frm 00012 Fmt 4700 Sfmt 4700 E:\FR\FM\04DER1.SGM 04DER1