Sunteți pe pagina 1din 11

MYSTERY CALENDAR WORKSHOP Page 1 of 11

MYSTERY CALENDAR WORKSHOP


By Shannon Hebert

Supplies:
PDF Created with deskPDF PDF Writer - Trial :: http://www.docudesk.com

 Tools, Dies, Templates


• Bind-it-All
• Fiscar 1” scallop circle punch
• Stampin Up 1-1/4 ” scallop circle punches
• Stampin Up double circle punch
• Adhesive
• Cricut Cartridge Plantin Schoolbook
 Stamps
• SU – Carte Postal – (May peace and Happiness be yours)
• Stampology – Manhattan Icons
• CTMH – Library Cards, Checklist, Journaling Jots
 Card stock
• (1) 12 X 12 Chipboard
• (1) Light weight chipboard (I use
• (1) 12 x 12 Green Card Stock
• (1) 12 x 12 Brown Card Stock
 Printed Paper or Card Stock
• (4-6) sheet’s of 12 x 12 Printed Paper
 Ink
• Stampin Up – Mellow Moss
• Stampin Up – Chocolate Chip
 Embellishments
• Brown and Cream Brads
• Buttons
• Dimensions
• Green & Brown Grosgrain Ribbon

Tips

© Shannon Hebert – www.northerngirlstamper.blogspot.com


MYSTERY CALENDAR WORKSHOP Page 2 of 11
Instructions: Calendar 5. Sponge the edges of the calendars with Stampin Up’s
1. Cut out you individual calendars leaving ¼” around each Chocolate chip Ink.
edge (I cheat and place the lines against the edge of the 6. Stamp your choice of images on each calendar. I ink the
inside ruler) image and then stamp on a scrap piece to get the faded look
before I stamp my image.
PDF Created with deskPDF PDF Writer - Trial :: http://www.docudesk.com

Place the printed


part against the
ruler and cut

2. Using the Double Stampin Up punch, punch holes in the top


of each corner of your calendars.
3. Cut a piece from Brown Card Stock 5 x 3-¾” 7. Stack all the calendars onto the Brown Card Stock.
4. Line up one of the Calendars in the center of the card stock 8. Cut (2) Pieces of Green Grosgrain Ribbon 8”.
and punch holes to match the calendar holes. 9. Feed the ribbon through from the back to the front for all
pieces.
10. Tie ribbon to form knot, cut at an angle.

© Shannon Hebert – www.northerngirlstamper.blogspot.com


MYSTERY CALENDAR WORKSHOP Page 3 of 11
19. Adhere the Printed Paper to both sides of the chipboard.
11. Print out all the Printable list
12. Cut each one at 3 5/8 x 5 3/8
13. Sponge edges with Stampin Up Chocolate Chip ink
14. Stamp with your chosen images
PDF Created with deskPDF PDF Writer - Trial :: http://www.docudesk.com

20. Cut (4) from light weight chipboard 3-7/8 x 6 (I use the
backing of any Printed Paper pad I have bought).
21. Cut (8) from Printed Paper 3-7/8 x 6.
22. Adhere the printed paper to the light weight chipboard.
15. Cut (4) from Brown Card Stock 3-7/8 x 6 (I cut 2 brown and
2 green).
16. Place your list on the Brown card stock matching closer to
the bottom. Once you have your pieces centered place a
brad in each upper corner. I use brads so that I can keep
adding as I need new list.

23. Cut (1) from the poster Write on/Wipe off poster board 7-¼
x 5-1/4.

17. Cut a 12 x 12 piece of chip board (2) 6 x 12


18. Cut (4) from Printed Paper 6 x 12 (I selected 4 different
styles)

© Shannon Hebert – www.northerngirlstamper.blogspot.com


MYSTERY CALENDAR WORKSHOP Page 4 of 11
30. For the top printed part of the envelope cut (2) at 3-7/8 x 1
on one side you will round the corners with a corner punch.
PDF Created with deskPDF PDF Writer - Trial :: http://www.docudesk.com

24. Stamp with stamps of your choice. (I only stamped in the 31. Adhere to the top of the envelope.
bottom and upper right hand corners) 32. For small pockets cut (2) at 4 x 2 from Card Stock (I cut (1)
25. Cut (1) from Green Card Stock 7-3/4 x 5-3/4. green and (1) brown)
26. Adhere the Write on/ Wipe off piece to the Card Stock. 33. Cut (2) from Printed Paper 3-7/8 x 1-7/8
27. Cut a piece of Brown Grosgrain ribbon 30” tie around both 34. Adhere to the Card Stock.
pieces at the top.

35. Adhere the Write on/Wipe off matted piece to one of the 6 x
28. To create the envelope pockets you will cut (2) from Card 12 pieces of Chipboard.
Stock (I cut (1) green and (1) brown) 4 x 3-1/4. 36. Adhere the Calendar to the side of the Write on/Wipe off
29. Cut from printed Paper (2) 3-7/8 x 3-1/8 adhere to the card Board.
stock.

© Shannon Hebert – www.northerngirlstamper.blogspot.com


MYSTERY CALENDAR WORKSHOP Page 5 of 11
PDF Created with deskPDF PDF Writer - Trial :: http://www.docudesk.com

37. Adhere the envelope pockets and small pockets to the other 39. Using your 1-1/4” Circle Scallop punch, punch (2) from
6 x 12 Chipboard piece. Green Card Stock and (2) from Brown Card Stock.
38. Be sure to only glue the two sides and bottom so that you 40. Print out the Tags
can use it as a pocket. 41. Punch out the tags using the 1” Circle Scallop punch.
42. Sponge the edges of the tags (2) with brown and (2) with
green ink.
43. Stamp an image in the center of the tag.

44. Adhere the printed tags to the Card stock. Set aside for
later.
45. The following steps are for those who have the BIND-IT-
ALL.
46. If you do not have the bind it all you can still bind your
project together with punched holes and ribbon.

© Shannon Hebert – www.northerngirlstamper.blogspot.com


MYSTERY CALENDAR WORKSHOP Page 6 of 11
47. You will just punch the project in different locations along
the top of your project.
48. I will try and make reference where a hole should be
punched and tied off with ribbon.
49. You will place each of the 6 x 12 top parts of the calendar
PDF Created with deskPDF PDF Writer - Trial :: http://www.docudesk.com

into the bind it all and begin to punch (follow manufactures


instructions).
50. I start by placing the bind-it-all in the center of the project
and work from middle to ends when I am punching straight
across.

57. I secured them in place with paper clips.

51. Follow the manufactures directions for lining up your project


to punch across.
52. You will do this for the second piece also.
53. If you will be doing ribbon to bind your project you will not
do anything at this point.
54. The tricky part is coming up. Now that you have the front 58. Now that they are all secure you will flip it over and trace
and back punched you will now line up your list and covers. the back punches onto the list Mat so that you can line the
55. I begin by stacking them on the 6 x 12 punched piece with Bind-It-All up correctly.
the envelopes. 59. Those that are using ribbon you will hole punch each corner.
56. You will want to secure them in place. I spaced each one out Crop-a-dile works best, but if you are like me and do not
2-1/2” own one then a simple paper punch will work. You will just
have to do it in layers.
60. Tie Ribbon in each punched hole. Your project is now bound.
61. Embellish and decorate.

© Shannon Hebert – www.northerngirlstamper.blogspot.com


MYSTERY CALENDAR WORKSHOP Page 7 of 11
PDF Created with deskPDF PDF Writer - Trial :: http://www.docudesk.com

62. Once you have outlined all the way across you can now take 66. Follow manufactories directions for punching across.
the paper clips off. 67. You will do this for each section.
63. You will now punch each section with the Bind-It-All.

68. You will place each of the 6 x 12 pieces back to back for
64. Place the sections 1 at a time still stacked by section into the binding. Then stack each section staggered 2-1/2” apart
Bind-it-All. (You will have (1) cover and (1) matted list). onto the 6 x 12 side with the envelopes on it.
65. You will line the outlined punch lines up to the machine for
correct line up.

© Shannon Hebert – www.northerngirlstamper.blogspot.com


MYSTERY CALENDAR WORKSHOP Page 8 of 11
PDF Created with deskPDF PDF Writer - Trial :: http://www.docudesk.com

69. Place project in Bind-It-All to bind it all together. 76. Cut 3 from printed Paper 3/8” x 2 3/8”
77. Adhere to 3 sides.

70. Now that your project is bound you will now decorate and
embellish it. 78. Adhere to the project.
71. To create the Dry Eraser pen Holder you will cut a piece of 79. I cut Tags out from Planton Cricut Cartridge at 2” and 4”.
Card Stock 2-1/4 x 3. 80. I used the stamp sets CTMH – Library Cards, Checklist,
72. Score on short side @1/2, 1, 1-1/2, 2”. Journaling Jots and adhered them to the tags to be placed in
73. Turn and score @ ½” on long side the envelope pocket holders.
74. Fold score lines and cut slits at the bottom of the box.
75. Assemble box

© Shannon Hebert – www.northerngirlstamper.blogspot.com


MYSTERY CALENDAR WORKSHOP Page 9 of 11
PDF Created with deskPDF PDF Writer - Trial :: http://www.docudesk.com

81. I used tabs I had that went with this paper pack to divide
each section and then adhered my tabs to the top of them.

© Shannon Hebert – www.northerngirlstamper.blogspot.com


MYSTERY CALENDAR WORKSHOP Page 10 of 11
PDF Created with deskPDF PDF Writer - Trial :: http://www.docudesk.com

© Shannon Hebert – www.northerngirlstamper.blogspot.com


MYSTERY CALENDAR WORKSHOP Page 11 of 11
PDF Created with deskPDF PDF Writer - Trial :: http://www.docudesk.com

© Shannon Hebert – www.northerngirlstamper.blogspot.com

S-ar putea să vă placă și