Documente Academic
Documente Profesional
Documente Cultură
Records Administration (NARA). For Contact Empresa Brasileira de operator nor increase the scope of the
information on the availability of this Aeronautica S.A. (EMBRAER), P.O. Box AD.
material at the NARA, call (202) 741–6030, 343—CEP 12.225, Sao Jose dos
or go to http://www.archives.gov/ Costs of Compliance
federal_register/code_of_federal_regulations/
Campos—SP, Brazil, for service
information identified in this AD. This AD will affect about 180
ibr_locations.html.
FOR FURTHER INFORMATION CONTACT: Dan
airplanes of U.S. registry. The required
Issued in Renton, Washington, on May 8, actions will take between 4 and 24 work
2006. Rodina, Aerospace Engineer,
International Branch, ANM–116, hours per airplane, at an average labor
Ali Bahrami, rate of $65 per work hour. Required
Manager, Transport Airplane Directorate, Transport Airplane Directorate, FAA,
1601 Lind Avenue, SW., Renton, parts will cost between $555 and $6,179
Aircraft Certification Service. per airplane. Based on these figures,
[FR Doc. 06–4503 Filed 5–15–06; 8:45 am] Washington 98055–4056; telephone
(425) 227–2125; fax (425) 227–1149. which depend upon airplane
BILLING CODE 4910–13–P configuration, the estimated cost of this
SUPPLEMENTARY INFORMATION: AD for U.S. operators is between
Examining the Docket $146,700 and $1,393,020, or between
DEPARTMENT OF TRANSPORTATION $815 and $7,739 per airplane.
You may examine the airworthiness
Federal Aviation Administration directive (AD) docket on the Internet at Authority for This Rulemaking
http://dms.dot.gov or in person at the Title 49 of the United States Code
14 CFR Part 39 Docket Management Facility office specifies the FAA’s authority to issue
[Docket No. FAA–2006–24120; Directorate between 9 a.m. and 5 p.m., Monday rules on aviation safety. Subtitle I,
Identifier 2006–NM–021–AD; Amendment through Friday, except Federal holidays. section 106, describes the authority of
39–14593; AD 2006–10–09] The Docket Management Facility office the FAA Administrator. Subtitle VII,
(telephone (800) 647–5227) is located on Aviation Programs, describes in more
RIN 2120–AA64
the plaza level of the Nassif Building at detail the scope of the Agency’s
Airworthiness Directives; Empresa the street address stated in the authority.
Brasileira de Aeronautica S.A. ADDRESSES section. We are issuing this rulemaking under
(EMBRAER) Model EMB–120, –120ER, Discussion the authority described in subtitle VII,
–120FC, –120QC, and –120RT part A, subpart III, section 44701,
Airplanes in Operation The FAA issued a notice of proposed ‘‘General requirements.’’ Under that
rulemaking (NPRM) to amend 14 CFR section, Congress charges the FAA with
AGENCY: Federal Aviation part 39 to include an AD that would promoting safe flight of civil aircraft in
Administration (FAA), Department of apply to all Empresa Brasileira de air commerce by prescribing regulations
Transportation (DOT). Aeronautica S.A. (EMBRAER) EMB– for practices, methods, and procedures
ACTION: Final rule. 120( ) airplane models in operation. the Administrator finds necessary for
That NPRM was published in the safety in air commerce. This regulation
SUMMARY: The FAA is adopting a new Federal Register on March 14, 2006 (71
airworthiness directive (AD) for all is within the scope of that authority
FR 13058). That NPRM proposed to because it addresses an unsafe condition
Empresa Brasileira de Aeronautica S.A. require replacing the protective tubes
(EMBRAER) Model EMB–120, –120ER, that is likely to exist or develop on
and conduits of the wiring harnesses of products identified in this rulemaking
–120FC, –120QC, and –120RT airplanes the refueling vent and pilot valves with
in operation. This AD requires replacing action.
non-conductive hoses; modifying the
the protective tubes and conduits of the harness wiring and supports; and Regulatory Findings
wiring harnesses of the refueling vent rerouting the harnesses to prevent We have determined that this AD will
and pilot valves with non-conductive interference with adjacent strobe light not have federalism implications under
hoses; modifying the harness wiring and connectors; as applicable. Executive Order 13132. This AD will
supports; and rerouting the harnesses to not have a substantial direct effect on
prevent interference with adjacent Comments
the States, on the relationship between
strobe light connectors; as applicable. We provided the public the the national government and the States,
This AD results from a fuel system opportunity to participate in the or on the distribution of power and
review conducted by the manufacturer. development of this AD. We received no responsibilities among the various
We are issuing this AD to prevent a comments on the NPRM or on the levels of government.
potential source of ignition near a fuel determination of the cost to the public. For the reasons discussed above, I
tank, which, in combination with certify that this AD:
flammable fuel vapors, could result in a Explanation of Change to Applicability
(1) Is not a ‘‘significant regulatory
fuel tank explosion. We have revised the applicability of action’’ under Executive Order 12866;
DATES: This AD becomes effective June the existing AD to identify model (2) Is not a ‘‘significant rule’’ under
20, 2006. designations as published in the most DOT Regulatory Policies and Procedures
The Director of the Federal Register recent type certificate data sheet for the (44 FR 11034, February 26, 1979); and
approved the incorporation by reference affected models. (3) Will not have a significant
of a certain publication listed in the AD economic impact, positive or negative,
as of June 20, 2006. Conclusion
on a substantial number of small entities
ADDRESSES: You may examine the AD We have carefully reviewed the under the criteria of the Regulatory
cprice-sewell on PROD1PC66 with RULES
docket on the Internet at http:// available data and determined that air Flexibility Act.
dms.dot.gov or in person at the Docket safety and the public interest require We prepared a regulatory evaluation
Management Facility, U.S. Department adopting the AD with the change of the estimated costs to comply with
of Transportation, 400 Seventh Street, described previously. We have this AD and placed it in the AD docket.
SW., Nassif Building, Room PL–401, determined that this change will neither See the ADDRESSES section for a location
Washington, DC. increase the economic burden on any to examine the regulatory evaluation.
VerDate Aug<31>2005 15:11 May 15, 2006 Jkt 208001 PO 00000 Frm 00028 Fmt 4700 Sfmt 4700 E:\FR\FM\16MYR1.SGM 16MYR1
Federal Register / Vol. 71, No. 94 / Tuesday, May 16, 2006 / Rules and Regulations 28257
List of Subjects in 14 CFR Part 39 harnesses with non-conductive hoses; in Issued in Renton, Washington, on May 8,
accordance with Part I of the 2006.
Air transportation, Aircraft, Aviation Accomplishment Instructions of the service Ali Bahrami,
safety, Incorporation by reference, bulletin.
Safety. Manager, Transport Airplane Directorate,
(2) For all remaining airplanes as identified Aircraft Certification Service.
Adoption of the Amendment in paragraph 1.1.2 of the service bulletin:
Replace the protective tubes of the wiring [FR Doc. 06–4502 Filed 5–15–06; 8:45 am]
■ Accordingly, under the authority harnesses of the refueling vent and pilot BILLING CODE 4910–13–P
VerDate Aug<31>2005 15:11 May 15, 2006 Jkt 208001 PO 00000 Frm 00029 Fmt 4700 Sfmt 4700 E:\FR\FM\16MYR1.SGM 16MYR1