Documente Academic
Documente Profesional
Documente Cultură
201
The dimensional tolerances in this table unlw otherwise nOled are based on
practice widely followed by users Ind manufacturers of pressure veueJs.
All tolerances lie inches, unJeu otherwise indicated .
Nowes, (CODtinUed)
h. Deviation from horizont.l, vertical or
the intended position in any
direction.. . . . . . . . . . . .
:!: 1/20
Bue Rlna
. Flatness
+ 1/16
+ 1/'
b. Out of level
CUpa, Brackets
,.
~,
P'l
,
1--'
1\
11
1'+'
13- t-
Saddle
....
...
+ 1/2
,.
..
+ 1/8
1/8
+ 1/8
1/ 32
per Fl.
+ 1/2
+ 1}8
Shell
+ 1/2
+ 1
Omoa - Dmlr! - P
1/4
+ 1/'
J/4
+ 1/2
! 1/8
per 10 ft.
mn.l-l / 2
p. Vessels for internll pressure. T he difference
between the maximum Ind minimum inside
diameters It any cross section shall not exceed
one percent o( the nominal diameter at the
cross section. . . . . . . . . . . . . I ~
+ 1/'
(.
1/8
+ 1/'
+--
Tray Insllllatkm
r. Oul o f level in any direction.
1/32
per Ft.
Tray Support
r. Out of level in any direction .
1/32
per Ft .