Documente Academic
Documente Profesional
Documente Cultură
Binoculars
Unusual Cine
Cine Collection
page 2
literature
About Us
Ask Expert
FAQ
Contact
Picture Film
The projector is fitted with many adjustment knobs from all sides. In this way the projector should be set up in a place
where is free access from all sides.
Pct 4; The electric power knobs &jack for speaker Pict.5; The side of the magnetic film operation
Pct. 6
The projector is fitted with a special security feature - the tension roller. Without film, or in case of film breakage during operation, the tension
roller atomatically cuts off the power supply for the projector mechanism and the projector lamp. This prevents film damage. The supply of the
amplifier is not interrupted however. The projector is automatically switched off when the end of the film passes the sound unit.
The power of the lamp can be adjusted. The lamp can operate at full brightness or at reduced output, extending lamp life (picture 7).
Pict 7;
Rewinding the film, the knob has to be turned to the left - picture 7.
3. The picture side
Making the power connection it has to be insert the bridging plug and adjust the voltage to the locale voltage, using a coin to set voltage.
The sound picture must be threading in the same way as on the picture side, but for double-band operation, the picture film must bear an exact
start mark as follows for the exact synchronization of picture and sound. The film can be treading according to the treading chart with the sound
operating modes (pict.10).
Pict 10; Double-band side with the synchronization threading drawing (on the left side) and threading mode chart (on the right)
Operating mode form magnetic and sound films: SEPMAG; COMOPOT; COMMAG- the double band cable must be connect to the socket - Picture 6;
and a proper push buttons depressed - Picture 2 & 3.
The magnetic film must coming off the reel in a clockwise direction - dull magnetic emulsion on the inside.
5. The projectors body
The projector is very heavy. Without reels it weights 64 lb - 29 kg.
The dimension: H - 12,7 - 322 mm; W - 15,4 - 392 mm; D - 13,2 - 336 mm.
Attention:
If anybody would like to operate the Bauer P6 Studio projector, on all factions, must to have the full operating hand book!!!
Page (1)
Page Back